2005 Chrysler Town and Country: clunking or noise when steering

Filed Mar 22, 2015 · Electrical, Engine · 99,276 miles · GA

I was making a left turn and the steering wheel was hard to turn left,not to the right.while turning left the steering column made a load noise.when I parked took the key out the switch the motor continued to run for about 3-5 seconds before it stopped. When I came out of the store cranked up and went straight home slowly and the left turn was still hard to make and when I stopped in my drive way I put the vehicle in park and took the key out the motor ran for about another 5 seconds.I checked the power steering fluid , the oil and coolant all looked okay I waited about 15 min. And cranked the vehicle up the key seem to turn farther than normal but it cranked up okay,so I shut it back off took the key out and the motor ran another 3 -5 sec. I put the key back in the switch and the radio and mileage started flashing on and off so I took the key out and talked to a mechanic about it.

Filed Sep 8, 2014 · Steering · 55,000 miles · AZ

I have power steering noise on my t&c 2005 chrysler van. It used to come initially on cold start and later it is common even on hot days and the noise is contentious when ever I turn the wheel. It looks it is manufacture issue and never recalled from chrysler as I see lot of complaints on different online forums.

Filed Oct 2, 2012 · Body, Brakes · 5,000 miles · AR

Tl* the contact owns a 2005 chrysler town and country. The contact stated that the vehicle experienced brake failure numerous times. The most recent failure occurred while driving through an intersection at approximately 25 MPH and the brakes failed to engage. The contact was able to coast the vehicle into a parking area and was able to stop buy engaging the emergency brake. The brake pad and tires were replaced at 18,000 miles, the strut was replaced at 5,000 miles, and the rotors were replaced at 28,000 miles however, the failure was not corrected. The steering wheel made a grinding noise and was hard to turn. In addition, the doors could not be unlocked automatically or manually and sometimes the doors opened independently while driving. The vehicle was towed to the dealer who inspected the vehicle and stated that the brake master cylinder exhibited oil consumption therefore, the vehicle was unsafe to drive and they could not complete the vehicle inspection. The failure mileage was 5,000 and the current mileage was 48,800.

Filed Mar 13, 2012 · Steering · PA

Steering makes noises and rack and pinion is leaking on both sides after 89k miles. Vehicle does not pass state inspection because of that. Chrysler does not cover the repair although it seems to be a manufacturer defect judging from the number of incidents that can be found here or elsewhere on the internet.

Filed Oct 11, 2011 · Airbags · 70,000 miles · WI

Tl* the contact owns a 2005 chrysler town and country. The contact was driving approximately 10 MPH and heard a clicking noise coming from the steering wheel as the horn began to sound erroneously. The vehicle then stalled with the illumination of the air bag warning indicator. The engine was restarted but the clicking noise continued and the air bag warning indicator remained illuminated. The vehicle was taken to an authorized dealer five times and the clock spring was replaced four separate times. One week after the forth clock was replaced the front driver side air bags deployed independently. The vehicle had been at the dealer for seven consecutive weeks and continued to remain for further investigation. The approximate failure mileage was 70,000. The VIN was unavailable.

Filed Nov 21, 2008 · Steering · 67,486 miles · WI

Chrysler town & country 2005 steering developed a noise and our mechanic identified the steering reservoir was required to be replaced under a manufacturer service bulletin. This was completed and about two months later, the rack and pinion was diagnosed to have a failed seal. The vehicle has 67k miles on it, which are family commuter miles. The reservoir cost over $200 and the rack is going to cost about $900. This is a manufacturer product deficiency and should be covered under a recall. As others have posted, the manufacturer should cover this failure.

Filed Jun 2, 2008 · Steering, Suspension · 55,000 miles · NY

Tl*the contact owns a 2005 chrysler town and country. In december of 2007, the contact heard a clicking noise while turning the vehicle at 35 MPH. She took the vehicle to the dealer, but they did not make any repairs. She returned to the dealer in january of 2008, but the dealer still could not find any failure. Most recently, the dealer stated that the power steering rack was leaking. The dealer recommended that she replace the power steering gear at the cost of approximately $800. The current mileage is 62,020 and failure mileage was approximately 55,000. Updated 06/16/08

Filed Mar 25, 2008 · Steering · FL

We purchased a used 2005 chrysler town and country mar 2008. During the test drive we noted a whirling sound upon acceleration. We were told that through their 90 day warranty we can have it checked out (the car ws purchased from a honda dealer) after purchased we took the van to a chrysler dealer to be inspected, several problems were found including a leak in the steering rack (source of noise). The entire steering rack will need to be replaced at a cost of $840. The part is on back order due to the enormous amount of vans that need this part replaced. We would like you to look into the number of steering racks being replaced as we feel there should be a recall.

Filed Mar 4, 2008 · Steering · GA

Power steering noise found to be leaking/fault steering rack. Upon inquire to dealer for repair/replacement found that 13,000 were on back order!!! Many similar problems found posted. Some individuals have had multiple replacements. Chrysler should recall due to negligence, danger to human life and the sheer volume of defects.

Filed Jun 26, 2007 · Engine, Steering · 24,000 miles · NY

Tl*the contact owns a 2005 chrysler town and country. The contact stated that the steering wheel locked and an unfamiliar noise was heard while attempting to turn the steering wheel. There were no warning indicator lights. The vehicle was driven to a chrysler dealer and liquid began pouring from the front end of the vehicle. The contact believes that the steering hose was replaced. Recently, the vehicle began to bounce and make a rattling noise. The vehicle was driven to a chrysler dealer and the mechanic replaced the engine mount. The purchase date was unknown. The current mileage is 32,000 and failure mileage was 24,000.

Filed Mar 26, 2007 · Steering · 38,723 miles · PA

Tl* - the contact owns a 2005 chrysler town & country. The vehicle started making a grinding and clicking noise when turning at 40 MPH. The contact could smell the engine running hot. The vehicle was diagnosed as needing a new power steering rack. The dealer paid for the part. However ,the contact had to pay for labor charges. The failure mileage was 38,723. The contact has the repair invoice. The current mileage was 39,330.

Filed Dec 8, 2006 · Steering · 40,632 miles · MN

Steering made a clunking noise and pulled to the right. Had vehicle checked three times while under warranty and was told the alignment was the issue. Aligned and tires balanced each time, but problem continued. Took car in with a copy of the federal safety agency bulletin and they replaced rack & pinion at my cost. Vehicle steering is now tight and pulling to right is gone. I don't feel I should have had to pay for this repair.