Freightliner MT-45 recalls

What is wrong

Daimler Trucks North America (DTNA) is recalling certain model year 2014 Freightliner Custom Chassis MT45, MT55 and MBC Chassis manufactured September 24, 2013, through November 7, 2013. In the affected vehicles, due to an incorrect calibration, the speedometer may display a speed lower than the vehicle is actually traveling.

Risk

With the incorrect calibration, the driver may unknowingly exceed the posted speed limit, increasing the risk of a crash.

Remedy

DTNA will notify owners, and dealers will update the instrument cluster software to the correct calibration, free of charge. Owners may contact DTNA at 1‑800‑547‑0712. DTNA's number for this recall is FL-658.

Recall number 13V640000 · Recall details

What is wrong

Daimler Trucks North America (DTNA) is recalling certain model year 2009-2014 model year Freightliner Business Class M2 and Freightliner Custom Chassis MT45 and MT55 chassis manufactured August 27, 2008, through December 10, 2013 and equipped with Eaton hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Risk

The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Remedy

DTNA will notify owners and dealers will update the hybrid transmission software, free of charge. The recall began on February 5, 2014. Owners may contact DTNA at 1‑503‑745‑6910. DTNA's recall number is FL-657.

Recall number 13V634000 · Recall details

What is wrong

Daimler trucks is recalling certain model year 2007 through 2010 freightliner business class m2, custom chassis mt45, s2 chassis, and stering acterra vehicles manufactured from october 5, 2006, through may 24, 2010, equipped with epa 2007 mbe 900 detroit diesel engines. Engine software may not react properly to certain aftermarket treatment device fault codes. The software may unnecessarily shutdown a vehicle or may fail to shutdown a vehicle with an aftermarket device over-temp fault.

Risk

Unexpected shutdown of a vehicle may increase the risk of a crash. Overheating of the aftertreatment device without engine shutdown may result in a fire.

Remedy

Daimler trucks will notify owners and repairs will be performed by detroit diesel free of charge. The safety recall began on december 30, 2010. Owners may contact daimler trucks at 1‑800‑547‑0712.

Recall number 10V472000 · Recall details

What is wrong

Cues, inc. Is recalling certain model year 2007-2009 service vehicles built on various chassis equipped with carrier airv ceiling units, model nos. 68rv0010ba, 68rv0012ca, and 68rv0010ea. The heater element in these assemblies may be defective which could cause the unit to create smoke or sparks.

Risk

This defect could result in a fire.

Remedy

Cues is working with carrier to remedy the affected vehicles. Repairs will be made by carrier free of charge. Please see carrier's defect report 09e-053. The safety recall began on january 5, 2010. Owners may contact carrier at 1‑877‑584‑7059 or cues at 1‑407‑849‑0190.

Recall number 09V456000 · Recall details

What is wrong

Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between july 2002 and july 3, 2007, equipped with bendix sr-7 spring brake control valves. The parker scv brass 90 degree single check valves (scv) which attach to the supply port of a bendix sr-7 spring brake modulating valve can break apart. Pieces of the parker scv can become lodged inside the sr-7 spring brake modulating valve, potentially causing either leakage out of the sr-7 valve or preventing air from properly exhausting from the sr-7 valve. Also, due to a manufacturing defect in the internal rubber check valve inside the sr-7 spring brake modulating valves, the valves can become deformed and not seat properly.

Risk

These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.

Remedy

Freightliner will notify owners and repair the vehicles free of charge. The recall began on january 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on february 1, 2008. Owners can contact freightliner at 1‑800‑547‑0712.

Recall number 07V302000 · Recall details

What is wrong

On certain walk-in vans, the stop lamps may be intermittent during light brake applications. The cruise control may not immediately deactivate when the service brakes are applied.

Risk

The stop lamps may not properly indicate that the service brakes are applied. The cruise control may not immediately deactivate when the service brakes are applied. Either condition may lead to a crash without prior warning.

Remedy

Dealers will replace the switch with one having a lower application load rating free of charge. The recall began on january 24, 2007. Owners may contact freightliner at 1‑800‑547‑0712.

