Car stalls immediately after filling up. I switched filling stations, brands and octanes. Continued to have problem. After a few gallons were used, the stalling went away each time. Problem now continues while stopped at traffic lights, traveling at low speeds, or no pressure on the throttle. While moving it will stall, the engine light will come on and "ding", then when I pump the throttle it will catch itself and the car will jerk hard and accelerate again. At traffic lights once it stalls, it will require using the key to restart. I took the car to the dealer twice for the problem, the last time in aug 2013, the check engine light had stayed on. They reset the codes and could not duplicate the problem.
2006 Chrysler 300C engine complaints
Page 9 of 10: complaints 221 to 250 of 276, newest first, as owners wrote them.
Tl* the contact owns a 2006 chrysler 300. The contact stated that the vehicle stalled without warning while driving at low speeds. The failure was recurring. The vehicle was taken to the dealer where a diagnostic was performed however, the dealer was unable to locate a failure code. The dealer reprogrammed the main computer system but the failure was not corrected. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure and current mileage was 66,000.
My 2006 chrysler 300c (hemi 5.7) will stall at low speeds or when stopped at a traffic light. The car does restart. At higher speeds (e.g,, 60mph), the vehicle will exhibit a sudden loss of power (drop in rpms, followed by a chime sound) as if the engine is about to stall, before reaccelerating again. The stalling/loss of power issue does not occur all the time. Sometimes, the car will operate as long as a day or two without incident. The dealer performed a complete system diagnostic - retrieved code po700 - related to loss of communication with PCM to multiple modules. (they may have been old stored codes.) then, they cleared the codes, road tested the car, but could not replicate the problem. The dealer returned the car and asked me to monitor it. They indicated that if the issue re-occurs, the vehicle will possibly need a PCM or ignition switch. My impression is that they are guessing at what the issue may be. The day after the car was returned to me, the same sudden stalling/loss of power issues recurred although the engine diagnostic light has not come on. I will be returning the car to the dealer, even though they have not been able to pinpoint the problem to date. I am very concerned about the sudden stalling and loss of power. This is a very serious safety issue that can result in an accident. I am married with a 9 month old baby.
After filling up my gas tank, I encountered numerous stalls while driving. Thankfully, it was city driving early in the morning. Since then, I have encountered numerous situations where the car has stalled after filling up. I initially thought it was bad gas (I.e. Water in my gas tank), however, I have since varied the fueling stations and brands I use and have seen no effect. It always seems to happen after I fill up, and it seems to go away after the tank has emptied a bit. The latest encounter was yesterday (I filled up two days prior) while I had my family in the car - multiple stalls in mid-day city traffic. And again this morning. The gas tank is still quite full (it shows over "f" on the gauge). I _never_ top off when I fill - I simply wait until the filler turns itself off when filling. I have never seen this problem prior to the first occurrence in mid november of 2012, which I initially (as indicated) wrote off as bad gas due to hurricane sandy (I figured the storm may have caused water in the tanks of gas stations). After hearing about numerous issues on this, I wanted to add my experiences to the growing list. The car in question is a 2006 chrysler 300c srt-8.
My 300 c stalls and jerks every time I fill it up now. The car was taken to the dealership and reported several times (midway jeep and chrysler, san diego), and the service writer said they were aware of the problem because they have had a number of complaints. I was told not to fill the car up completely as this might help. It does not !!!! I almost got killed last week when the engine stalled as I was going down hill with the loss of brakes and power steering....!!!!!!!! I called the service writer at midway jeep chrysler and was put into his voice mail. It is interesting that he never returned the call about the complaint. I have made several. What is it going to take for action to be taken ? An injury or death ? I also have witnesses that have been in the car when this has happened.
After I purchased my 2006 chrysler 300c on july 6th, 2013, the salesman filled the car up with gas. He had the car running & before I could get in the car, it switched itself off, not once but twice. The next incident was after the first time I filled my car with gas, which was july 26th, I drove to my next stop & my car switched off while pulling into a parking place. The next time was july 29th, my husband filled the car up & the car switched off twice!!! The next time was the next day, july 30th, I was at a red light & the car switched off. I have not made the 1st payment on the car, however, I am concerned with this major safety issue!!!
