Completed x53 extended warranty a year prior at dealership, car still stalls only after putting fuel even though always filling to 3/4-7/8 of tank. Had my children with me Car stalled again today at middle of busy street when about to make a left turn after i filled to 3/4 of a tank. Had dodge dealer in Manteca, CA diagnose after first stall half a year prior and they would not replace faulty new tank. Still had to pay diagnostic fee saying fuel liquid was getting into vapor lines and flooding engine and that new tank is not the issue even though it is allowing fuel liquid to pass through vent valve which caused saturation of vapor canister and purge solenoid and engine stalling. Car only stalls when pumping gas 3/4 tank or above
2006 Chrysler 300C fuel system problems
342 complaints (49% of all complaints for this car). Typical mileage when it fails: 70,000. 1 crash reported.
- owner complaints
- 342
- of this car's complaints
- 49%
- typical mileage
- 70,000
- crashes
- 1
- recalls
- 0
Which part fails
- Storage: tank assembly3
- Storage1
- Delivery: fuel pump1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Chrysler 300C fuel system problems in other years
Specific symptoms reported on the 2006 Chrysler 300C fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
No recalls on record for this model year.
Related investigations
Engine Stall
During PE13-016, Chrysler identified a condition in model year (MY) 2005 through 2006 Chrysler 300, Dodge Charger and Magnum vehicles equipped with 5.7L and 6.1L 8-cylinder HEMI engines that may result in engine stall after refueling when the vehicle is stopped or travelling at low speeds. According to Chrysler, the multifunction control valve (MFCV) fuel shutoff float integrated into 19-gallon fuel tanks can swell in a stuck open position allowing an overfill condition.This condition causes fuel to enter into the purge line which may result in engine stall after refueling.Chrysler's investigation determined that the problem was related to dimensional changes/swelling of the float when exposed to fuels with high ethanol content.Chrysler and its supplier, Stant, developed new fuel soak test requirements to address the condition and extended the warranty period on 19-gallon fuel tanks to lifetime coverage.The owner letter mailing began in January 2014.See the investigative file for copies of Chrysler's owner letter.The Office of Defects Investigation (ODI) analyzed 1262 complaints related to engine stall that were provided by Chrysler or submitted to ODI from consumers.In total, there were 299 unique reports indicating that the fuel system allowed an overfill condition after refueling, and the predominant failure mode identified involved stalling when stopped or travelling at low speeds.The complaint counts shown in this resume include incidents in which enough detail was available to verify the symptoms were related to the defect condition identified by Chrysler.The condition that is causing the majority of stalling incidents in the subject vehicles occurs at a stop or low speed and allows the vehicle to be restarted immediately.The condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty. This preliminary evaluation is closed. The ODI reports cited above can be viewed at http://www-odi.the federal safety agency.dot.gov/owners/Searchreference?targetCategory=C under the following identification numbers (ODI Nos.): 10507307, 10507200, 10505652, 10505171, 10504826, 10504737, 10504085, 10503965, 10502091, 10501842, 10499752, 10496037, 10495284, 10494434, 10494394, 10493452, 10493120, 10490388, 10489004, 10487504, 10483660, 10480828, 10480763, 10477973, 10477450, 10474702, 10474358, 10473974, 10466062, 10458709, 10457762, 10455763, 10453489, 10453283, 10451227, 10450065, 10449138, 10446316, 10442787, 10442594, 10440885, 10439373, 10415682, 10399601, 10384811, 10365159, 10340153, 10336288, 10275134, 10510152, 10509942, 10509026, 10506031, 10505862, 10534319, 10534148, 10531912, 10520561, 10525368, 10524698, 10520820, 10520097, 10520012, 10515715, 10519379, 10516140, 10515325, 10515134, 10520305, 10514678.
PE13016
What 2006 Chrysler 300C owners say
Most recent owner complaints, unedited.
After Fueling on several occasions the vehicle just abruptly stalls out and it's very dangerous I notice that there is recalls on other 2006 Chrysler but mine isn't on there but I am very concerned about this as it could cause me to get in a accident
car stalled after filling gas tank. I was driving through an intersection and had to stop for oncoming traffic, when the car stalled and would not immediately restart, it eventually did start after several panic moments of being stuck in the intersection while the light was changing to let opposite traffic proceed. It stalled 2 more times on the way home. Both times I was slowing the car down when this occurred. I have been fearful of driving this car again since this happened. I heard there was a recall from Chrysler for lifetime replacement of gas tank due to a possible control valve shutoff float failure. My vehicle has never had the gas tank or float replaced, but it does not show up for a recall when I enter VIN. What should I do?
gasket around fuel pump failed allowing gas to pool on top of fuel tank under the back seat on passenger side . this resulted in a strong "gas/fuel" smell from fuel vapors colecting inside the car and the obvious risk of ignition/explosion and negative health effects of breathing said fumes .the vehicle has not been inspected yet because we are afraid to start the vehicle let alone drive it to the shop . We are making araingements to have it towed to the repair shop . we have not had any warning lights . Mechanic said it was a common problem with seal failure around fuel pump . the vehicle has 127,000 miles
There is a fuel leak coming from the rear right side near the right rear wheel. Fuel leaks when the tank is full.
The contact owns a 2006 Chrysler 300C. The contact stated that the fuel tank was previously replaced under an unknown extended warranty coverage; however, after the repair, the vehicle experienced a failure. The contact stated that after refueling the vehicle and driving at slow speeds, the vehicle stalled. The contact stated that the failure recurred several times while driving and coming to a complete stop. The vehicle was towed each time the failure occurred. The contact stated that the vehicle stalled in the middle of the road during the last failure. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and test-driven, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was approximately 214,624.
Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.
My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit
The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem
Fuel leaking through gas gasket under rear passenger seat near electrical components. Gas Fumes fill vehicle cabin when fuel tank is full and could be ignited by a small spark. No warnings of issue on dashboard. EXTREME DANGER!
Questions about the 2006 Chrysler 300C fuel system
Does the 2006 Chrysler 300C have fuel system problems?
Owners have filed 342 complaints about the fuel system of the 2006 Chrysler 300C, 49% of all its complaints, more than any other problem.
At what mileage do 2006 Chrysler 300C fuel system problems start?
The typical (median) mileage in owner complaints is 70,000 miles.
Was there a recall on the 2006 Chrysler 300C fuel system?
There is no recall for this problem on this model year.
What year does the Chrysler 300C have the most fuel system problems?
The Chrysler 300C model years with the most fuel system complaints are 2006 (342 complaints) and 2005 (138 complaints).
Other 2006 Chrysler 300C problems
Engine 276Transmission 106Electrical 56Steering 38Airbags 32Brakes 22Acceleration 19Body 11Lights 7Suspension 7Driver assistance 6Visibility 4Seat belts 3Seats 3Tires 3Wheels 3Locks 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Chrysler 300C?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history