There has been a leak from the fuel tank since 2006 without any accident to the vehicle and am having difficulty finding one to replace it. One car parts attendant informed me of the recall on this problem.
2004 Buick Rendezvous fuel system problems
49 complaints (25% of all complaints for this car). Typical mileage when it fails: 85,000.
- owner complaints
- 49
- of this car's complaints
- 25%
- typical mileage
- 85,000
- crashes
- 0
- recalls
- 2
Which part fails
- Storage: tank assembly4
- Storage: fuel gauge system4
- Storage: tank assembly: filler pipe and cap2
- Storage2
- Fuel injection system: injectors1
- Fuel injection system: fuel rail1
- Delivery: fuel pump1
- Delivery1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Buick Rendezvous fuel system problems in other years
Specific symptoms reported on the 2004 Buick Rendezvous fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Fuel system, gasoline: storage
- What is wrong
- On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (icv).
- Risk
- A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the fuel tank. The recall will be mailed in two phases with the first phase beginning on december 4, 2007. The second phase will be mailed on december 13, 2007. Owners may contact buick at 1‑866‑608‑8080; chevrolet at 1‑800‑630‑2438; or pontiac at 1‑800‑620‑7668. The vehicle population includes buick rendezvous and pontiac aztek vehicle built in may 2003; chevrolet venture and pontiac montana vehicles built from june through august 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.
Recall number 07V349000 · Recall details
Fuel system, gasoline: storage
- What is wrong
- On certain passenger vehicles, a weld between the fuel tank inlet check valve and the fuel tank can fail.
- Risk
- If these parts separate, the driver may notice an odor of fuel, the service engine soon or check engine light may illuminate, and/or fuel may leak onto the ground. Fuel leakage in the presence of an ignition source could result in a fire.
- Remedy
- Dealers will inspect the serial number of the fuel tank to see if it is on the list of affected tanks. If the serial number matches, the fuel tank will be replaced. Owner notification began november 4, 2003. Owners should contact buick at 1‑866‑608‑8080 or pontiac at 1‑800‑620‑7668.
Recall number 03V454000 · Recall details
Related investigations
Fuel tank leakage
Gm is recalling (the federal safety agency recall no. 07v‑349) certain model year (my) 2002-2004 buick rendezvous, chevrolet venture (regular wheelbase) and 2001-2004 pontiac aztek and montana (regular wheelbase) vehicles to replace fuel tanks and correct a defect that may allow fuel leakage.the vehicle recall population is rendezvous and aztek vehicles built in may 2003, venture and montana vehicle built in june through august 2002 and certain same model vehicles registered in nevada, arizona, virgin islands, puerto rico and hawaii that were built through nov/dec 2003 (depending on model).the total number of vehicles recalled is 20,594 (includes 15,196 subject aztek and rendezvous vehicles). In addition to the recall, gm will extend the warranty on my 2002-2004 rendezvous and regular wheel base venture vans and my 2001-2004 aztek and regular wheelbase montana vans not included in the recall to provide warranty coverage for a period of 10 years or 150,000 miles, whichever occurs first.gm will begin notifying owners in december 2007.gm reports that the fuel inlet pipe containing the inlet check valve (icv) may fracture and allow fuel vapors or fuel to leak out.gm data revealed that elevated ambient temperatures, higher carbon content in the icv and variation in the manufacturing process were the contributing factors for potential cracks in the icv.beginning december 2003, gm built vehicles with a redesigned fuel tank/icv.subject vehicles not included in the recall or extended warranty did not show a failure trend similar to the above vehicles..for additional details, see recall 07v‑349.this investigation is closed.
EA07006
Fuel tank leakage
Certain subject vehicles may exhibit leakage of odor and/or fuelfrom the lower portion of the fuel tank inlet filler pipe (inlet check valve).the inlet check valve (icv) and the fuel tank are joined together using a hot plate welding process for plastic parts.gm reports that its analysis of field returned parts show evidence of process variations for different manufacturing periods.these variations produced some icv to fuel tank joints with poor melt flow lines.odi's analysis of gm's warranty claim data finds more frequent fuel tank replacements in the hotter climate states.this investigation has been upgraded to an engineering analysis (ea07-006) to further assess this matter.
RQ06009
What 2004 Buick Rendezvous owners say
Most recent owner complaints, unedited.
My grandson and I were shopping, then I filled my gas tank. We then went into the grocery store came out, smelled gas and looked under car. It is leaking gas, we hurried home--went from full tank to 1/4 full tank in 58 miles. It is sitting and not driven. And I have a 2003 rendezvous that has a gas smell that is very strong but hasn't leaded out gas yet.