As reported with other complaints, car will stall after refueling. Yesterday it stalled three times while removing my foot from the accelerator and applying the brake. It also stalled while turning through an intersection which prompted me to dig into this further since previous attempts to correct the problem have not worked!. Visited chrysler dealership today and since the check engine light was not on nor could they find anything specific to the issue there was nothing they could do. The only question I was asked was that if I topped the fuel after the pump automatically shuts off. I responded that I did not and if I did what difference would that make. Problem has been on going for about 8 months, and in those months the dealership re-flashed the engine control module, I have replaced the spark plugs, replaced all the fluids, and replaced the pcv valve. Problem still persists and would like to seek some type of resolution!
On 4 occasions since december 2012 (I purchased it 6/2012), my car has stalled after fill up, on one of the three occasions the car would not restart for several minutes. All four times that the car stalled, it was while I was in traffic and turning. The first time I was turning on to a major highway in daytona beach, and the car would not restart. I do not overfill my tank, I only fill it until the pump shuts itself off. I have had my engine codes checked and there is not indication of any reason for the stall. I have two codes, one for an ambient air temperature sensor, and one for an oil pressure sensor. Neither of those should have cause a random stall with no warning. My car is well maintained, and babied.
Most of the time, the engine will stall at a stop with all gauges dropping to zero. This also happens when the car is moving down the roadway. Engine does not start smoothly. Most times it takes at least two attempts to start it. Sometimes upon restart the gauges remain at zero. Upon start, engine will run for a brief time and will run maybe 1 block or so before stalling again. It will run without incident until the next episode. There may be a spread of 3 to 4 weeks between incidents. Sometimes the engine speed jumps up without accelerator input making the car leap forward. This has happened once to me. Sometimes when the engine is restarted and put into gear, the transmission does not engage immediately, but after a very brief delay causing a "jump" into gear when it does engage. The esp bas light comes on a majority of the time this happens. Sometimes the gauges all drop to zero while the car is running. Almost always, I can feel in the running of the engine that something is not quite (almost imperceptive missing) right before this happens. I took the car to a chrysler dealership immediately after this happened and asked them to read the codes. They told me many codes had been recorded.
Vehicles stalling while driving, mostly while decelerating. Seems to occur more frequently with a full fuel tank and while pulling a trailer, but has also occurred with a half a tank. No problem restarting after stall. Started occurring more frequently in june of 2013. Has happened at least 6 times in the past 18 months.
When I refuel the car at any gas station, it usually stalls a few minutes later when I am driving. At first, I thought it was the gas quality, but I have tried premium fuel from all major brands, and each time I fill up the car, their is a 90% chance that it will stall two or three times in the middle of the road. The rpms just drop and the car stalls. I have not had an accident, yet, but this is a major problem which can cause an accident..
Our 2006 chrysler 300 srt8 dies after fueling the gas tank to full. It has died in intersections were we have almost been hit and in turns car dies, locks up and there is no power anything. We have taken it to the dealership 4 times and continuously pay money to turn run diagnostic, only to hear " we cannot duplicate the problem" I have spent $400.00 to be told there is nothing wrong.car becomes very hard to restart. Once I get the vehicle started, again the stalling starts, this will happen several times before the car remains on. As I drive home, I could feel the car "sputtering" or hesitating like it wanted to shut down again. When starting car in the morning it feels like it wants to die. Please help this car is my family's main transportation and I fear that one day this issue will cause a crash. I have a 3 year old and a baby on the way. Help!!! Chrysler does not care about lives, only the bottom line.
Every time after refueling the vehicle to a full tank of fuel vehicle stalls and sometimes several tries before it restarts. Once the fuel tank level goes down about a gallon, the problem stops. This always occurs after refueling to a full tank of fuel. If I fill to about 3/4 tank the car can stall but not always. The only known fix to work all the time is a new gas tank for $1500 to install.
Pulled out of gas station after refueling into heavy rush hour traffic, car stalled while turning making it very difficult to steer (if my wife had been driving she would not have been able to steer). Managed to put car in neutral and coast into medium. Put car in park and restarted car, pulled out into traffic and car stalled again. This time I put car in neutral and restarted while coasting. No more problems on this trip. Had the same problem 3 weeks later, pulled up to stop sign after refueling and car stalled. I put car in park and restarted, drove approximately 3/4 mile and entered stop and go traffic on freeway. Car stalled 5-6 times within 1 mile, each time I put car in neutral and restarted. Several times I was able to prevent a stall by watching the tach for signs of RPM dropping then putting car in neutral and pushing the gas pedal.
