2004 GMC Envoy: gas smell in the cabin

Filed Jul 27, 2018 · Fuel system · GA

Fuel tank. At least three years ago, I received a recall form gm because of the fuel filler tube/fuel tank was compromised and I was being recalled for a fun tank replacement. Went to my gmc dealer (nalley of brunswick ga) who told me that fuel tanks were on national backdoor even though they had the filler tube parts, would notify me when the tanks available. I faithfully revistedthem every 6 months to be told same story, still no fuel tanks. I believe now they are hoping I just go away. In the mean time I still cannot fill up the tank without having gas fumes emanating from under the car.

Filed Oct 26, 2017 · Fuel system · 95,000 miles · VA

Recently, when the A/C or heater is turned on, the smell of fuel comes thru the air vents. It is a strong odor which last for a few minutes to sometimes longer. I have to put the windows down in order to not get dizzy or get a headache. The vehicle be in motion or still for this to happen. Mileage is around 95,000. I've heard it's a cracked fuel line or fuel tank and read many complaints about the same; therefore, why no recall?

Filed Sep 18, 2017 · Fuel system · 147,000 miles · NY

Fuel odor -strong, from region of fuel tank. Loss of fuel while driving, far more than normal useage! Investigation shows faulty tank to fill line connection at tank 'spout'. Or fault at fuel pump area- hidden on top of tank. Parked strong gas odor. Driving or on grade, fuel loss !

Filed Dec 21, 2016 · Fuel system · 109,000 miles · NJ

Tl* the contact owns a 2004 gmc envoy. While the vehicle was parked, an abnormal fuel odor was present on the inside and outside of the vehicle. The contact stated that there was evidence of a fuel leak coming from the fuel filler neck. The vehicle was not diagnosed or repaired. The manufacturer was notified. The approximate failure mileage was 109,000. The VIN was not available. ..updated 05/05/17 *bf

Filed Jun 20, 2016 · Fuel system · TN

Tl* the contact owns a 2004 gmc envoy. The contact noticed strong fuel fumes in and around the vehicle. The vehicle was taken to a dealer for diagnostic testing and repair. The manufacturer advised the contact to call the dealer. The failure mileage was not available. Updated 08/04/16

Filed Dec 14, 2015 · Fuel system · 173,000 miles · NC

Tl* the contact owns a 2004 gmc envoy. The contact stated that while driving at 55 MPH, there were fuel fumes emitting from inside and outside of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 173,000.

Filed Sep 10, 2015 · Fuel system · 168,000 miles · MA

Tl* the contact owns a 2004 gmc envoy. While the vehicle was idling, there was a strong fuel odor. The contact noticed the fuel was leaking out of the fuel tank. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel tank ruptured and the entire fuel tank needed replacement along with the fuel pump and the fuel lines. The vehicle was not repaired due to the parts not being available. The manufacturer was notified of the failure. The approximate failure mileage was 168,000.

Filed Jan 22, 2015 · Fuel system · 198,365 miles · NJ

I bought this car last december . Went to gas station , got home smelt fuel odor. There's no visible leaks , just fuel smell from top of tank. This is not a common problem , lot complaints online . I have kids , and this unsafe. There are no recalls for this , gm should recall and fix .

Filed Dec 16, 2014 · Fuel system · 103,000 miles · OH

2004 gmc envoy verified by sims buick-gmc-nissan warren, ohio, to have a leak in fuel tank around filler neck area. Smell of gas always around and inside of vehicle. Vehicle leaks gas when filled completely. Vehicle being repaired 12-17-14. Gm will not provide any help due to vehicle being 10 years old and over 100,000 miles.

Filed Jul 21, 2014 · Fuel system · 103,000 miles · IN

Check engine light came on, took my truck to the mechanic to have it checked and testing showed codes of fuel evap leak. I had to get this fixed as I was due to get my registration renewed. Got the vehicle back went for emissions test and the"check engine light" popped up again just as emission test was being done!!!. I could not believe it! So not only did I incur cost of mechanic but the vehicle failed the emissions test. The tech at the emissions center said the codes showed "fuel evap leak" detected., while driving home from the emissions test I smelled a strong gas odor, pulled into my garage and looked under the vehicle and it was not leaking however my whole garage stunk of gas. My garage is attached to my house, let the dog out and the dog even sneezed!.... Being a weekend and my only way of transportation I drove the car as little as possible. Monday took the car back to the shop and the tech noticed the strong odor , later the technician called me to tell me that the lines to fuel tank and the fuel tank needed to be replaced as they were leaking but only when the vehicle was mobile!!!!!. He also told me that the vehicle was a fire hazard and I could not drive the vehicle. Now what! I had to get this fixed as I need the vehicle to get to work. The additional cost was $960 not to mention the extension I had to pay the dmv to extend my renewal registration. Had the vehicle back a week now, no more gas smell but lord and behold the "check engine light" just popped up again! This vehicle only has 103k and very well taken care of..the mechanic says the code is still reading "fuel evap leak" . Somebody please help.!!!!!!! It seems as tho I am not the only envoy owner with this problem!!!!!! I loved this vehicle but totally disgusted and disappointed in gmc.

Filed Feb 24, 2014 · Fuel system · 125,000 miles · ME

My service light came on during the summer of 2013 and diagnostics were completed stating that there was a pressure issue, then later in the fall, noticed fuel smell at time of fueling. Took car to shop to get checked, shop owner found recall for injuries demonstrated in my fuel system. Moved car to gmc dealer for official diagnostics, they stated that my car was actually a 2003, since it was sold in dec of that year and would not be eligible. I then found a recall notice published in 2007 that included 2002 and 2003 vehicles with the initial recall. Gmc told me that they did not have to cover warranty because it was a voluntary recall(they could not explain in a satisfactory way how this affected me as a consumer). The federal safety agency action # is pe07014. At the time of the symptoms, my car had less than 130,000 miles on it (as it has just 130 k on it now) and was just under 10 years old.

Filed Feb 3, 2014 · Electrical, Fuel system · 83,661 miles · FL

I have had an overwhelming smell of gasoline for weeks and my speedometer was only working intermittently. I took my car to an auto store and had them put it on the computer the code read small evap leak so I bought a new gas cap to attempt to resolve the issue. That didn't work so I took my car to the mechanic for it to be checked out as my check engine light came back on. On the first visit he scanned the computer and codes read po 442 & 445 ? Small/large emission leak, he checked all components and could find nothing. I took my car back as the speedometer issue was getting worse and the gas smell was still present the same code came up for the emission/evap leak and still nothing for the speedometer issue. He then did a smoke test and found that there was a crack in the filler neck of the plastic gas tank that cannot be repaired and must be replaced. He replaced the speedometer sender which still did not fix the issue. After much research I have found both of these issues to be a serious problem with other envoy owners. I would like to know why there has not been a recall on these parts and why gmc is leaving the cost of repairs up to the owners. These are manufacture??s defects. This is supposed to be a reputable company. I have called into gmc support and they as well as staff at a gmc dealership stated that this was the same issue as was stated in a recall but my VIN number wasn't included so no financial help was given. $1,215.29 later I have a new gas tank and my speedometer still does not work. This is ridiculous... Take ownership for your product malfunctions!!! How many complaints does there need to be before a recall is issued on these vehicle issues?