2019 Alfa Romeo Giulia fuel system problems

Filed Sep 26, 2026 · Engine, Fuel system · CA

No remedy for the already existing recall Turbo o ring wears out leaking oil Sensor issues front go off due to license plate cover While in n drive the car does not engage auto stop/start

Filed Aug 27, 2026 · Fuel system · AZ

1. The fuel delivery/fuel pressure system is malfunctioning. The vehicle has experienced fuel-pressure related diagnostic trouble codes, loss of power, stalling, and limp mode. The fuel pressure sensor was replaced, but the same diagnostic codes and symptoms continued. The symptoms are consistent with the fuel delivery module/fuel pump defect described in the federal safety agency recall 25V586. The vehicle and affected components are available for inspection upon request. 2. The vehicle repeatedly enters limp mode and has experienced loss of power, stalling, and severe shifting problems, especially with low fuel. I have had to drive 20–30 miles on the freeway while unable to accelerate or shift normally, nearly causing multiple accidents around traffic and semi-trucks. I regularly transport my family and children, greatly increasing the safety risk from an unexpected loss of power or stalling. 3. No. The problem has not been reproduced or confirmed by a dealer or independent service center. However, the vehicle has experienced repeated loss of power, stalling, limp mode, and shifting problems, along with the same two fuel-pressure related diagnostic trouble codes. The fuel pressure sensor was replaced, but the codes and symptoms remained. 4. No. The vehicle has not been inspected by the manufacturer, police, or an insurance representative. 5. Yes. The check-engine light appeared with codes P018D and P018B. The vehicle subsequently experienced limp mode, loss of power, stalling, and severe shifting issues, especially with low fuel. Replacing the fuel pressure sensor did not resolve the codes or symptoms.

Filed Aug 5, 2026 · Fuel system · TN

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated that while exiting a gas station, the vehicle shut off with the "Check Engine" and "Service Electronic Throttle Control" messages displayed. The manufacturer was made aware of the issue but offered no assistance. The vehicle was not repaired. The failure mileage was unknown.

Filed Jul 1, 2026 · Electrical, Engine · GA

The vehicle is subject to Alfa Romeo Safety Recall 93C (the federal safety agency Campaign 25V586) for a defective Fuel Delivery Module. The safety defect is an active, un-remedied hazard. The vehicle is currently located at [Name of Alfa Romeo Dealership] for an official diagnosis and is available for inspection. The vehicle has an active safety recall for sudden, catastrophic engine stalling at highway speeds due to fuel pump warping. Because the manufacturer has not provided a remedy or a safe alternative transport, I am forced to choose between driving a vehicle with an acknowledged highway-stalling hazard or being completely deprived of my transportation. The vehicle cannot be safely operated in commerce until Recall 93C is performed. The vehicle is currently undergoing inspection by the manufacturer's authorized technicians at the Alfa Romeo dealership. It has also been reviewed administratively through a claim with the National Center for Dispute Settlement (NCDS), which was denied based on mileage despite the active federal safety recall. The vehicle displayed an "Excessive Oil" warning and experienced heavy smoking from the engine bay beginning around June 25, 2026. While the vehicle has also been undergoing cooling system repairs, the presence of these severe engine warnings and thermal symptoms creates an immediate escalation of risk when combined with the active 93C fuel pump recall.

Filed Jun 9, 2026 · Fuel system · 22,000 miles · AZ

The contact owns a 2019 Alfa Romeo Giulia. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle hesitated before accelerating as intended. No warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received a recall notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts required for the recall repair were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,000.

Filed Jun 6, 2026 · Engine, Fuel system · FL

Check engine light, electronic throttle control warning, and auto start/stop warning lights illuminate intermittently. OBD scan revealed codes P018B and P018D (Fuel Pressure Sensor B Circuit). Freeze frame data shows fuel rail pressure at 20,030 kPa under full throttle load, significantly below expected range. Engine running lean with short term fuel trim at +11.7%. Dealer and FCA confirmed awareness of fuel pump recall 93C covering this vehicle but no remedy currently available. Vehicle poses stall risk under acceleration

Filed Apr 14, 2026 · Fuel system · IL

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Filed Apr 9, 2026 · Fuel system · 160,000 miles · NC

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle went into LIMP Mode and stalled. The check engine warning light was illuminated. The vehicle was able to be restarted. The vehicle was taken to Firestone, and an oil change was performed, and the cabin air filter and water pump were replaced; however, the failure persisted, with the check engine, engine oil, and several other unknown warning lights intermittently illuminated. The vehicle was then taken to an independent mechanic, who determined that the fuel pump had low pressure and needed to be replaced. The dealer was made aware of the failure but informed the contact that there would be a charge for a diagnostic test. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

Filed Feb 13, 2026 · Fuel system · 100,000 miles · CA

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the check engine warning light and several unknown warning lights illuminated, and the vehicle unintendedly shifted to neutral(N) and lost motive power. The contact pulled over to the side of the road, turned off, and restarted the vehicle; however, there was a delay before the vehicle reached 35 MPH while driving. The contact stated that after refueling the vehicle, the warning lights turned off. The failure reoccurred whenever the fuel level was low. The dealer was notified of the failure and informed the contact that the failure was related to the fuel pump, but the part to do the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, and the contact was advised to wait for the second recall notification to proceed with the scheduling of the recall repair. The failure mileage was approximately 100,000.

Filed Jan 27, 2026 · Fuel system · CA

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact expressed safety concerns. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.