2018 Alfa Romeo Stelvio: fuel pump failure

Filed Nov 5, 2026 · Fuel system · AZ

My vehicle was subject to recall 93C for the fuel delivery module. Before the recall repair I had Auto Start/Stop Disabled, Service Electronic Throttle, Service Parking Brake, Check Engine Light, limp mode, and unexpected shutdowns. Bill Luke Tempe Alfa Romeo replaced the fuel pump on September 29, 2026, and the vehicle was ready September 30, 2026. The same warnings and shutdowns continued after the repair. On October 23, 2026, at approximately 93,400 miles, while driving to Walmart, I attempted a U-turn. The vehicle went into limp mode with the same warnings and completely shut down in the middle of the turn. I was able to restart it temporarily and move it to a Circle K parking lot, but when I tried to pull into a parking space it would not start. It was towed to my home in Tucson and has remained inoperable since. No crash, no injury, and no fire occurred. The loss of power while turning was a serious safety risk.

Filed Sep 11, 2026 · Fuel system, Seat belts · UT

My 2018 Alfa Romeo Stelvio has a safety recall, due to a faulty fuel pump. I have attempted to work with the Alfa Romeo customer support team to try and have my vehicle fixed, but they have not been able to make practical arrangements to have the vehicle serviced. I live in [XXX]. Initially, I was informed that although there were no local Alfa Romeo dealerships in [XXX], there were some partner Jeep Chrysler Dodge dealerships that could handle the repair. However, I was then informed that these dealerships were no longer being compensated from Alfa Romeo, so I would actually need to work with an actual Alfa Romeo dealership. The closest dealership is in [XXX], which is over 400 miles away. I was then told that Alfa Romeo would arrange towing my car to and from the dealership in [XXX]. The parts were ordered and after a few weeks, the parts are now available. However, in the meantime, Alfa Romeo has again changed their policy to provide towing services. I have been informed that they will make an exception and tow my vehicle to the dealership, but then I would be responsible to arrange to pick up the vehicle from the dealership. This would require me to either drive a rental vehicle or purchase a plane ticket at my expense, in order to obtain the vehicle. Alfa Romeo has issued the safety recall, but is not providing a timely or effective option of actually taking care of the repairs without requiring a significant cost to the consumer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 27, 2026 · Electrical, Engine · VA

I am reporting an authorized manufacturer franchise dealer for actively refusing to remedy a federal safety recall and unlawfully withholding my vehicle. My vehicle is a 2019 Alfa Romeo Stelvio (VIN: [Insert VIN]), which is subject to the active Fuel Pump Safety Recall (the federal safety agency Campaign 25V586000 / Manufacturer Recall Code 93C). The vehicle has been physically located at Southern Alfa Romeo of Norfolk ([XXX]) for approximately 18 months. The dealership service management has explicitly stated that they will not perform the mandatory safety recall remedy, nor will they release my vehicle to a flatbed towing company, until an unrelated $5,000 civil dispute involving a loaner car is paid out of pocket. By conditioning a federal safety mandate and the physical custody of my vehicle on a separate civil debt, this dealership is violating the National Traffic and Motor Vehicle Safety Act (49 U.S.C. Chapter 301). The 1.5-year delay also completely violates the federal requirement to provide a safety remedy within a reasonable timeframe. I request federal intervention to force compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 31, 2026 · Fuel system · AZ

There is no fix for this. The fuel pump foe the Stelvio is recalled almost a year ago. The engine light comes on and the car is undriveable. I have paid for 2 new fuel pumps and control module (out of pocket) , and the check engine light will come back after a few weeks. The car is basically inoperable and bricked because of this, and Alfa has not resolved it. They should not be allowed to drag a recall out for years while owners suffer, and are in danger. Please hold Alfa Romeo accountable. It just happened again today (7/31/26) while my wife was on the highway. This is after paying thousands and thousands to resolve this whole Alfa Romeo doesn’t do anything to fix it. We are out of options.

Filed Jul 22, 2026 · Fuel system · 80,000 miles · FL

The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that while driving at slow speeds, the vehicle hesitated, shuddered, and jerked while depressing the accelerator pedal. The messages "Service Engine Soon," "Service Electronic Throttle," and "Low Fuel Pump Pressure" were displayed. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the failure was associated with the recall; however, the dealer confirmed that parts were unavailable, and there was no timeline for parts availability. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 80,000.

