2005 Bigdog Mastiff recalls

There are 8 safety recalls on record for the 2005 Bigdog Mastiff, covering 37,416 vehicles in total across all the models in each campaign. Newest first.

All recalls

Structure: bodyReported December 18, 2007 · 8,061 vehicles affected

What is wrong: On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Risk: This could occur without prior warning and could result in an injury or a crash.
Remedy: Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on january 21, 2008. Owners may contact big dog at 316‑267‑9121.

Recall number 07V580000 · Recall details

Electrical system: alternator/generator/regulatorReported August 8, 2007 · 7,611 vehicles affected

What is wrong: On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit.
Risk: This could possibly result in a fire.
Remedy: Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (b+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. The recall began on october 1, 2007. Owners may contact big dog at 1‑316‑219‑9129 or email to [email protected].

Recall number 07V356000 · Recall details

StructureReported October 12, 2006 · 2,494 vehicles affected

What is wrong: On certain motorcycles, the long pivot bolt may bend or break during normal operation of the motorcycle.
Risk: This could potentially cause the rear fender to abrade against the rear tire while the motorcycle is being driven. This condition could occur without any prior warning and could result in a crash.
Remedy: Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced free of charge. The recall began on november 1, 2006. Owners may contact big dog at 316‑267‑9121.

Recall number 06V389000 · Recall details

Electrical systemReported August 11, 2006 · 2,101 vehicles affected

What is wrong: On certain motorcycles, the electronic harness control (ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Risk: This condition could occur without any prior warning and could result in a crash.
Remedy: Dealers will replace the ehc modules free of charge. The recall began on september 19, 2006. Owners may contact big dog at 316‑267‑9121.

Recall number 06V305000 · Recall details

Electrical system: ignition: moduleReported August 9, 2006 · 2,711 vehicles affected

What is wrong: On certain motorcycles, the ignition modules are oriented within the battery tray in a way that makes the ignition module susceptible to vibration.
Risk: This susceptibility to vibration may contribute to a stalling condition that could occur without any prior warning and result in a crash.
Remedy: Dealers will install a new ignition module mounting system free of charge. The recall began on august 25, 2006. Owners may contact big dog at 316‑267‑9121.

Recall number 06V301000 · Recall details

Structure: motorcycle: kickstand/center standReported January 25, 2006 · 9,726 vehicles affected

What is wrong: On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Risk: This will allow the kickstand to deploy into the extended position and cause a crash.
Remedy: Dealers will install a new kickstand spring free of charge. The recall began on february 17, 2006. Owners may contact big dog at 316‑267‑9121.

Recall number 06V019000 · Recall details

Wheels: lugs/nuts/bolts/studsReported September 28, 2005 · 3,294 vehicles affected

What is wrong: On certain motorcycles, the rear wheel hub bolts could loosen and back out allowing the hub and brake rotor to detach from the wheel with an associated loss of stopping power.
Risk: This condition could occur without any prior warning and could result in a crash.
Remedy: Dealers will remove, clean and reattach the rear hub bolts free of charge. The recall began on october 14, 2005. Owners may contact big dog at 1‑312‑267‑9121.

Recall number 05V432000 · Recall details

Power trainReported April 14, 2005 · 1,418 vehicles affected

What is wrong: On certain motorcycles, the primary drive sprocket nut may back off the engine main shaft.
Risk: This could cause the primary drive to lock up and cause a crash. This condition could occur without any prior warning.
Remedy: Dealers will inspect and replace the drive sprocket nut free of charge. The recall began on may 13, 2005. Owners may contact big dog at 316‑267‑9121.

Recall number 05V149000 · Recall details

Questions about the 2005 Bigdog Mastiff recalls

How do I check if my 2005 Bigdog Mastiff has an open recall?

Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.

Do I have to pay for a recall repair?

No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.

How many recalls does the 2005 Bigdog Mastiff have?

8, covering structure, electrical system and wheels.

VIN decoder

See the problems and recalls for an exact car

Buying a used 2005 Bigdog Mastiff?

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.

Check its history