2016 Chrysler 200 airbags problems

Filed Jul 8, 2026 · Airbags · 132,073 miles · WV

The contact owns a 2016 Chrysler 200. The contact stated that whenever the front passenger's seat was occupied, the "Service Airbag" warning light illuminated. The contact stated that the failure occurred when the occupants placed their feet near the front passenger footwell area, where the airbag module and wiring harness were located. The contact routinely disconnected and reconnected the airbag wiring harness to reset and clear the warning light from the instrument panel; however, the failure recurred when the front passenger seat was occupied. The vehicle was taken to the dealer for a diagnostic inspection, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 132,073.

Filed Nov 22, 2025 · Airbags · TX

Service airbag system My car doesn’t start

Filed Oct 13, 2025 · Airbags · VA

My airbag sensor has randomly come on and off for about 2 years, it sense cut off and stayed off up until recently in early 2025 the “service passenger airbag” sensor comes on and stays on which affects the ability to pass a state inspection in Virginia.

Filed Sep 2, 2025 · Airbags · GA

My air bag light has been flickering on and off for quite some time now. I’ve taken it to a professional mechanic as well as Gerber and they have both fixed the issue by unplugging and replugging the harness underneath the passenger seat. I was told this issue with this type of Chrysler has been brought by the shop numerous times and I may have missed a recall repair on this vehicle. I have repeated this method numerous of times but at this point it is an inconvenience and safety issue. How am I able to receive a recall notice to get this issue fixed? I can be contacted via email [XXX] . Respectfully, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 5, 2025 · Airbags, Electrical · IN

Vehicle has 46,000 miles on odometer. A year ago the "Service Airbag System" light would intermittently illuminate. It is now staying lit all the time. I was speaking with an acquaintance as they had the same vehicle. Theirs caught on fire under the seat in the electrical connection box for the airbag. I took it to a few of our local mechanics and they say it is a substantial safety issue as they pulled the codes B0028-13 and B0020-13. Right side and left side seat deployment squib circuit open. The airbags will not deploy upon impact. The consensus from the mechanics was that Chrysler has known this is a common problem in these vehicles and needs to address the repair. After calling Chrysler and finding out they do know this is a problem in design it will still cost $4000.00 to repair as it's not covered under warranty. This vehicle is unsafe and it makes me wonder how many people are driving these vehicles not knowing the potential danger. It will be going to the dealership when one of them can "fit me in".

Filed Feb 20, 2025 · Airbags · 97,000 miles · OK

The contact owns a 2016 Chrysler 200. The contact stated that the air bag warning light was illuminated, and the message "Service Air Bag" was displayed. The vehicle was taken to the dealer, where the contact was informed that the failure might be a factory defect; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000.

Filed Sep 25, 2024 · Airbags, Seats · KY

Air bag light comes on. We have had it checked by 3 different technicians. They have found that it is an issue with the control module, and seat squibs need to be replaced. This is a $4000 issue that is directly related to the safety of the driver of the car. They said it looks to be a manufacturing issue but unfortunately is not covered by the extended warranty that we purchased.

Filed Jul 8, 2024 · Airbags · TX

The airbag Service light keeps coming on. There has been no accidents to this vehicle. There was a airbag safety recall on Chrysler 2016, but when I contacted Chrysler, they said my vehicle fell out of the date range that they assigned the recall to it was manufactured before a certain date reference number 90517639. Chrysler should be responsible to ensure that buyers are safe in their vehicles and they need to help get this issue corrected

Filed Jun 8, 2023 · Airbags · OK

B0028-13 is the code that appears when a scanner tool is used because the "service airbag system" warning message came on. Reading the other U-Tube post concerning this problem it seems to be common and a possible danger to the driver and the front passenger.

Filed Dec 10, 2022 · Airbags · UT · crash · 2 injuries

I was unable to stop fast enough and went through a red light and t boned another car. My airbags failed to go off. Everyone, including the police officer was shocked that they did not deploy.