I had just refueled (filled up - did not continue fueling after the pump auto-stopped) and continued driving to my destination (about 3-5 minutes). I had just completed a left turn, approaching a red light, so I was "coasting" at about 15 MPH when the engine died. Luckily, I was beside of a vacant parking lot and was able to veer into the lot and off the highway. However, in doing so, I noticed that I had lost steering capabilities and it was very difficult to steer the car off the highway. It was a good thing I wasn't driving at a higher speed and going around a curve, because I would've surely wrecked. The instrument panel was still lit up (compass, odometer, radio station, etc), but the engine light came on. After stopping, I placed it in park, turned off the switch and restarted the car. There was some hesitation, but it did start. Continuing to my destination, I could occasionally feel the car "sputtering" or hesitating like it wanted to shut down again, but it did not happen again before I made it home. However, on my way to work this morning and before I left my driveway, the car acted like it wanted to die again. I had backed out of my garage and put it in drive, slightly pressed the accelerator and it "sputtered". It continued "sputtering" periodically on my way to work (6-8 minute drive). I am really becoming very nervous about driving our country roads, in fear that it will shut down and I will lose the ability to maneuver the car to safety until I can regain power.
The first time I stalled was after filling up my tank , I was leaving the gas station, I was in the right lane of on coming traffic when it stalled, nearly getting hit by an on coming car. Since that time it has stalled at least six times. I went to my chrysler dealer who claims they had no knowledge of this problem. It happened again two days later while on a busy highway. I was making a left turn into a shopping center when it stalled , leaving me in the far left lane of on coming traffic. I immediately went to the chrysler dealership and reported it again at which time I was informed there was still no recall on the car and I was told I would have to leave it. I am going back to the dealership on 5/30/13 (hilton head chrysler, hwy 278 ,fording island rd,.,hardeville, sc)
After filling the gas tank to full, stopping after the pump clicks off the first time, the vehicle stalled after running for around 5 minutes. Restarted vehicle and same thing happened two more times. Vehicle continues to do this regularly.
After filling up with fuel while stopped at a traffic light the engine stalled. After restarting and proceeding the engine stalled again while traveling at 15-20 MPH. This has happened several times since always after refueling.
After refueling tank I drove away from the pumps and onto the roadway, during acceleration to speed limit (50mph), at 25mph the engine stalled, with traffic quickly approaching I might add, and left me coasting. I was able to pull off to the side of the road thankfully, at which time I had to attempt a restart 3 times before it did start, when it started I had no issues for a few months. This exact situation happened to me every other month for a year until I learned to not fuel the vehicle to the top. It is a considerable inconvenience to not be able to fill the car to its capacity, especially on long trips. I am just afraid that this will happen, at any time, with no warning, quite an uncomfortable feeling actually. I hope for a satisfactory resolution to this issue. Thank you.
I too have had several instances when my car stalled on a busy road after approx. 5 minutes of fueling up. Very dangerous. This happened approx. 6 times usually in very cold weather.
After filling the gas tank full I drove the car 1-2 miles and stopped at a traffic light and when I went to accelerate to go forward the engine completely died. I coasted to a stop just past the intersection and was able to re-start it. The same thing happened about a mile further down the road only this time I was not stopped, but driving and accelerating and it died and I was forced to coast to a stop and restart the engine. The problem continued for several days and then stopped. It happened again the next time I filled the gas tank up with very similar issues, and again stopped after the gas tank had used several gallons of fuel. I took it to the dealer and was informed that they would have to replace the gas tank (at a cost of $1600). The technician then told me that if I kept the gas tank at 75% full and not completely fill it I would have no problems. He was right, since these events in december of 2012 I have only filled it to 75% full and have had no problems. I am reporting this because I read in the dallas morning news on 05/16/2013 that this model of chrysler is being investigated for the problem I have told you of. The description/symptoms listed in the news release seemed to match mine and I am therefore reporting it.
I filled up the gas tank at the station pulled into traffic and the light turned red. Stopped for the light the car started lurching and the engine shut down. Turned on hazard light pushed gas to floor and cranked engine over. Took several tries to get engine to start. After this incident the car runs rough when stopping at red lights.
Going for a 1000 mile trip from saint cloud fl. To pittsburgh pa. I filled up my gas tank . When I pulled out of the station the engine stalled. It stalled twice again a mile away while I was traveling about 25 MPH. On my trip to pittsburgh the car stalled about 5 separate times all after getting the gas tank filled. Most stalls occurred when stopped but at least twice happened while driving. Called chrysler and got no where. Their suggestion was to take car to a dealer at my own expense. This car has been maintained to a very high standard. Never a scratch , or dents. Always kept covered in garage. It is in immaculate condition. I am shocked about this stalling and chrysler's reply to my asking for their assistance.
