2017 Buick Encore engine problems

Filed Jul 22, 2026 · Engine, Fuel system · FL

The factory-installed turbocharger assembly on my 2017 Buick Encore failed mechanically while operating the vehicle, creating an immediate and severe roadway safety hazard.The structural failure of the turbocharger causes the vehicle to experience a sudden, unpredictable, and extreme loss of engine propulsion while actively driving. This severe power degradation makes it incredibly dangerous to accelerate, merge into highway traffic, or clear busy intersections safely, as the vehicle fails to respond to throttle input and drops speed rapidly. The vehicle is displaying an active diagnostic trouble code P0299 (Turbocharger Underboost condition).The manufacturer, General Motors, is fully aware of this exact component defect and has issued corporate Special Coverage Adjustment Bulletin N232395330 to address cracked turbo housings and wastegate failures on this model. However, because my vehicle is over their arbitrary 120,000-mile corporate warranty limit, GM’s Executive Resolution Team (Case #103125607) has issued a final refusal to repair the component.The manufacturer's mileage limitation leaves a documented, highly dangerous engine propulsion defect completely uncorrected on an active vehicle, posing a continuing, severe safety risk to the occupants and other drivers on public roads.

Filed Jun 11, 2026 · Engine · TX

There is a problem with the 2017 Buick Encore turbocharger. From speaking with the auto shop I took it to for a check they have seen many Buick Encore’s with the same turbocharger problems. He spoke to me about it prior to me dropping off the vehicle and then confirming the issue after inspecting the vehicle. The turbocharger inspection revealed a distinct structural crack at the wastegate flange, resulting in boost pressure loss. There is already a recall associated with this problem in other VIN’s with the same year and type of vehicle, recall needs to be expanded because this is a known and ongoing problem.

Filed May 22, 2026 · Engine, Transmission · PA

Formal Consumer Complaint Statement — GM / Crivelli Buick I am filing a formal consumer complaint against Crivelli Chevrolet Buick GMC and General Motors/Buick regarding what I believe was discriminatory and unfair treatment in connection with a warranty-covered vehicle repair. The customer is [XXX] , owner of a 2017 Buick Encore. The vehicle was serviced by Crivelli Chevrolet Buick GMC in Mt. Pleasant, Pennsylvania, on or about May 20, 2026, for a turbocharger failure covered under GM Special Coverage Bulletin N232395330. The vehicle had recently passed Pennsylvania safety and emissions inspection on April 30, 2026. The turbo-related diagnostic code appeared on or about [XXX]. Crivelli completed the minimum turbocharger warranty repair but then informed the customer that additional intake/manifold-related repairs were needed and would not be covered. The customer disputed this because the additional failure appeared during the same repair sequence and appears directly related to the covered turbocharger failure. A written request was faxed asking Crivelli to review the invoice, compare the repair to GM’s covered parts list, and submit the related intake/manifold issue to GM for collateral coverage, goodwill review, or warranty consideration. Crivelli did not respond to the fax notice and did not return the customer’s calls. When the customer attempted to follow up with the service department, Scott from the service department refused to review the concern, refused to provide further service, and refused to contact GM regarding the related warranty issue. Based on the conduct, tone, refusal to review the documentation, refusal to escalate to GM, and refusal to provide equal service, I believe the customer was denied fair consumer service because of race.The customer is not asking for special treatment. The customer is asking for equal treatment, proper review of GM’s own warranty/special coverage bulletin, and fair handling of a related mechanical INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION A

Filed Mar 20, 2026 · Engine · 88,000 miles · TX

The contact owns a 2017 Buick Encore. The contact stated that while driving at an undisclosed speed, the vehicle experienced a sudden loss of power and went into "LIMP Mode". Additionally, there was smoke coming from the rear of the vehicle. The dealer was notified of the issue but declined to service the vehicle because the vehicle had a salvage title. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 88,000.

Filed Mar 9, 2026 · Driver assistance, Engine · 44,000 miles · CT

The contact owns a 2017 Buick Encore. The contact stated that while driving at 40 MPH, the engine was running rough, and the vehicle experienced reduced power. The stabili-trak and the check engine warning lights were illuminated. The vehicle was taken to Auto Zone, where a diagnostic trouble code for a cylinder misfire was retrieved. The vehicle was taken to an independent mechanic, where the cylinder #1 ignition coil and spark plug were replaced, but the failure persisted. The mechanic determined that the engine might need to be replaced; however, the mechanic did not specialize in engine diagnostic tests. The manufacturer was notified of the failure and referred the contact to the dealer for a diagnostic test. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the engine needed to be replaced. The contact related the failure to GM Special Coverage Number: N232395330; however, the manufacturer informed the contact that the VIN was not included, and the contact was referred to the federal safety agency Hotline for assistance. The vehicle was not repaired due to the cost. The failure mileage was approximately 44,000.

Filed Jan 23, 2026 · Engine · 48,000 miles · NY

The contact owns a 2017 Buick Encore. The contact stated that while driving approximately 25 MPH, the contact smelled smoke and became aware that the smoke was coming from under the hood. The failure reoccurred while driving the following day. The vehicle was driven to an independent mechanic, where it was diagnosed, and it was determined that the turbocharger needed to be replaced. The vehicle was repaired. The contact received notification of Special Coverage: N232395330 (Turbocharger Replacement), and the manufacturer was contacted for reimbursement. A case was opened; however, the manufacturer later informed the contact that the reimbursement claim was denied because the vehicle was not repaired by a dealer. The failure mileage was approximately 48,000.

Filed Jan 9, 2026 · Engine · OH

4/2025-Engine coolant water outlet needed to be replaced 5/2025- Turbo boost replaced (under recall) 6/2025- Engine fan needed to be replaced 12/2025- There was active leaking in the engine oil cooler and lines- needed to be replaced Engine ventilation , engine oil weep along valve cover seals- needed to be replaced

Filed Sep 17, 2025 · Engine, Fuel system · IN

I have went to the dealership for the past two years with this problem and they keep saying they are not getting any codes: when the air conditioner is on it’s pulling the power from the motor and makes it hard to go up hill. Hard To accelerate when going on to the freeway as well. The problem is only getting worse and worse.

Filed Aug 8, 2025 · Engine · MI

The turbo charge is not providing adequate power. I was on the highway and the car began to chugging then accelerated on its own and all the lights on the dash came on then all went off like it was going to shut down. I put my hazards on and started to pull to the side of the highway. I gave it a moment for the car and for me because I was terrified, my kids were in the car and traffic was going steady around 70-75 miles per hour and I was scared as it began to shut down that I would be hit by traffic behind me before I could get over. It started driving again. It still drives but is hard to accelerate and even when stopped you can see the RPM rising. It’s as if the car never idles, it feels as though is constantly under load. I have had it looked at professionally at Midas but they will only say they think it is the turbo as there are no codes coming up. I have had it looked at by mechanics I know who have fixed other things that may cause similar issues and nothing has worked and they also believe it is the turbo. I’ve know other people with Buicks and they have had similar problems I’m confused as to why this 1.4 liter turbo has not been recalled.

Filed Jul 22, 2025 · Engine · 60,189 miles · MI

The contact owns a 2017 Buick Encore. The contact stated while driving at various speeds, the engine overheated, and there was smoke coming from the front of the vehicle. The contact stated that the temperature gauge indicated that the engine was hot. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that the water outlet housing, the blower motor, A/C condenser, water pump, thermostat, thermostat housing, turbo charger, and the fan were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 60,189.