Tl* the contact owns a 2003 buell firebolt xb9r motorcycle. The contact stated that while driving at various speeds, the headlights would not illuminate the road beyond three feet which obstructed the visibility. The failure recurred whenever the headlights were in operation. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the problem. The approximate failure mileage was 13,000.
Buell Firebolt Xb9r headlights problems
15 of the 18 owner complaints about the Buell Firebolt Xb9r describe headlights failing or too dim.
- owner complaints
- 15
- typical mileage
- 10,579
Is there a fix? No recall or service bulletin covers this area of the car yet.
By model year
- 200315
What owners say
Degraded coating on headlight reflectors starting as black spots which spread. After reflective coating is gone the black plastic reflectors melt. I use oem bulbs.
The chrome/plastic reflector material on the low beam headlight started to degrade. The light reflected at night was dim. The housing absorbed the heat from the light instead of reflecting the light. The headlight was replaced by buell motorcycle company.
Tl*the contact owns a 2003 buell firebolt xb9r. The contact stated that the vehicle's headlights are dimming. He replaced the bulbs, but the heat of the headlights cause the bulbs to dim. The vehicle has not been diagnosed. The purchase date was unknown. The current mileage is 25,000 and failure mileage was 10,000.
The low beam headlight was getting progressively dimmer over time. Upon disassembly I found the reflector area to be dull and partially blackened. Any attempt to clean away the black area only enlarged it as the reflector area had turned to powder. I swapped out parts from the high beam to restore the low beam operation. I have not yet determined a course of action to permanently remedy the situation.
I have a 2003 buell motorcycle corporation motorcycle. After suffering a problem where my headlight dimmed considerably and is basically useless at night. After consulting an internet forum I belong to, it appears that there are numerous complaints of this problem and the interior lining of the light disintegrating as part of a manufacturing flaw. Apparently this has been brought to the manufacturer's attention with no interest or intent on resolving this safety issue.
Motorcycle headlamp loss of reflective material resulting in poor lighting. Make: buell model: xb9r year: 2003.
Headlights getting dimmer and dimmer, found headlight inner housing chrome plating peeling off. No fix except to buy new headlight assemblies. This also happened to the new assemblies in several months. Buell chat sites confirm that all/most xbr models develop this problem making travel at night unsafe.
Reflective coating in headlamp assemblies deteriorate with the excessive heat and cause poor visibility and illumination.
Lighting from headlights go dimmer and dimmer after a few months. Inside the headlight assembly they used only chrome paint for reflecting light out of the headlight assembly. Over time the part wears out because of heat from the light. So there is no more reflecting of light out of the assembly. This in turns makes the headlights go dimmer and dimmer over time.. Can't see when driving at night because of not enough lighting..
Related recalls
No recalls on record for this model year.
Questions about the Buell Firebolt Xb9r headlights
Which Buell Firebolt Xb9r years have headlights failing or too dim problems?
The model years with the most reports are 2003 (15 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Buell Firebolt Xb9r?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history