2022 Blue Bird Vision School Bus problems

What is wrong

Blue Bird Bus Company (Blue Bird) is recalling certain 2022-2027 Vision school buses. The exhaust hanger cotter pin may contact the hydraulic brake line, damaging the line and causing a brake fluid leak.

Risk

A brake fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire. Additionally, a brake fluid leak can extend the distance required to stop, increasing the risk of a crash.

Remedy

Dealers will replace the exhaust hanger cotter pin. Dealers will also inspect and replace the brake lines as necessary. All repairs will be performed free of charge. Owner notification letters were mailed September 17, 2026. Owners may contact Blue Bird customer service at 1‑478‑822‑2242.

Recall number 26V466000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk

An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

Remedy

Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478‑822‑2242. Blue Bird's number for this recall is R23CK (SB).

Recall number 24V758000 · Recall details

What is wrong

Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

Risk

Roof panels that separate during a crash can increase the risk of injury.

Remedy

Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1‑478‑822‑2242.

Recall number 24V543000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2023 Vision school buses. The diesel tank that supplies the fuel fired heater was improperly designed and may leak fuel. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."

Risk

A fuel leak onto the road creates a hazard for other road users, increasing the risk of a crash. Additionally, a fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will repair the tank, free of charge. Owner notification letters were mailed July 08, 2024. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R24DA.

Recall number 24V365000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2024 Vision 2020-2023 All American school buses. The convertible seats may have been incorrectly installed, which can result in an unsecured seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk

An unsecured seat may not adequately restrain an occupant, increasing the risk of injury during a crash.

Remedy

Dealers will inspect and repair the seat, free of charge. Owner notification letters were mailed March 04, 2024. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R24CM-SB.

Recall number 24V078000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 Vision school buses. Firmware in the multiplex module may cause the warning lights to deactivate and the stop arm to retract without warning.

Risk

An unintended deactivation of the warning lights and retraction of the stop arm during use increases the risk of a crash or injury.

Remedy

Dealers will update the multiplex firmware, free of charge. Owner notification letters were mailed March 25, 2024. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R24CX (SB).

Recall number 24V068000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 All American and 2021-2022 Vision school buses. A software error in the instrument cluster may cause the air pressure gauges and the visual and audio low air warnings to not function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk

Air gauges and warnings that do not alert the driver to air pressure loss can result in driving without functioning brakes, increasing the risk of a crash.

Remedy

Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed July 27, 2023, 2023. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R23CH (School Bus).

Recall number 23V425000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision school buses equipped with a 7.3L gasoline engine. The transmission cable may not have sufficient clearance from the gasoline fuel supply line at the left rear corner of the engine, which can result in a fuel leak.

Risk

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will inspect and reroute the transmission cable, free of charge. Owner notification letters were mailed February 9, 2023. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R22CB (School Bus).

Recall number 22V739000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk

A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy

Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R22BX-NSB.

Recall number 22V578000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2017-2023 Blue Bird Vision school buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The zinc-plating on the fuel return line may break away when contacted by road debris, causing two dissimilar metals on the fuel line to contact each other and corrode.

Risk

A corroded fuel line can leak fuel, increasing the risk of a fire.

Remedy

Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R22BX-SB.

Recall number 22V579000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.

Risk

An improperly grounded air compressor can cause electric shock, increasing the risk of injury.

Remedy

Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R22BY-SB.

Recall number 22V505000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision school buses. The fuel supply line was incorrectly routed, allowing it to chafe against a bolt head, which can damage the line and create a fuel leak.

Risk

A fuel leak increases the risk of a fire.

Remedy

Dealers will reroute the fuel line, and replace the fuel line if any damage is found, free of charge. Owner notification letters are expected to be mailed on June 21, 2022. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R22BU-SB.

Recall number 22V274000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2022 Vision school buses equipped with Ford 7.3L engines. The retaining clamp used to secure the hydraulic brake line near the engine may not have been installed, which could cause the brake line to rub which could cause a brake fluid leak and result in a loss of brake function.

Risk

Loss of braking ability increases the risk of a crash.

Remedy

Dealers will inspect the hydraulic brakes lines, and install any missing hardware, free of charge. Owners letters were mailed on November 30, 2021. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R21BN-SB.

Recall number 21V778000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2022 Vision school buses equipped with cross-view mirrors and a Mobileye collision mitigation system. Due to the current placement of the Mobileye camera, the camera could partially or fully obstruct the driver's view of the passenger side cross-view mirror. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk

An obstructed view of the passenger side cross-view mirror increases the risk of injury for pedestrians.

Remedy

Dealers will change the location of the camera and update the software, free of charge. Owners were notified of the defect on November 2, 2021. Owner notification letters were mailed on March 31, 2022. Owners may contact Blue Bird's customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R21BL-SB.

Recall number 21V696000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American school buses. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake System."

Risk

Unintended spring brake application may occur, increasing the risk of a crash.

Remedy

Dealers will replace the SC-3 check valves, free of charge. Owner notification letters were mailed on November 18, 2021. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R21BE-SB.

Recall number 21V284000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2021-2022 Vision and 2022 All American school buses equipped with hydraulic brakes and electronic stability control (ESC). The Hydraulic Brake control unit (ECU) may not have been programmed correctly, possibly causing the ESC to malfunction.

Risk

If the electronic stability control does not function properly, it can increase the risk of a crash or injury.

Remedy

Blue Bird will notify owners, and dealers will inspect the hydraulic brake ECU and repair it as necessary, free of charge. The recall began on April 9, 2021. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R21BC-SB.

Recall number 21V083000 · Recall details

What is wrong

Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk

An incorrectly installed seat can increase the risk of injury in the event of a crash.

Remedy

Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1‑478‑822‑2242. Blue Bird's number for this recall is R21BB-SB.

Recall number 21V070000 · Recall details