Tl* the contact owns a 2004 buick rendezvous. The contact stated that while refueling, gasoline leaked from the vehicle. The contact became aware that the gas tank was fractured while refueling the vehicle. The vehicle was taken to an independent mechanic where it was inspected and diagnosed and determined that the fuel tank was fractured and needed to be replaced. The vehicle was not repaired. The contact referenced the federal safety agency campaign number: 07v349000 (fuel system, gasoline) as a possible solution to the failure however, the VIN was not included. The manufacturer was made aware of the failure and informed the contact that the warranty was expired. The failure mileage was approximately 109,694.
Whenever I put gas into my car there is a strong unbearable gas odor in the car.
I was driving my vehicle on the freeway going 70 miles per hour and all the sudden my vehicle had pretty much came to a complete stop and if I hadn't had my seatbelt on, I probably would have went through the windshield.
My vehicle has been picking up speed for no reason. The vehicle was not taken to nor taken to a dealer for diagnostic testing or repairs. Also, the fuel pump is not working. I can fill it up with gas and the light will still turn on. Maybe after driving for a couple miles or making a turn the light will turn off.
No acceleration,when I go up a hill no acceleration, or when I go to get on the highway no acceleration, and very dangerous. I went to dealership for a diagnostic test and I replaced fuel tank pressure sensor and vent solenoid, no acceleration. I went to another dealership for diagnostic. They recommended that I replace 3 electrical harnesses and connectors $1350 dollars parts and labor too much for me and that may not solve my problem. I told them the problem was corrosion in the connectors to the fuel pump $160 dollars later they agreed with me. Still dangerous.
While driving the anti-lock and awd lite on and smell of gas from inside of cabin and sometimes from under the hood . Also when trying to accelerate the car bogs and the RPM fo high but the carvseama to lose power . Ob2 code is p0445
Tl* the contact owns a 2004 buick rendezvous. While the vehicle was parked, there was a strong fuel odor and a fuel leak was noticed from the rear of the vehicle. The vehicle was taken to reliable buick gmc (400 automall dr, roseville, ca 95661, (916) 783-5233) where it was diagnosed that the fuel tank check valve was cracked and leaking. The contact was informed that the fuel tank needed replacement. The vehicle was not repaired. The manufacturer was notified and stated that the VIN was not included in the federal safety agency campaign number: 07v349000 (fuel system, gasoline). The manufacturer offered no further assistance. The approximate failure mileage was 175,000. *tt
Tl* the contact owns a 2004 buick rendezvous. The contact observed an abnormal fuel odor within the vehicle without warning. In addition, a slow drip from the fuel tank was observed. The vehicle was taken to an independent mechanic who confirmed that there was a leak from the fuel tank. The contact then called the local dealer (buick gmc of kirkland, 12335 120th ave ne, kirkland, wa, 98034) where an appointment was scheduled. The dealer diagnosed that there was a fracture within the fuel tank inlet check valve. The vehicle was not included in the federal safety agency campaign numbers: 03v454000 (fuel system) or 07v349000 (fuel system). The vehicle was not repaired due to the cost. The manufacturer was contacted and provided case number: 8-34895551467. The case was escalated, but the manufacturer denied the claim and stated that they would not cover it nor was the vehicle included in the prior recalls. The failure mileage was approximately 50,100.
Questions about the 2004 Buick Rendezvous fuel system
Does the 2004 Buick Rendezvous have fuel system problems?
Owners have filed 49 complaints about the fuel system of the 2004 Buick Rendezvous, 25% of all its complaints.
At what mileage do 2004 Buick Rendezvous fuel system problems start?
The typical (median) mileage in owner complaints is 85,000 miles.
Was there a recall on the 2004 Buick Rendezvous fuel system?
Yes, 2 recalls: 07V349000, 03V454000. Check your VIN to see if your car still needs the free repair.
What year does the Buick Rendezvous have the most fuel system problems?
The Buick Rendezvous model years with the most fuel system complaints are 2002 (103 complaints), 2003 (84 complaints) and 2004 (49 complaints).
Other 2004 Buick Rendezvous problems
Electrical 76Engine 31Brakes 21Steering 16Airbags 14Transmission 12Suspension 9Visibility 9Acceleration 8Body 7Driver assistance 6Locks 4Lights 3Seats 3Tires 3Wheels 3Seat belts 2
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Buick Rendezvous?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history