2006 Chrysler Town and Country: check engine light

Filed Mar 11, 2016 · Fuel system · 99,000 miles · FL

Problem: stalling and sputtering after refueling engine type: 3.3 liter start of problem noticed: approximately 2011-2012 service completed: chrysler/dodge dealer and third party engine light associated with problem: egr valve service provided: 2 new egr valves, a evap canister, gas cap, ignition coil and new fuel pump within seconds after fueling my vehicle, the vehicle sputters and sometimes stalls. Initially there was no engine light associated with problem. Vehicle primarily stalls in intersections local streets) due to stalling occurring at start up creating significant safety hazard. After initial stalling (up to 4 times in one incident) and sputtering, vehicle returns to normal operation. Heavy acceleration helps with preventing stalling. The problem has progressed and now the engine light turns on and the vehicle sputters at various time (local streets and highways); even while traveling at highway speeds. I was never informed by "certified mechanics" of the issue or advised on how to fix the problem. I stumbled across information via google search regarding failure of the vapor/liquid separator in the gas tank dating back to at least 2012. I understand the federal safety agency has completed the investigation. Concerns: 1. Chrysler has failed to notify consumers of a known issue 2. Chrysler/dodge dealers seem to be unaware of issue 3. Unknown if stalling may occur at highway speeds causing loss of control 4. Stalling has occurred in intersections 5. It is unclear if there are any deaths or serious bodily injuries associated with this issue because it is unclear if this cause has been investigated in traffic homicides across the united states. Further investigation should be completed. Chrysler/dodge or any other affected vehicle should have to at a minimum notify consumer of danger involved.

Filed Sep 22, 2015 · Electrical, Steering · 145,000 miles · TX

My chrysler town and country van started having what looked to be battery issues at the beginning of 2015. The engine would turn off and all the dash dials would begin to puslate until I turned it off and restarted it. At first it would do this only when it was raining out, so we changed the battery and it seemed to work. Then one afternoon it just completely shut down as we were driving down the road, sun shining, and completely dry out. We check the battery connections and replaced a few, seemed ok but then it happened again! This time as we were driving down a 70mph highway! Thankfully the highway was not busy as the moment and near our exit and were able to safely get to the side and restart the van. We continue to take it in but everyone has told us "no engine light, no engine code, sorry can't help you." we have seen others write about this same problem and are now bringing it to the federal safety agency.

Filed May 7, 2015 · Engine · 100,000 miles · NJ

Tl* the contact owns a 2006 chrysler town and country. The contact stated that the check engine light illuminated on the instrument panel. The vehicle was taken to a dealer, who was unable to diagnose the failure. In addition, the contact mentioned that the vent fans stopped working and the check engine light stayed on. The vehicle was taken back to the dealer. The vehicle was not repaired. The failure mileage was 100,000.

Filed Aug 27, 2014 · Airbags, Engine · 57,000 miles · FL

Tl* the contact owns a 2006 chrysler town and country. The contact stated that the check engine and air bag warning light illuminated. The vehicle was taken to a private mechanic where it was diagnosed that the air bag sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 57,000.

Filed Aug 4, 2013 · Fuel system · 7,000 miles · TX

The engine light came on and the speedometer read the words "gas cap". We changed out the gas cap and turn the engine light off. About a week later it was back on again. I need to get the car inspected but when the mechanic "smoked" the system. He discovered that the module/rollover on top of the tank where 2 small lines goes in is broken and the assembly is not separate but a part of the entire gas tank. He stated there is no reason for the breakage. I have contacted chrysler about this but have not received any response. There is no viable explanation for this except a faulty part. I am sure I cannot be the only one. There is a strong gas .

Filed Jul 9, 2013 · Electrical, Steering · OH

While driving during a rain storm I drove through a small puddle and the power steering system went out as well as the electrical system. I was able to pull the car into the closest drive after struggling with the steering. Anytime we hit a puddle or there is heavy rain something goes wrong. Someone is going to get hurt if they are traveling and the steering goes out. I just got back from the store just now and it is raining again, hit a small puddle and now the check engine light is on. This vehicle is not safe to drive in the rain!

Filed Sep 7, 2011 · Engine, Steering · 65,000 miles · WI

Tl* the contact owns a 2006 chrysler town and country. While parked, the contact noticed the check engine light was illuminated. The vehicle was taken to an independent mechanic where the mechanic advised that the fuel exhaust recirculation sensor had failed and would need to be replaced. In addition, the dealer stated that the steering rack assembly also needed to be replaced. The vehicle was not repaired. The approximate failure mileage was 65,000.

Filed Jun 7, 2011 · Electrical, Lights · 46,674 miles · FL

Tl* the contact owns a 2006 chrysler town and country. The contact stated that the check engine light would sporadically illuminate. The contact stated that all of the warning lights would do the same and and the gauges wiould fluctuate rigorously. The contact had taken the vehicle to the dealer several times, but was told they could not duplicate the failure. The contact also stated that the passenger side tail light was replaced three times. The failure mileage was 46,674 and the current mileage was 55,683.

Filed May 28, 2011 · Electrical · 45,000 miles · FL · fire

We own a 2006 chrysler town and country. On wednesday may 25, 2011, my wife was driving the vehicle when it started shuddering and the engine light came on and smoke started coming from under the hood. She immediately pulled over and got out of the vehicle. A passerby told her that he called the fire department. When they showed up they popped the hood and extinguished the fire. We contacted our insurance company to have the vehicle towed to advantage chrysler, dodge in mount dora, fl. We had also purchased an extended warranty on the vehicle. We have since been informed that the vehicle is a total loss. I have also filed a complaint with chrysler concerning the incident.

Filed Sep 6, 2010 · Electrical · 38,000 miles · UT

Normal city driving, 35 MPH, all dash function lights came on including, check engine, airbags, oil etc. All mechanical gauges (MPH etc.) stopped working. Gear selection lights (prd12) all lit. Trip computer stopped receiving information. Interior fan stopped working. Headlights came on. Total electronic disruption but engine continued to run. Stopped, restarted, all dash lights again came back on - climate control fan, radio, interior lights, door locks worked, headlights came back on (switch turned off). Cold start next morning - same problems. Replaced battery, same problems. Can't determine operating status without gauge readouts, speed, temp etc. Not working properly. Door locks not working at times. Electronic rear hatch and side sliding door not working at times. Afraid to drive the van.

Filed Aug 13, 2010 · Electrical · 94,000 miles · PA

Vehicle is driving fine on highway, check engine light comes on, then airbag light, then seatbelt light. Within a few minutes all dashboard lights are on and all dials (speedometer, oil gauge, temp gauge, RPM gauge) are all at zero while vehicle is driving at about 65 MPH on highway. Also, periodically the car will start and immediately turn off multiple times. After waiting a day, it will start up fine and then the next time, will start then stop. Vehicle has been taken to the dealership 3 times and most recently they have had it for 2 weeks with no luck finding any issues. We just keep getting charged for them to look at it without finding anything.