2002 Georgie Boy Cruise Air recalls

What is wrong

Coachmen is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk

The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Remedy

Coachmen is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The safety recall began on february 21, 2011. Owners may contact norcold at 1‑800‑767‑9101.

Recall number 11V065000 · Recall details

What is wrong

Coachmen is recalling 932 model year (my) 1999-2003 georgie boy cruise master, my 2000-2002 maverick and pursuit, my 2000 & 2002 cruise air and my 2001-2002 suite motorhomes equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.

Risk

If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Remedy

Coachmen is working with norcold and norcold will notify owners and the vehicle's refrigerator will be repaired free of charge (please see 09e-027). Owners may contact norcold's recall center at 1‑800‑767‑9101.

Recall number 09V289000 · Recall details

What is wrong

On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.

Risk

An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.

Remedy

Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800‑932‑3837 or coachmen at 1‑877‑876‑9024.

Recall number 03V374000 · Recall details

What is wrong

Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.

Risk

In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.

Remedy

Dealers will repair the brake warning lamp circuit. Owner notification began march 13, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact georgie boy at 1‑800‑521‑8733.

Recall number 03V041000 · Recall details