2003 Country Coach Magna recalls

What is wrong

Certain motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Risk

Release of coolant under certain conditions could ignite and result in a fire.

Remedy

Country coach will be working with dometic in order to repair these refrigerators (please see 06e076). A secondary burner housing will be installed free of charge. The recall began on march 28, 2007. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or country coach at 1‑800‑452‑8015.

Recall number 07V031000 · Recall details

What is wrong

On certain class a motor homes equipped with vehicle systems' aqua-hot and hydro-hot water heaters, which use webasto burner tubes, the burner tubes do not meet specifications and could fail prematurely.

Risk

The surface temperature of the exhaust tube exiting from the heater can increase and could potentially ignite combustible materials in or around the vehicle.

Remedy

Vehicle systems is conducting the owner notification and remedy for this campaign. Owners may contact vehicle systems at 1‑800‑685‑4298 or country coach at 1‑800‑547‑8015.

Recall number 05V209000 · Recall details

What is wrong

On certain motorhomes equipped with international thermal research (itr)hurricane hot water heaters, the electronic control board may adversely affect safety features in some of the systems protecting against overheating and potential fire situation.

Risk

If the safety features do not shut down properly, the heating system can continue heating, possibly resulting in a fire.

Remedy

The defective electronic control board will be replaced. In the meantime, customers should turn the system off using the master on/off switch located on the side of the electronic control box which is adjacent to the heater. Owners who take their motorhomes to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact itr at 1‑800‑755‑1272 or country coach at 1‑800‑547‑8015.

Recall number 03V109000 · Recall details

What is wrong

On certain motor homes equipped with slide-out generators, certain generator slide-out ball screw actuator brake holding components are defective. The brake may not allow the actuator to hold the load in position with the power off. The amount the load may move can vary and in some cases the actuator may not hold at all. These actuators are used to control the movement of the slide-out generator mounted in the front of the motor homes.

Risk

The failure of the actuator to hold the generator in position could potentially result in a vehicle crash and/or injury to a pedestrian.

Remedy

Dealers will replace the actuator. Owner notification began june 19, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact country coach at 1‑800‑452‑8015.

Recall number 02V164000 · Recall details