2004 GMC Sierra 1500 brakes problems

Filed May 26, 2020 · Brakes, Fuel system · KY

Corroded brake lines. This has been reported previously. I was driving down rural road getting ready to turn in my driveway when my brakes gave out. I was lucky enough to be able to get it into the gravel driveway without killing someone. When I looked underneath to find the brake lines were corroded and one had burst. I had part of the line fixed with copper tubing. I have since had 2 more lines burst. As well as a fuel line leak. This has become frustrating.*dt

Filed Jul 3, 2017 · Brakes · 999,940 miles · MI

I purchased this vehicle brand new in 2004 and have taken very good care and almost 100,00 miles in almost 14 years however I applied the brake and all the brak fluid came out I had to drive over a person lawn to avoid hitting a person and a moving vehicle on 7/1/2017 due to rusty brake line and checking all lines were rusted . I am almost 75 years old and very concerned I was aware the lines were all rusted due to imported brake lines with inferior metals, never heard about and notice or recall.I almost injured a person and hit a car if I did not drive on someones lawn the vehivle was moving about 35 MPH .

Filed May 20, 2017 · Brakes · KY

Brakes went out as I was pulling into my driveway, brake line corrosion

Filed Feb 16, 2017 · Brakes, Transmission · 110,000 miles · WI

Power train PCM defective with transfer case with bad designing with shoe pump, and brake line corroded and leak. Brake system will not prevent vehicle to stop when brake lines are leak. For my 2004 I was lucky driving on slow speed on city road, and I was able to use emergency brake to stop my truck.

Filed Jan 26, 2017 · Brakes · 142,550 miles · PA

On january 24, 2017 traveling on pa turnpike at posted speed limit of 70mph, when I applied brakes to slow when approaching slower vehicles. Brake pedal went to the floor and vehicle almost ran into the rear of slower vehicles. Metal brake line ruptured above left front wheel. When inspected, all brake lines exhibited extreme rust/corrosion to the point of flaking and thinning. This is an extreme safety issue which could have resulted in a major collision and would have injured or killed occupants. This problem is a major known safety defect and needs to be remedied by gm.

Filed Nov 30, 2016 · Brakes · MO

Tl* the contact owns a 2004 gmc sierra 1500. The contact stated that the brake line had rusted completely. The contact took the vehicle to the dealer but the details of the repairs were unknown. The vehicle was not repaired. The failure milage was not available.

Filed Aug 25, 2016 · Brakes · 146,145 miles · MI

The brakes on my truck failed due to the brake line corrosion. I pushed on my brakes while backing out of my driveway lost all braking power and had my brake . Luckily I was in my driveway when this happened. All of the brake fluid leaked onto the ground, I had my vehicle towed to the dealership and had the brake lines replaced. Upon speaking with the service advisor he said that this was common and that the new brake lines were coated and will not rust. None the less the repair cost and towing cost was quite expensive.

Filed Dec 3, 2015 · Brakes · 89,900 miles · FL

Tl* the contact owns a 2004 gmc sierra 1500. The contact stated that while driving at 15 MPH, the brake pedal was depressed and failed to respond without warning. The contact was able to avoid an accident. The vehicle was taken to the dealer where it was diagnosed that the brake line was rusted and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 89,900....updated 02/04/16 *bf; 05/02/18

Filed Nov 26, 2015 · Brakes · 230,000 miles · GA

Brake lines are rusting causing brake failure due to pressure/fluid loss

Filed Jul 4, 2015 · Brakes · 53,000 miles · NJ

As I approached a major intersection the traffic light turned yellow and I applied the brakes preparing to stop. The brakes failed and the petal went to the floor. The truck rolled halfway into the intersection before I was able to step on the emergency brake and fully stop the truck. The dashboard flashed on indicating "repair brakes"...a little too late to help. If I had a vehicle in front of me , I would have hit it and possible injuries would have resulted. I had my daughter in the front passenger seat and was glad for seat belts.