2015 GMC Sierra 1500 engine problems

Filed Sep 25, 2026 · Engine · MA

In August, 2019, at 93,672 miles, GM covered a lifter failure on our 2015 GMC Sierra, V8 AFM engine. Only the left side was repaired. Now, in 2026 at 130,000, the right side has the same issue and needs repair. The estimate to repair is $16,697. This is a known issue and a safety concern.

Filed Apr 20, 2026 · Engine · SC

Active Fuel Management Miss firing Idle rough Shaking Loss of power #7 cylinder loss of all compression Bad fuel mileage Skipping

Filed Mar 17, 2026 · Engine · 124,000 miles · FL · fire

The contact owns a 2015 GMC Sierra 1500. The contact stated that while driving at approximately 45 mph, he observed a popping noise beneath him. The contact stopped the vehicle and observed smoke emanating from the front of the vehicle. The vehicle went into limp mode, lost power, and when the brake was depressed, the vehicle did not slow the vehicle down as intended. The contact stated that as he pulled into a parking lot to inspect the vehicle, he observed flames emanating from the hood. The contact stated that he pressed the hood latch, which did not open the hood, and he then exited the vehicle and observed the hood engulfed in flames. The contact mentioned that a store employee brought a fire extinguisher out and attempted to extinguish the flames. The fire department was called and extinguished the fire fully. There was no police report, but the police did come out to assist. The contact sustained a right-hand injury, but medical attention was not needed. The vehicle was then towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 124,000.

Filed Mar 8, 2026 · Engine · ID

Another GM truck AFM failing. It failed at 70,000 miles causing P0307 cylinder 7 misfire. No aggressive driving just commuting to work. Truck just got done with a new oil change. It's another to add to the hundreds/thousands seen on Reddit threads of all 5.3/6.2 AFM/DFM that this organization turns a blind eye to.

Filed Jan 22, 2026 · Engine · AL

The engine seized up traveling about 40MPH in the middle lane on a busy road with my child in the passenger seat. I was able to get off the busy road but part of my truck was still intruding into the lane. The truck is parked at my house. The vehicle has not been inspected by anyone and is still in the same condition as the day the engine seized. The only thing that indicted any issue was a couple popping noises right before the engine seized. It all happened while I was driving in traffic and I did not notice any indications on dash. I was more concerned about getting off the road and out of traffic before I got rear-ended or involved in a pile up.

Filed Dec 8, 2025 · Engine · TN

The GMC Sierra 1500 started a knocking sound. The collapsed lifter on a AFM cylinder bent a push rod which led to cam failure. Metal fragments are throughout the oil system.

Filed Nov 2, 2025 · Engine · FL

While driving the vehicle at approximately 40MPH the motor made a tapping sound, I was able to pull into a parking lot and have the vehicle towed to the dealer. The dealer told me that the vehicle was out of warranty and appeared that under initial inspection the would have to rebuild the motor due to a lifter failure at the estimated cost of $18,000. I had the vehicle towed to a reputable repair shop and after the did a tear down to the small block they determined a bent push rod and broken lifter, all pushrods and AFM lifters were replaced at the cost of $10,754. dollars as invoice shows. The issue occurred again on 10/25/25 causing catastrophic failure that will cost me a complete engine replacement.

Filed Oct 31, 2025 · Engine · WA

This occurred 5+ years ago. Coming home one night I had a sudden loss of power with the truck and barely made it home. Was able to limp the truck to the dealership the next day and was told that one side of the engines lifters had failed. Prior to the failure I had noticed a ticking sound coming from the engine that was becoming increasingly more prominent. It was several thousand dollars to repair. Fortunately the failure occurred near home, not on the freeway where I could have been dodging cars while trying to limp the truck to the shoulder. Some online research while the repair was being done revealed that several other owners with the 6.2L engine had the same problem. When I mentioned it to the dealer the response was that they had no bulletins from GM on the issue and I was stuck with the bill. Got the same response a year or two later when the torque converter on the transmission went out. The reason I am reporting it now is I saw that GM is recalling 6.2L vehicles with lifter issues but not back to 2015 even though the issue appears to go back farther than that. They claim it's limited to a specific run of engines for the recall. They have been having various lifter problems for many years that have put drivers in danger when they fail but refuse to acknowledge it. As for the repair they made to the engine I've driven another 70 K miles and the ticking has started again. I fear another failure. Please note that the date previously given for the incident is my best guess.

Filed Oct 13, 2025 · Engine · GA

Lifter and camshaft failed

Filed Aug 20, 2025 · Engine, Transmission · MI

I have owned 4 of these trucks in my lifetime ranging from 2007-2015 all equipped with the same drivetrain. 5.3l engine and 6l80 transmissions. All have had the same failures. The engine afm system particularly the lifters fail which in turn destroys the camshaft and destroys the engine. More importantly the transmission torque converter fails sending debris through the whole system causing a sudden loss of drive. This happened while driving down the road and was a safety concern for myself and others. This time it costed me $6500 to replace the transmission. All of the trucks I have owned experianced the same failures how is this not a problem?