2022 Acura MDX: harsh or hard shifting

Filed Sep 8, 2026 · Transmission · MA

Heard a loud clunk followed by several small clunks when accelerating. Dealer confirmed the transmission & PTU are damaged and the car is no longer AWD. This issue is becoming more widespread with Acura MDXs and is a very expensive repair. From dealer: “FOUND DRIVESHAFT CAN TURN IN PARK WITHOUT TURNING FRONT WHEELS. THIS INDICATED TRANSMISSION AND PTU SPLINES ARE DAMAGED”

Filed Jul 14, 2026 · Transmission · SC

The car made a clunk sound while driving and wouldn't accelerate. After coming to a stop and trying to take off, the car still had difficulty accelerating. After turning the car off and back on everything appeared fine. The loss of acceleration was unexpected and there were no warning lights or indication of an issue. The lack of ability to accelerate along with the clunk sound caused unnecessary safety risks by not allowing the car to maneuver out of danger and disrupting the flow of traffic unexpectedly. The car then began leaking oil. The Acura dealership noted that the oil was transmission and power transfer unit oil and the car no longer has all wheel drive but only front wheel drive. The loss of all wheel drive without any indication or warning is a serious safety issue because it affects all aspects of drivability (handling, acceleration, traction). They said over time the splines of the power transfer unit input shaft rust and then sheer off which causes metal to damage the transmission seal and power transfer unit seal. The service manager said this was a known issue due to bad engineering and there is no way to prevent it. The vehicle is unchanged since the incident and can be inspected.

Filed May 12, 2026 · Transmission · MO

I own a 2022 Acura MDX SH-AWD with approximately 85,000 miles. The issue began suddenly while driving around 5 mph when two loud bangs were heard from the rear drivetrain/transfer case area. After the initial incident, the vehicle was driven home, and the problem became consistently noticeable during any acceleration from a stop or low speed. The drivetrain would clunk/slip during acceleration and exhibited abnormal engagement behavior. Due to concern about causing further drivetrain damage or a potential safety issue, the vehicle was subsequently towed to an Acura dealer for diagnosis. The Acura dealer confirmed that both the transfer case and transmission require replacement due to “worn teeth on splines.” The repair estimate specifically states: “REPLACE TRANSFER CASE AND TRANSMISSION DUE TO WORN TEETH ON SPLINES.” Estimated repair cost is approximately $11,400. I have photographs and repair documentation related to the failure. This failure created a potential safety concern because the drivetrain was no longer operating normally and produced loud clunking/slipping during acceleration from stops and low speeds. A drivetrain or power transfer failure could increase the risk of loss of propulsion or inability to accelerate normally into traffic. The issue was reproduced and confirmed by the Acura dealer. The vehicle has been regularly maintained, including drivetrain fluid services, through Acura/Honda service facilities. There were no warning lights, dashboard messages, or electronic indications before or after the failure event. The only indication was the loud banging noise from the drivetrain/transfer case area and the resulting abnormal drivetrain behavior during acceleration. The service manager also indicated they had seen several similar cases involving this issue.

Filed Apr 13, 2026 · Transmission · VA

Complete drivetrain failure while accelerating from a complete stop in the middle of a busy intersection. No warning lights or hazard messages were activated before or after the failure. The car made a massive clunking/banging sound and continued to clunk on acceleration. The car had to be towed to the dealership. My children were in the car with me, and we had just driven on the highway for 45 minutes before this failure. Luckily, my husband was behind me, and I activated hazards until I could pull over safely. It was jerking and clunking so badly that I was barely able to steer. It was terrifying since my two young children were in the car, and they were both screaming from the noise. I believe I would have been rear-ended if my husband had not been behind me due to the sudden jerk from the failure, as I was the first car in the left turn lane. This is not the first issue I have had with the transfer case in this vehicle. The affected transfer case and drive train were replaced only 7 months prior due to a faulty transfer case and a severe clunking sound. This vehicle has had repeated drivetrain failures without warning, resulting in loss of traction and control. The recent failure reflects a completely stripped spline connecting the transfer case and transmission. This will be the 4th transfer case this vehicle has had at only 64K miles. All recommended maintenance and care have been completed at the certified Acura dealership since the vehicle was purchased. Recently, the 60K services were completed just 3 months prior to the current failure. The vehicle is currently at the dealership for repairs under warranty, as it needs a new transmission and another transfer case. I have not yet received the documentation, as the car is not in my possession, but I will provide it once I receive it. See the attached documentation from the previous failure, dated 6/3/2025, to establish a pattern of catastrophic drivetrain failure.

Filed Apr 12, 2026 · Transmission · SC

I was at a stop light, when the lights turned green, I accelerated and heard a loud bang underneath the vehicle. The sound was so loud I thought I had been rear ended. I got out to inspect the vehicle and did not see any damages. I got back into the vehicle and put it in drive to get to the closed gas station. When I started driving, I heard clunking sounds underneath vehicle. I put on my hazards and drove slow. After about 50-100 ft the clunking sounds went away. No lights on the dash or anything. I then got vehicle towed to my father’s shop to inspect what was going or what happened due to not feeling safe driving. One of his employees looked up the cause of the noise and had found that the differential splines or transfer case would strip and cause a loud bang. Which happens on a lot of these acuras. He put vehicle on lift, and put it into drive. The front wheels would spin, but not the rear wheels. He said that indicates the transfer case is bad

Filed Mar 19, 2026 · Transmission · PA

In January of 2026, when driving under normal conditions, the 2022 Acura MDX made a loud clunking noise and power was temporarily disrupted. The vehicle had to be stopped on the side of the road as the clunking noise persisted. This occurred on a major highway and put the driver and passengers at risk as we had to quickly get to the shoulder. After inspecting the vehicle for any visible signs of damage we continued home without issues. Now, March of 2026, we took the car for routine service and was contacted by the dealership and informed the transfer case and transmission needed to be replaced. The dealership indicating they were in contact with Honda USA to see what they could do for us. A quick search of the Internet revealed the federal safety agency DP26001, so we now know this issue has occurred on many Acura MDX's of the same year. No warning lamps illuminated. We were unaware that the vehicle was running in 2erWD instead of 4WD. There were no warnings leading up to the event.