Filed Jul 14, 2026 · Fuel system · MD

THIS IS A FOLLOW UP TO MY PREVIOUS COMPLAINT, 11737275 AS THE VEHICLE HAS NOW DEGRADED TO PERSISTENT ACTIVE STALLING. This is a follow-up to my previous complaint 11737275 as the vehicle has now degraded to persistent active stalling. The failed component is the fuel pump assembly under active safety recall the federal safety agency 25V586 (Mopar 93C), and the un-remedied vehicle is completely available for physical inspection upon request. Safety is severely compromised as the vehicle experiences extreme drops in RPM, engine choking, and sudden stalling immediately after fueling because the failing, recalled pump cannot maintain proper pressure to compensate for standard EVAP canister vapor purging cycles. This dangerous driveability defect has been formally brought to Criswell Alfa Romeo, where service staff confirmed the failures but stated they cannot perform the remedy because the redesigned factory replacement component is currently unavailable. While the vehicle remains open for full review by any designated authority, it has not yet undergone formal inspection by the manufacturer, local law enforcement, or insurance investigators. The symptoms first manifested in 2021 immediately before the safety recall campaign became public knowledge, and the vehicle has suffered from these chronic, hazardous failures ever since. The manufacturer's technical summary states that 2017–2019 Alfa Romeo Stelvio vehicles may experience a loss of motive power due to a heat-susceptible fuel delivery module (FDM) losing flow rate, which FCA US will remedy by conducting a voluntary safety recall to replace the FDM with a newly updated Pump Electronic Module (PEM). My vehicle is a 2018 Alfa Romeo Stelvio TI.

Filed Jul 6, 2026 · Electrical, Fuel system · FL

My vehicle has been subject of multiple recalls, however the current recall is a significant one and has been pending for months with no end in sight. I am concerned The manufacturer and dealers are not taking this seriously and the delay is causing additional damage to my vehicle. Additionally quickly googling my vehicle will show that it has fuel pump and acceleration jerking and lag issues that are extremely, extremely, common and troubling. I am also still having the service engine soon issues described in recalls and other forums related to throttle cable. Either none of this has been addressed by the manufacturer or the repairs so far have not been sufficient if it is still so common. On behalf of all Stelvio owners I demand these recalls and issues be addressed in a timely manner. This is going to cost us additional grief, safety issues, and repair costs. The biggest being my safety and my family's safety when we are riding in this vehicle, the acceleration issues are very noticeable and are getting worse. The symptoms are -exactly-what is described online and also as part of the recall. I don't even have the option to get it fixed there is no parts to fix available. This is a very nice vehicle, but this is getting old not having repairs done and the dealers running out of parts etc. Waiting months and months for repairs. - Fiat, Alfa Romeo and their dealerships do not seem to be taking this seriously - at all, they should have pride in their products like the owners do when we buy them. I want my Stelvio to be the best it can be, fully safe, and fully functional.

Filed Jun 16, 2026 · Engine, Fuel system · 62,000 miles · CO

The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of the federal safety agency Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while driving 45 MPH and merging onto the highway, the vehicle entered Low Power Mode, forcing the contact to pull over to the side of the road. The contact then drove to the residence, where the vehicle was turned off and restarted, and the messages "Service Engine" and "Service Throttle Control" were displayed. The vehicle was taken to the dealer, where the fuel system was bled. The dealer later informed the contact that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the high-pressure fuel pump and the fuel delivery module (FDM) were replaced in July 2025. The contact related the failure to the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 62,000.

Filed Jun 16, 2026 · Electrical, Fuel system · CA

I was driving and the car gave an error showing service throttle position. Car went into limp mode. I pulled over out of traffic. Car drove but very slow. I tried to drive back home but the car died while I was in the turning lane. It would not start again. I used my autel scanner and received codes, p01ca, p008a, p00c6, p0300, p0303, p0302. I believe it is the fuel pump and fuel pump module causing the car issues. I believe it is the 93c recall for this car. It would have been very unsafe if I was driving on the highway and this happen. The car is currently at Champion Alfa dealership. I’m waiting for the service department to get back to me. I hope the dealership or Alfa Romeo will cover the repairs cost since it is a pending recall.

Filed May 10, 2026 · Fuel system · FL

I took the vehicle to Auto Zone for a basic diagnostic and it came back that the fuel pump is failing and defective. I only recently purchased the vehicle and found that there’s a recall on it for this reason. The yellow check engine light came on and it stalled while driving home.

Filed Mar 30, 2026 · Fuel system · 93,200 miles · NY

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked, the vehicle was started and was shaking abnormally with the check engine warning light illuminated. The vehicle then shut off unexpectedly. The vehicle was towed to an independent mechanic where it was diagnosed with fuel pump failure. The contact was informed that the failure was caused by an unrepaired recall. The vehicle was not repaired. The contact was informed that parts were not available for the repair. The dealer was made aware of the failure, and the contact was informed that parts were not available for the repair. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part for the recall repair was unavailable. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 93,200.

Filed Feb 17, 2026 · Electrical, Engine · KY

November 26th my car went into LOMP mode. But then restored itself. December 3rd my car went into LOMP mode again and had not recovered along with a slew of ALARMS. I have been using uber and rental cars since this issue. Highly likely this is a fuel pump issue but unable to determine as the authorized shop is 2hours away and the car will not make it there. I need a remedy I have been out of a car for months now and the recall has no remedy!