1991 Freightliner FL80 Problems: 0 Complaints, 5 Recalls

The worst 1991 Freightliner FL80 problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Tap a problem to see which part fails, at what mileage and in which other years.

Exterior lighting: turn signal: switchReported August 4, 1997 · 77,000 vehicles affected

What is wrong: Vehicle description: heavy duty truck. The shoulder bolt which holds the grote turn signal switch case and components together can loosen resulting in the turn signal malfunctioning.
Risk: If the turn signal function is lost, following motorists would not be aware of the turning vehicle, increasing the risk of a vehicle crash.
Remedy: Dealers will inspect these vehicles and tighten any loose bolts and in the turn signal switch within 2 years from the date of the recall notification letter. The shoulder bolt will be removed, cleaned, and reinstalled with loctite. Owners can also request loctite and repair instructions so they can fix the vehicles themselves.

Recall number 97V114001 · Recall details

Visibility: windshield wiper/washerReported September 14, 1993 · 985 vehicles affected

What is wrong: The windshield wiper arm support cracks where the wiper arm pivot mounts to the support brackets causing failure of the system.
Risk: Failure of the windshield wiper system reduces drivervisibility in inclement weather which could result in an accident.
Remedy: Remove and replace the windshield wiper arm support bracket with a redesigned support bracket.

Recall number 93V148000 · Recall details

Seat belts: front: anchorageReported April 14, 1992 · 1,400 vehicles affected

What is wrong: A number of cabs were assembled with fewer welds than specified in the upper b pillar near the anchorage for the seat belt. Welding materials used on the inboard anchorage bracket under the cab deck will not meet fmvss no. 210 load test requirements when three seating positions are provided.
Risk: Safety belt anchorage systems that do not comply to theload test requirements subject the seat occupant to greater risk of injury inthe event of a sudden stop or accident.
Remedy: Add reinforcement welds in the upper b pillar and add fasteners to the lower deck anchorage bracket.

Recall number 92V057000 · Recall details

Vehicle speed control: springsReported October 15, 1991 · 420 vehicles affected

What is wrong: The hook size of the throttle return spring is too small resulting in a tight fit around the anchor nut, causing the throttle return spring to break prematurely.
Risk: If the throttle spring breaks, the engine will return to idle speed, which may cause a highway hazard and result in a vehicle crash.
Remedy: Install throttle return springs with larger hooks.

Recall number 91V177000 · Recall details

Service brakes, air: antilockReported October 15, 1991 · 49 vehicles affected

What is wrong: Reservoir interior paint was allowed to enter the air reservoir check valve, and the valve is not properly seated.
Risk: Lack of proper seating causes the reservoirs to failto comply with the requirements of fmvss 121.
Remedy: Clean and reseat the air check valves as needed.

Recall number 91V178000 · Recall details

Used buying checklistWhat to check on a 1991 Freightliner FL80 before you buy

Is the 1991 Freightliner FL80 reliable?

Owners have filed 0 complaints about the 1991 Freightliner FL80.

What is the most common problem with the 1991 Freightliner FL80?

There are not enough complaints to tell.

How many recalls does the 1991 Freightliner FL80 have?

5 recalls, covering exterior lighting, visibility and seat belts.

See the problems and recalls for an exact car

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.