Georgie Boy Maverick recalls

What is wrong

Coachmen is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk

The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Remedy

Coachmen is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The safety recall began on february 21, 2011. Owners may contact norcold at 1‑800‑767‑9101.

Recall number 11V065000 · Recall details

What is wrong

Coachmen is recalling 932 model year (my) 1999-2003 georgie boy cruise master, my 2000-2002 maverick and pursuit, my 2000 & 2002 cruise air and my 2001-2002 suite motorhomes equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.

Risk

If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Remedy

Coachmen is working with norcold and norcold will notify owners and the vehicle's refrigerator will be repaired free of charge (please see 09e-027). Owners may contact norcold's recall center at 1‑800‑767‑9101.

Recall number 09V289000 · Recall details

What is wrong

Coachmen is recalling 13,662 my 2002-2008 motor homes, fifth wheel and travel trailers equipped with glass shower doors and manufactured from june 15, 2001 thorugh august 6, 2007. When pressure is applied to the towel bar on the glass shower door, the edge of the bar may contact the glass.

Risk

Glass breakage may occur which could cause personal injury.

Remedy

Owners will be provided with new mounting hardware for the towel bar and installation instructions. If an owner is not comfortable replacing the hardware themselves, a dealer will install the hardware at no cost to them. The recall is expected to begin on or about december 19, 2008. Owners may contact coachmen at 1‑574‑825‑5821.

Recall number 08V639000 · Recall details

What is wrong

Coachmen is recalling 37,293 motorhomes and fifth wheel travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Risk

Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.

Remedy

Coachmen is working with dometic in order to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or coachmen at 574‑825‑5821.

Recall number 08V279000 · Recall details

What is wrong

Coachmen is recalling 4,231 my 1999-2002 georgie boy cruise master, landau and pursuit, my 1999-2000 cruise air, my 1999-2001 maverick and my 2000-2002 georgie boy suite motor homes equipped with norcold refrigerators. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak.

Risk

Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.

Remedy

Coachmen is working with norcold to repair these refrigerators. Norcold will provide thermal switch kits to owners along with the necessary forms and instructions. The recall is expected to begin during june 2008. Owners may contact norcold at 1‑800‑767‑9101 or coachmen at 1‑800‑453‑6064.

Recall number 08V271000 · Recall details

What is wrong

Vehicle description: recreational vehicles equipped with 45 amp magnetek power converters. A weakened bypass capacitor on the converter's printed circuit board can cause a breakdown of the capacitor allowing electrical current leakage.

Risk

Electrical current leakage could result in a fire.

Remedy

Magnetek is replacing these power converters.

Recall number 98V240004 · Recall details