The mounting bracket welded to the front exhaust pipe (near the flex section) broke off due to weak factory welds. As a result tearing a hole in my exhaust pipe and potentially leading to exhaust fumes leaking into the cabin of the vehicle. In my opinion this defect should be addressed as a safety issue if not repaired.
2020 Buick Enclave: gas smell in the cabin
7 of the 61 complaints about the 2020 Buick Enclave describe gas smell in the cabin.
- owner complaints
- 7
- of this car's complaints
- 11%
- recalls
- 1
Is there a fix? There is 1 recall and 2 service bulletins for this area of the car. See below
Gas smell in the cabin by model year
- 20207
- 20161
- 20081
What owners say
I am submitting a complaint regarding premature exhaust system failure on my 2020 Buick Enclave involving the front exhaust pipe/exhaust manifold/catalytic converter assembly. The issue appears very similar to the conditions described in GM Special Coverage programs N212356540 and N242445280 involving exhaust pipe and bracket failures on related GM crossover platforms. The mounting brackets/support brackets on the front exhaust pipe appear to fail or separate, which places excessive stress on the flex section of the exhaust system. This movement and stress can cause the flex pipe/manifold area to crack and may ultimately damage the catalytic converter assembly itself. My vehicle developed: Exhaust leak Loud ticking/exhaust noise Rich/lean oxygen sensor fault conditions Exhaust fumes entering or potentially entering the cabin Passenger dizziness while riding in the vehicle Concern for carbon monoxide exposure The repair facility documented that the exhaust leak should be repaired as soon as possible because exhaust fumes may enter the vehicle cabin. The estimated repair cost is approximately $1,700 for replacement of the integrated catalytic converter/exhaust manifold assembly. This appears to be more than ordinary wear and tear. The failure pattern is consistent with bracket/support failure causing abnormal stress and cracking in the exhaust system upstream near emissions components. Because these failures can allow exhaust gases and possible carbon monoxide exposure into the passenger compartment, I believe this issue represents a significant safety concern and warrants investigation for 2020 Buick Enclave vehicles and related GM crossover platforms.
Leaking flex pipe on the exhaust causing undue rattling and possible exhaust fumes entering the passenger cabin.
The contact owns a 2020 Buick Enclave. The contact stated while driving at an undisclosed speed, there was an abnormal ticking sound coming from under the hood. Additionally, there was an abnormal exhaust odor inside the cabin of the vehicle. The vehicle was taken to the dealer, who determined that the passenger’s side flex pipe bracket had cracked, causing damages to the catalytic converter. The contact was informed that the flex pipe and catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was 52,580.
Welds have broken loose from exhaust creating a hole and loud noise & strong exhaust smell
2020 Buick Enclave mounting bracket separated from the front exhaust pipe which caused a hole to appear in the exhaust pipe. This is a known issue for 2019, 2021, and 2022 Buick Enclaves. No warning light The exhaust fumes along with Carbon Monoxide were coming through my ac vents for several months. There is no indication on when the mounting bracket separated.
The vehicle's exhaust intermediate pipe mount has broken has caused damage in the intermediate pipe requiring both the be replaced. The cracked exhaust allows exhaust fumes to enter the passenger compartment. A recall (N222385510) for 2021 Chevrolet Traverse has been made however is addressing this on only the 2021 models, even though the same issue is applicable to other models. On the this forum, there are several complaints of this design flaw reported. https://gmauthority.com/blog/2023/06/gm-to-fix-2021-chevy-traverse-front-exhaust-pipe-issue/
Service bulletins that may apply
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, Cadillac XT6, Chevrolet Traverse, and GMC Acadia vehicles. The fuel pump's jet nozzle may have a plastic burr remaining from the manufacturing process, possibly causing a blocked nozzle and an insufficient fuel supply to the engine.
- Risk
- Insufficient fuel supply can result in an engine stall without warning, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the fuel pump module. The recall began November 16, 2020. Owners may contact GMC customer service at 1‑888‑988‑7267, Buick Customer service at 1‑866‑608‑8080, Chevrolet customer service at 1‑800‑222‑1020 or Cadillac customer service at 1‑800‑458‑8006. GM's number for this recall is N202314760.
Recall number 20V639000 · Recall details
Questions about the 2020 Buick Enclave fuel smell
Is gas smell in the cabin a common problem on the 2020 Buick Enclave?
7 of 61 owner complaints about the 2020 Buick Enclave (11%) mention gas smell in the cabin. The model year with the most reports is 2020.
Is there a recall or service bulletin for this on the 2020 Buick Enclave?
There is 1 recall and 2 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2020 Buick Enclave
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Buick Enclave?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history