Alfa Romeo Stelvio won't shift problems

Filed Nov 5, 2026 · Fuel system · AZ

My vehicle was subject to recall 93C for the fuel delivery module. Before the recall repair I had Auto Start/Stop Disabled, Service Electronic Throttle, Service Parking Brake, Check Engine Light, limp mode, and unexpected shutdowns. Bill Luke Tempe Alfa Romeo replaced the fuel pump on September 29, 2026, and the vehicle was ready September 30, 2026. The same warnings and shutdowns continued after the repair. On October 23, 2026, at approximately 93,400 miles, while driving to Walmart, I attempted a U-turn. The vehicle went into limp mode with the same warnings and completely shut down in the middle of the turn. I was able to restart it temporarily and move it to a Circle K parking lot, but when I tried to pull into a parking space it would not start. It was towed to my home in Tucson and has remained inoperable since. No crash, no injury, and no fire occurred. The loss of power while turning was a serious safety risk.

Filed Aug 18, 2026 · Engine · 120,000 miles · ME

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving 30 MPH and depressing the accelerator pedal, several unknown warning lights were illuminated, before the vehicle went into LIMP Mode. The contact stated that there was a rattling sound coming from the turbo charger. A dealer was contacted. The vehicle was diagnosed, and it was determined that the turbo charger needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.

Filed Aug 11, 2026 · Fuel system · SC

Car stalled/ went into limp mode 4 separate times for fuel pressure issue. Is not drivable, does not accelerate, throws erroneous error codes. The recall Y91 covers this issue for 2020 Stelvio. When I contact Mopar they say it is not open on my vin. How is this possible?

Filed Jul 22, 2026 · Fuel system · CT

I was told I was on a priority list to have this recall fixed. My Stelvio is virtually undrivable. It continues to lose power when acceleration and goes into limp mode. I refuse to take the Stelvio onto the highway as it poses a danger to myself and passengers. This recall has been active for well over a year with a continual push back on the remedy date. Recall 93C (the federal safety agency 25V‑586) causes a failure in the fuel delivery system which compromises acceleration and will frequently, without warning lose power as well as trip the a throttle delivery system warning light. This is a freaking joke to them. They refuse to take ownership over this recall and people are going to get into accidents.

Filed Jun 16, 2026 · Electrical, Fuel system · CA

I was driving and the car gave an error showing service throttle position. Car went into limp mode. I pulled over out of traffic. Car drove but very slow. I tried to drive back home but the car died while I was in the turning lane. It would not start again. I used my autel scanner and received codes, p01ca, p008a, p00c6, p0300, p0303, p0302. I believe it is the fuel pump and fuel pump module causing the car issues. I believe it is the 93c recall for this car. It would have been very unsafe if I was driving on the highway and this happen. The car is currently at Champion Alfa dealership. I’m waiting for the service department to get back to me. I hope the dealership or Alfa Romeo will cover the repairs cost since it is a pending recall.

Filed May 22, 2026 · Fuel system · 70,000 miles · GA

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly entered limp mode, with the start/stop warning light illuminated and a “Throttle Unavailable” warning message displayed. The contact also stated that the vehicle failed to properly accelerate. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts required for the recall repair were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 70,000.

Filed Apr 21, 2026 · Fuel system · 95,000 miles · OH

The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving, the vehicle failed to exceed 60 MPH and the vehicle went into LIMP Mode. The vehicle was taken to the dealer, and the failure was associated with the recall and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.

Filed Apr 1, 2026 · Engine, Fuel system · TX

I experienced an unexpected Loss of Motive Power (LOMP) event. Late afternoon traffic was fast, estimate 75-80 MPH. I attempted to change lanes get to the righthand shoulder and was very nearly involved in a high-speed collision with a semi-petroleum tank truck. He applied his brakes to avoid hitting me and started to jackknife, but regained control and continued. The truck missed by inches. At this point I had NO remaining power and was essentially coasting until I managed to cross the remaining two lanes of traffic to the shoulder emergency lane. I reset the error codes and continued home with no further occurrences. The incident produced the following warning lamps: Electronic Throttle Control Failure, Start/Stop System Failure and Check Engine, then a few seconds later the Limp Mode/LOMP event. I carry an OBD Scanning Tool with me to be able to clear the error codes when I encounter them. They are typically a cascading event that can result in LOMP. I have experienced a total of 26 of these error lamp events since 4/19/22 which have resulted in 3 LOMP's. The remaining 23 events I was able to reset before the inevitable LOMP. This is the first LOMP that nearly caused a fatal accident, the remainder I was able to safely find a place to stop to perform the resets. There is an active Manufacturer Recall Number93C, the federal safety agency Recall Number25V-586 that may cover this issue. The Recall Status is "Incomplete, remedy not yet available." The Alfa Romeo dealership has noted the P0191-00 error and replaced the fuel pressure sensor on 2/23/23, but this did not solve the problem. Owner's forums, and now the Manufacturer/the federal safety agency recall have reported this as a known problem, so I have been clearing my own error codes in order to at least have a car to drive. In my mind, this nuisance has now become a potentially very dangerous condition.

Filed Sep 24, 2025 · Electrical, Engine · MD

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The low-pressure fuel pump (fuel delivery module) appears to be failing, consistent with Recall 25V‑586 / Alfa Romeo Campaign 93C. This causes fuel starvation and loss of motive power. 2. How was your safety or the safety of others put at risk? The vehicle has experienced loss of motive power (LOMP) while driving. At times it jerks or hesitates when accelerating from a stop, and while climbing a hill it suddenly lost power, displayed a Service Electronic Throttle warning, and went into limp mode. This created a risk of being unable to accelerate safely in traffic, increasing the chance of being rear-ended or unable to merge. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. I described the symptoms to Alfa Romeo Service dept, and they told me it is related to the recall and that other customers have reported the same symptoms and warning lights. However, they advised that there is currently no remedy available, and I must wait for the fix before scheduling an appointment. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. Alfa Romeo advised that no remedy is available at this time, so the vehicle has not been formally inspected by the dealer or manufacturer. Advised not to drive long distances until fix determined. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check Engine Light and Service Electronic Throttle came on as car lost power and entered limp mode with code P0299. Alfa Romeo Service Dept tech said these warnings match the recall. Rep said this shows how loss of motive power from fuel starvation manifests electronically & ECU interprets fuel starvation as underboost, which then triggers limp mode.

Filed Jun 17, 2024 · Acceleration, Electrical · NY

I was in the process of merging on the the express way when my vehicle threw a warning light, "service electronic throttle control" along with a "service engine" message and a check engine light. The vehicle went into a "limp" and had extremely poor acceleration, I was almost rear ended because the vehicle couldn't reach highways speeds fast enough. The vehicle has not yet been inspected my the manufacturer but I did some research on this issue and found it to be alarmingly common. There seems to be no clear answer to the reason for this and no sure repairs for the problem. This poses a safety risk to drivers as this problem seems to happen while accelerating. It can be dangerous if someone on the expressway is attempting to merge into 60mph traffic and hit "limp mode" at roughly 30. I believe an investigation need to be conducted regarding this followed by a recall of the affected part.