Recall number 06V321000 · Recall details

What is wrong

Certain 2004 and 2005 freightliner van, motor home, shuttle bus, and school bus chassis manufactured between january 2004 and may 2005. Erratic voltage supply to the fuel lift pump causes premature wear of the pump. This premature wear could result in fuel lift pump failure and in some cases may cause an engine stall condition.

Risk

Should the engine stall, a vehicle crash could occur.

Remedy

Cummins will notify the owners of the freightliner and thomas built vehicles and will repair the engines by emc recalibration and replacement of the fuel lift pump at no charge to the customer. Owners may contact cummins assistance center 1-800-diesels (1‑800‑343‑7357) or freightliner at 1‑800‑547‑0712.

Recall number 05V469000 · Recall details

What is wrong

Certain van chassis with single rear tires fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the rear tire rating was incorrectly entered in the gawr/gvwr calculation program on certain single rear tires. The rear gawr and gvwr will be incorrect when the gawr is limited by the tire capacity on chassis with these tires.

Risk

This could cause premature tire tread wear or tire failure during normal driving which could cause a crash.

Remedy

Dealers will mail new chassis identification labels with the correct gawr, gvwr, and tire information. The recall began on september 12, 2005. Owners may contact freightliner at 1‑800‑547‑0712.

Recall number 05V138000 · Recall details

What is wrong

Vehicle description: heavy duty trucks equipped with trw tie rod ends on certain meritor axles. The tie rod and drag link ball stud ends contain bearings that are below the specified case depth and/or hardness.

Risk

This can lead to premature wear with possible separation of the ball stud from the socket, increasing the risk of loss of control of the vehicle.

Remedy

Dealers will remove and replace all affected tie rods and drag links with different designed ends. Owner notification began november 8, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.

Recall number 01V140007 · Recall details

What is wrong

Vehicle description: step vans. The back-up brake pump was wired to a 25 amp fused circuit instead of the required 50 amp fused circuit. If the back-up hydraulic brake pump were to engage due to a failure in the primary brake assist system or the brakes are applied without the engine running, the fuse could blow.

Risk

This results in a loss of power assist to the brake system, increasing the risk of a crash.

Remedy

Dealers will rewire the back-up brake pump circuit. Owner notification began july 23, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.

Recall number 01V117000 · Recall details

What is wrong

Vehicle description: step vans. Water could enter the electrical relays resulting in an electrical short.

Risk

This could potentially cause an electrical fire.

Remedy

Dealers will install a new sealed relay and fuse box with sealed relays. Owner notification began july 23, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.

Recall number 01V116000 · Recall details

What is wrong

Vehicle description: heavy duty trucks, shuttle buses, transit buses and step vans equipped with allison 1000 or 2400 series transmissions. These transmissions can experience park pawl to rear cover interference due to an out of flatness condition.

Risk

This could cause non-engagement of the park pawl when the transmission shift selector is moved to the park position, resulting in unintended vehicle movement and a vehicle crash without prior warning.

Remedy

Allison transmission is conducting the owner notification and remedy for this campaign. Dealers will remove the transmission from the vehicle, replace the park pawl, and reinstall the transmission in the vehicle. Owner notification is expected to begin during september 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact allison at 1‑800‑252‑5283 or freightliner at 1‑800‑547‑0712.

Recall number 00V229001 · Recall details

What is wrong

Vehicle description: heavy duty trucks. The throttle cable can bind due to misalignment with the fuel pump assembly.

Risk

Engine speed will not return to idle after the driver releases the accelerator pedal if the cable is binding.

Remedy

Dealers will realign the cable bracket. The cable assembly will be inspected for damage and replaced as necessary.

Recall number 99V255000 · Recall details

What is wrong

Vehicle description: step vans equipped with spicer 6,000 or 8,000 lb. Front steer axles. The tie rod end can pull outboard and separate from the tie rod tube due to improper thread engagement between the male tie rod end and the female tube.

Risk

Separation of the tie rod end could result in loss of steering control, increasing the risk of a vehicle crash.

Remedy

Dealers will replace the complete tie rod assembly.

Recall number 99V033003 · Recall details