2007 Fleetwood American Eagle recalls

What is wrong

Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Risk

If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.

Remedy

Fleetwood is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or fleetwood at 1‑800‑322‑8216.

Recall number 08V320000 · Recall details

What is wrong

On certain motor home chassis, there may be a loose connection between the bus bar and a grid pad due to the pins being slightly smaller diameters after assembly. Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shut down and/or not be capable of powering up.

Risk

Each vehicle could potentially experience a unique circumstance where one or a combination of the following conditions could occur: loss of electrical power to the engine, transmission, starting and engine cooling systems, operation of the right chassis stop/turn signal and right trailer stop/turn signal, the anti-lock brake system, auxiliary brake system, the heater elements in the air dryer, and the heater element in the water-in-fuel separator.

Remedy

The dvec bussmann box will be replaced. The recall began on january 16, 2008. Owners may contact spartan at 1‑517‑543‑6400.

Recall number 07V363000 · Recall details

What is wrong

On certain class a motor homes, the service compartment that contains the inverter and the house batteries is insufficiently sealed from spark producing devices. In the event out gassing occurs from the batteries and the gases are exposed to a spark of measurable size and duration, ignition of the gasses may occur.

Risk

This has the potential to ignite combustible objects within the compartment.

Remedy

Dealers will inspect and install a compartment spacer and bulb seal to the service compartment that contains the house batteries free of charge. The recall began on march 30, 2007. Owners may contact fleetwood at 800‑509‑3418.

Recall number 07V101000 · Recall details

What is wrong

On certain american eagle and american tradition class a motor homes, the anti-lock brake system (ABS) module may not have been permanently mounted. The module could detach from the vehicle.

Risk

The anti-lock feature for the brake system could be lost.

Remedy

Dealers will inspect and permanently mount the ABS module to the inside of the chassis rail. The recall began on march 30, 2007. Owners may contact fleetwood at 1‑800‑509‑3418.

Recall number 07V059000 · Recall details