2015 Forest River Shasta wheels problems

Filed Oct 24, 2018 · Wheels · 8,000 miles · MI

I have a travel trailer with 15' white painted steel spoke wheels, after a year one had a air leak where the rim and spokes are welded together, about 6 months later another wheel had the same thing happen, I ended up putting innertubes in them. In sept. Of this year while traveling at 65mph on highway 80 in iowa, we had a wheel/tire failure since we never felt anything when it happened we didn't pull over right away, I thought the noise I heard was a truck passing us but after it passed the noise was still there. We pulled over to find that one tire and rim was missing only the spokes were left still bolted to the hub. The tires were inflated to 65 psi cold that morning, the lug nuts were checked for tightness also, we had been on the road for around 5 hours. We never heard any noise that I would think was a tire going bad, the flap, flap, flap sound you hear when a truck goes by with a bad tire. There was not any damage to the bottom of the trailer or marks that may have ben made by a tire coming apart, the damage to the trailer was to the plastic fender and metal it was screwed to. I think that maybe there was a problem with the wheel manufacture, that the welds were not as good as they should have been. It was suggested I contact you in case this problem is bigger than just my wheels. I have photos of the aftermath if needed.

Filed Aug 22, 2015 · Suspension, Wheels · 135 miles · GA

When I got my camper back from shasta after they had the camper 79 days for repairs. I looked under my camper and I found they just put a few screws in the wheel wells to "fix" damage from wheels busting the wheel well loose from my camper, and it still has gaps in the wheel wells and exposed screw with the pointed end pointed towards my tire ...

Filed Aug 22, 2015 · Suspension, Wheels · 45 miles · GA

My tire info label had 65psi but on the tire it had 35psi stamped on the tire... When it went back to the factory they put the right sticker on the camper.

Filed Aug 22, 2015 · Suspension, Wheels · GA

I bought my shasta airflyte 16 it had 0 miles and camping world is 40-45 miles to my house. We had to pull over 2-3 times because we thought the camper was coming uncoupled because of the bouncing of the camper and the shaking of the vibrations of the steering wheel, but when we got out everything was fine we smelled breaks and they were fine.. So we got home and 5hrs after it being home my camper was leaking that caused us to look over the whole camper close and I seen daylight in a vent when sitting on the gaucho. I found our wheel wells where busted loose and gaped open and tire skid marks in the wells and on the back side of the wells on the frame rub marks from the side walls. I couldn't fit my hands between the well and the tread of my tires and I couldn't get a finger behind the tire and the frame and measurements is about 1/4" sidewall to camper on one side and the other I can get a finger back there but it's a tight fit it measures about 3/4" side wall to camper .. My camper went back to the factory to be fixed.

Filed Jul 21, 2015 · Suspension, Wheels · OK

This is for a 2015 forest river shasta airflyte reissue 19 foot travel trailer, production # 1301. I believe the oem leaf suspension system and passenger tires are unsafe and will lead to a serious accident, injury, or death. The wheel well clearance is not sufficient for the oem tires and leaf suspension system on the trailer. Also, the oem tires are coker whitewall passenger vehicle tires. I believe travel trailers must be manufactured with oem trailer/cargo tires which have stiffer sidewalls. I was unaware of these concerns until an online forum recommended I check my trailer. I had recently completed an approximately 1,000 mile round trip and when I checked my trailer upon return, I found the tires had been rubbing the wheel wells both on top of the tires and on the inside of the tires. The left tire has already exhibited troubling sidewall wear on the inside of the tire.. There is less than 2 inches of clearance between top of tires and wheel well and less than 1 inch clearance between inside of tires and wheel well. Forest river shasta has a warranty repair which replaces the rear leaf spring shackles with ones that are longer but this only increases the above tire clearance by another inch. This does nothing to address the inside clearance of the tire to the wheel well. With the oem suspension system, the trailer exhibits excessive sway even with an aftermarket professionally installed curt anti-sway kit. I fear the warranty installed longer leaf spring shackles coupled with the coker passenger tires will only aggravate the excessive sway issue. To my knowledge, forest river shasta has not issued a safety recall for this condition.

Filed Jul 14, 2015 · Suspension, Wheels · 1,000 miles · CA

Inspection revealed tires impacting inside fender wells on this travel trailer. Under rated springs allow tires to rub inside fenders creating safety hazard. Updated 10/06/15*lj the vehicle was repaired at the owner's updated 12/21/2015

Filed May 28, 2015 · Wheels · TX

Tl* the contact owns a 2015 forest river shasta. The contact stated that the camper was equipped with passenger tires instead of trailer tires. The weight of the equipment placed on the camper brought the camper very close to the tires, which made it difficult to maneuver. The trailer was not taken to the dealer. The manufacturer was not notified of the failure. The failure mileage was not applicable...updated 07/08/15*bf updated 10/17/2017

Filed May 27, 2015 · Wheels · 50 miles · CO

I have a shasta airflyte reissue. The manufacture put passenger tires on it p225/75r15. They are to have 35 psi. The sticker says gvw is 3635 lbs. Each tire says max load 1874 lbs. The wheels say max load each 1820 lbs. It is my understanding that it is not safe to run passenger tires on an enclosed trailer, camper. A trailer needs tires with a stronger side wall and be able to inflate to 65 psi. I also understand that the tires and wheels should be rated at 20% more than gvw. The wheels are also offset to where the inside clearance in the wheel well is only about 1". A trailer wheel should be centered on the hub, not offset. The wheels should be able to accomadate a trailer tire and 65 psi.

Filed May 27, 2015 · Suspension, Wheels · 300 miles · OH

Tl* the contact owns a 2015 forest river shasta air flight. The contact observed that the suspension of the vehicle was low. As a result, the vehicle was less than one inch from both of the side tires. The vehicle was taken to the dealer for diagnostic testing. The dealer reached out to the for manufacturer for guidance. The manufacturer stated that the solution for this failure was to place banana shaped shackles to add clearance space from the tires and wheel well. The vehicle was repaired; however, the remedy proposed by the manufacturer did not suffice to deter the issue. After the contact received the vehicle back, she test drove it for four hours and noticed that the tires still scraped along the wheel wells. The manufacturer was made aware of the failure. The contact also noted that the camper was only equipped with one axle and the manufacturer factory equipped passenger tires on the vehicle and not the standard trailer tires. The contact also noted that the leaf spring was flat and already showed signs of corrosion. The failure mileage was 300.

Filed May 27, 2015 · Suspension, Wheels · 100 miles · WI

Tl* the contact owns a 2015 forest river shasta air flyte. While pulling the trailer at approximately 50 MPH, the trailer swayed left, right, and bounced up and down. The failure recurred on several occasions. The trailer was taken to the dealer. The technician was not able to diagnose or repair the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 100.