GMC Envoy 360 headlights problems

Filed Jan 28, 2016 · Lights · 80,000 miles · TX

Low beam headlights turn on and off without warning...either in motion or stationary

Filed Jan 20, 2016 · Electrical, Engine · 119,000 miles · NY

Gas sending unit/fuel pump lines rot out due to corrosion and spray gasoline all over the underside of vehicle. The vehicle might stall but often times it keeps running, all while spraying gasoline all over the place. This one does not even trip a check engine light while running in this condition. The only warning was the smell of gasoline- some people do not have a sense of smell, and this could have been very dangerous. This is a fire waiting to happen. This corrosion issue is known to gm, why is this not a safety recall? This let loose on my sister in-law while driving, it could have resulted in explosion or serious fire. Gm knows that these rot out prematurely due to poor materials and combined with road salt and environmental effects in snow states. This vehicle also suffers from the driver door switch for door locks and windows not always working, due to shorting out from water...again a known issue with "some" units of this year, but this has not been recalled on this particular "unit" yet. Some of these have shorted out and caused fires- combined with the leaky gas sending units, this is a serious safety hazard. Do not park this vehicle in a garage- a fire waiting to happen...come on- make gm take care of these problems before someone gets killed. This truck was at a dealer for the fuel leak, they told her it needs a sender unit and a bunch of other things that have failed on this poorly built truck, which include wheel bearings, ABS sensors. Steering wheel sensor (? Really) inop door locks, leaking fuel, water pump leaking, failing headlights- that work when they want, and a whole bunch of other repairs. This fuel and electrical issue(s) should be immediately recalled. This is affecting a lot of people who live in the northern states with snow and salt on the roadways.

Filed Dec 17, 2015 · Lights · NC

Tl* the contact owns a 2007 gmc envoy 360. While driving at various speeds, the headlights failed to illuminate. The failure recurred multiple times intermittently. The vehicle was taken to an independent mechanic where it was diagnosed that the headlight driver module overheated and needed to be replaced. The vehicle was not repaired. The contact was made aware of the federal safety agency campaign number: 15v519000 (exterior lighting) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was unknown.

Filed Dec 16, 2015 · Lights · 137,000 miles · AZ

Tl* the contact owns a 2007 gmc envoy 360. The contact stated that while driving at night at approximately 30 MPH, the headlights failed. The vehicle was not diagnosed or repaired. The vehicle was not included in the federal safety agency campaign number: 15v519000 (exterior lighting). The failure recurred on several occasions. The manufacturer was not made aware of the failure. The approximate failure mileage was 137,000.

Filed Dec 14, 2015 · Lights · 150,000 miles · OH · fire

Tl* the contact owns a 2006 gmc envoy 360. The contact stated that while driving at 60 MPH , the headlights failed to remain illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the wiring harness had melted which caused a failure in the fuse panel. The vehicle was included in the federal safety agency campaign number: 14v755000 (exterior lighting). The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 150,000.

Filed Dec 7, 2015 · Lights · PA

Tl* the contact owns a 2006 gmc envoy 360. The contact stated that there was a progressing failure in which the low beam head lamps failed while the vehicle was in motion. The contact constantly had to use the high beams each time the failure recurred. The contact later received notification of a manufacturer's recall to repair the hdmi failure. The dealer indicated that they were unable to provide a permanent remedy and that they could only provide an interim repair. The contact notified the manufacturer and they were unable to provide a permanent remedy to repair the condition. The vehicle was not repaired. The failure mileage was not available.

Filed Oct 22, 2015 · Lights · 146,725 miles · CA

Tl* the contact owns a 2007 gmc envoy 360. While driving 65 MPH, the headlights failed without warning. The vehicle was restarted and resumed normal operation. The vehicle was not diagnosed or repaired. The failure recurred. The manufacturer was notified of the failure. The failure mileage was 146,725.

Filed Oct 14, 2015 · Electrical, Lights · 118,000 miles · FL

Tl* the contact owns a 2006 gmc envoy 360. While driving at approximately 40 MPH, the head lamps failed to illuminate without warning. The contact had to turn on the high beams in order to see the road. The failure recurred three times. The vehicle was not taken to a dealer or diagnosed. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.

Filed Aug 26, 2015 · Lights · 100,000 miles · KY

Tl* the contact owns a 2007 gmc envoy 360. While driving at an unknown speed, the low beam headlights suddenly shut off and failed. The vehicle was taken to an independent mechanic who was unable to diagnose the cause of the failure. The manufacturer was notified and the contact was informed that the vehicle was not included in the federal safety agency campaign number: 14v755000 (exterior lighting). The failure mileage was 100,000.

Filed Aug 11, 2015 · Lights, Visibility · 60,000 miles · CA

Tl* the contact owns a 2007 gmc envoy 360. While driving approximately 55 MPH, the exterior headlamps and daytime running lights failed without warning. The failure recurred on several occasions. The vehicle was taken to the dealer, but the failure was unable to be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that the VIN was not included in the federal safety agency campaign number: 14v755000 (exterior lighting). The approximate failure mileage was 60,000.