After filling my gasoline tank and driving away the engine quit running while driving down the city street or highway. While still rolling forward I put the car in neutral and attempted to restart the engine. I always succeeded in restarting the car while it was rolling forward. However, the stalling would repeat itself two to three more times before the car stopped doing this. I reported this to my dealership who said they knew nothing about this problem and had no solutions. After months of repeated experiencing this problem I started to fill my tank only to about 3/4th full and the stalling was solved. However, after hitting some rough road after a 3/4th filling (the gasoline got sloshed about, I am sure),the engine stalled on me. On june 12, 2012 I asked the dealership, overland park jeep, chrysler, dodge, in overland park, ks to start replacing gasoline tank parts. They installed a 4891427ab detector-natural vacuum detecti....., a solenoid-proportional purge and a canister-vapor. (their invoice #429537). This did not solve the stalling problem. On march 26, 2013 I finally gave up on the problem and asked opjcd to replace the saddle-bag gasoline tanks. Their invoice 452851 covered the installation of a 68051891 aa tank-fuel, o-ring-fuel pump and level unit. With three complete gasoline tank fill up's I have had no problems with stalling. I am writing to you after reading, in this mornings newspaper, about similar problems being looked into by your agency and I wanted to report what happened to me and what I did about it. Opjcd service man told me they would reimburse me for my expenses if a recall was made on my car. I paid a total of $1,453.90 to get my 2006 chrysler 300c, I hope, fixed. Thank you.
I had just refueled at the quick trip left the station and within one mile experienced the vehicle's engine cutting off and on. The tachometer would show that the engine was going from 2000 RPM's to 1000 this happened maybe 5 times in a one minute span and then quit.
Many multiple incidents - after filling fuel tank, engine will stall multiple times shortly afterwards and is difficult to re-start. This happens even if care is taken to avoid "topping off" tank. At times the engine has even stalled during fueling once tank is near full, before pump clicks off. Must drive with gas cap removed for it to start and run at all for many miles before it behaves normally again, and even with gas cap removed it still will come near stalling at times.
After refueling, my chrysler 300srt 2006 6.1 liter v-8 engine stalled while traveling through town. It restarted quickly and I continued my travel. Within 1 mile, the vehicle stalled again and restarted quickly. I have not had any other incident as of 5/5/13. I am concerned after reading an article in the paper regarding this problem with other chrysler products of the same year and similar models. I travel the interstates often and refuel during my travel and I am extremely concerned that my car will stall on the interstate while traveling 65 MPH surrounded by other cars. I have reported this problem to my chrysler dealer and understand there is an ongoing investigation. I can only pray that the underlying problem is discovered quickly before there are any crashes with or without injuries. Is there anything else I need to do?
After filling the gas tank the vehicle is prone to stall. This can happen at random times and speeds. If you only fill the tank up 3/4 of the way it seems to alleviate the problem. No trouble codes are set. After stalling the vehicle can sometimes be restarted immediately, other times it might have to sit for 5 minutes.
Engine stalls at least once after refueling. The dealer replaced the fuel-line purge valve last year,but it didn't fix the problem. I was told on several occasions that it was bad gas that was causing the problem, but I've tried using several brands of fuel without any luck. I don't drive the vehicle that much, but I have had a few near accidents because the engine accelerates before shutting off.
The first time I had this problem, I filled up my car after a trip, and upon leaving the gas station my engine stalled and the car would not come back on. I could not get the car to crank and when the engine did come on once the rpms would not settle and they kept dipping to almost zero before the engine cut off. I had the car towed to a repair shop where they were unable to fix the issue. I've had this happen about five times and I finally had one repair shop tell me to not fill my gas tank up all the way and it should prevent the cut offs. I then failed an emissions test and had to have my gas cap replaced. I thought that this had solved the problem so I tried to fill the tank up all the way again and it immediately cut off after starting it up. I was able to rev the engine and use up some of the gas and managed to get the car home with the rpms constantly dipping almost to zero. The car cut out at a stop light and I then had to get it started again after sitting in the intersection stalled. I've had my car inspected by two chrysler dealers, a few independent repair shops, and also a nissan dealer where I know the head mechanic. The only answers I've gotten were that it is a faulty o2 sensor and needs a new gas tank.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Chrysler 300C?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history