2016 Fiat 500X technical service bulletins
229 technical service bulletins and manufacturer communications cover the 2016 Fiat 500X.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Verify Reman part number availability
- 2.4L Excessive Oil Consumption XS1 Warranty Extension The
- U90
- 2.4L Excessive Oil Consumption XB1 Warranty Extension The
- U90 Parts Ordering
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Air Bag Warning Lamp Illumination Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Lifter
- MIL/check engine lamp comes on after performing U90 recall PCM software update.
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Emissions Recall U90
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Air Bag Warning lamp Illumination Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Water Quality When Mixed With Engine Coolant
- Emission Recall U90 Catalyst Efficiency
- WiTECH Small Leak Verification Test (SLVT)
- 2.4L Excessive Oil Consumption XB1 Warranty Extension The
- Warranty Bulletin D-23-01
- 2.4L Engine Oil Consumption Test The
- Emissions Recall U90 Catalyst Efficiency
- Approved Use of Weld Through Primers
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Customer Complaint May Include Engine Oil Leak Or Consumption
- Wiring
- Flash: Powertrain Control Module (PCM) Updates
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Customer complaint may include engine oil leak/consumption.
- Flash: Drivetrain Control Module (DTCM) Diagnostic and System Improvements
- Customer Satisfaction Notification W80 Oil Consumption Inspection (Revision 2)
- Customer Satisfaction Notification W80 Oil Consumption Inspection (Revision 1)
- 2.0L or 2.4L Engine Replacement
- CEL, Check Engine Lamp On, DTC P0339 Crankshaft Position Sensor Intermittent
- Customer Satisfaction Notification W80 Oil Consumption Inspection
- Keys/Fobiks, Programming Keys With High Line BCM (L3 BCM)
- 2.4L Engine Oil Consumption Test
- Blind Spot Or Park Assist Warnings, False Activation
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Hands On Steering Wheel Message In EVIC
- No Weep Hole In Muffler Assembly
- 2.4L Ignition Coil Boot Replacement
- 2.4L Ignition Coil Boot Replacement
- Key Programming, Security Pin Request, Pin Invalid
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Revised Customer Satisfaction Notification V54 Engine Cooling Fan
- Radio [res]
- Flash: Powertrain Diagnostic and System Enhancements
- RA2 RJ2 RG2 RL2 and RM2 Radio Enhancements
- Flash: Transmission Diagnostic and Shift Enhancements
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Door Hinge Assembly Side door hinge noisy
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- Restraints Remove I-Sheet from packaging
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Flash: Engine Does Not Start at The First Attempt
- Transmission Shift And Drivability Enhancements For P0901-00.
- Flash: ABS Module Electronic Parking Brake Enhancements
- Flash: Transmission Shift And Drivability Enhancements
- Flash: Transmission Diagnostic And Shift Enhancements
- Water Leak On Right Front Floorboard
- Rear Outboard Seat Belt Is Slow To Retract
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Flash: Diagnostic And System ImprovementsThis bulletin involves updating the Body Control Module (BCM),...
- 948TE 9
- RF Hub Module DTC, U1765-87 "RFHM (Radio Frequency Hub Module)
- Flash: Diagnostic And System Improvements
- Windshield Please contact Chuck Hood at cell (248) 613-7591 regarding BU & FB windshields that exhibit...
- Customer Satisfaction Notification R73 Wheel Stud Wrench The wheel stud wrench on about 11,700 of the...
- Seat Relay For a Jeep Renegade or Fiat 500X ONLY, if the driver's power seat will not move in any axis and...
- RA4 RG4 RJ4
- MY16 RA3 & RA4
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- RA4 RG4 RJ4 radio enhancements
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- 2.0L or 2.4L engine replacement this bulletin involves replacing the long block due to a crankshaft...
- 2.0L Or 2.4L Engine Replacement
- Diagnostic And System Improvements
- Wheel Clicking Sound When Moving Slow
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- RA2 Radio software enhancement.
- RA2 Radio Software Enhancement
- Updating the radio software.
- Wire repairs to engine harness.
- Wire Termination Seal On 2.4L Engine Wiring Harness
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- RA3 RA4
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Pod Switch Buttons Sticking On Center Instrument Panel Bezel
- Flash: Amplifier Audio Enhancement
- This bulletin involves updating the amplifier (AMP) software.
- RA4 RG4
- RL4 Radio Enhancements
- This bulletin involves updating the radios software.
- Speed Transmission Quick Learn Procedure.
- Flash: ABS Module Electronic Parking Brake Enhancements
- : ABS Module Electronic Parking Brake Enhancements.
- Diagnostic And System Improvements.
- Flash: 1.4L Diagnostic And System Improvements
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- Flash: Instrument Panel Cluster (IPC) Enhancement
- Flash: Diagnostic And System Improvements
- NAG1 (5A580)
- Flash: Radio Frequency Hub Module (RFHM) Enhancement
- This bulletin involves updating the RFHM software.
- Flash: ABS Module Electronic Parking Brake Enhancements
- Malfunction Indicator Lamp (MIL) Illumination Diagnostic Trouble Code (DTC) P0113 The wiring at the...
- Air Conditioning Inoperative
- Flash: ABS Module Electronic Parking Brake Enhancements
- ABS Module Electronic Parking Brake Enhancements.
- Flash: 2.4L Powertrain Diagnostic And System Enhancements
- Flash: BCM Diagnostic And System Improvements
- Flash: Transmission Shift And Drivability Enhancements
- This bulletin involves updating the Body Control Module (BCM) software.
- Transmission Shift And Drivability Enhancements.
- Liftgate Open Indicator Illuminated And Liftgate Will Not Latch Fully
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Liftgate Fiat Emblem Loose
- Front Brake Squeak/Squeal Noise
- Flash: ABS Module Electronic Parking Brake Enhancements
- Travel Link button not displayed on the radio screen.
- Claim Reimbursement Guidelines
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Fiat 500X?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history