There is a Service Bulletin on the Engine Oil Cooler line failure. It leaks or becomes detached form the crimp joint. Mine is leaking from the crimp joint and GMC says my VIN is not covered under this bulletin. N192220080 if this is a known issue on these vehicles why am I having to cover the costs for replacing a known faulty part. GMC said I could bring it in and have them perform the repair at my cost. The nearest service department is 100 miles away. I have it at a local mechanic that says it will cost anywhere from $1300 to $1500 to perform the repair.
2019 GMC Sierra 1500 engine complaints
Page 6 of 12: complaints 131 to 160 of 335, newest first, as owners wrote them.
5.3L V8 L84 Engine, 101,300 2nd owner Slowed down for traffic and was accelerating back to 80 when sudden loss of engine power coinciding with cylinder failure happened. Dealership determined lifter was collapsed. Lifter 1 failure at interstate speeds. Collapsed lifter caused damage to camshaft required both components to be replaced.
I had to get the cam and lifters replaced in the engine.
I live in Illinois, my 2019 GMC Sierra 1500 SLT has 51,318 miles on it as of 12/31/2025. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine Oil Cooler hose line detaching from crimp - small oil leak currently. Not yet fixed. Available for inspection. How was your safety or the safety of others put at risk? If this component fails, all oil from the vehicle will be lost and inoperable. This could cause a traffic accident, especially if towing a load. Has the problem been reproduced or confirmed by a dealer or independent service center? Confirmed by an independent service center. I will be taking my vehicle to the local GMC service center for additional confirmations. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, but GM has acknowledged the issue through these customer satisfaction surveys (CSP XXX/ XXX). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There has been no failure yet. A small oil leak was found on my garage floor. My issue is that this is a known issue in cold weather climates. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Friday night coming home. While entering my driveway. The check engine light came on. The engine sounded really bad. Rough idling. Saturday morning. Took it to a mechanic shop. While on my way to the shop, the truck had loss of power. The first mechanic shop told me that the truck was having engine failure. Was not sure at the time but the L 87 is known for having lifters and bearing failure. Monday the truck was taken to the dealership Novak motors. For extended warranty, repair or possible engine replacement. It has been two weeks. Have not heard anything yet. But the timing of the incident was good. Because the engine failed when I was pulling in to my driveway.
Ecm completely failed during drive no previous warnings
On November 25th, 2025 I had my wife, kids and baby grandson in my truck driving approx 50 mph when the trailer brake light appeared on my dash. I thought that was strange since I was not pulling a trailer. Shortly after my truck felt like it was going to stall and complete loss of power. I pulled into a turn lane and coasted into a gas station parking lot. I put the truck into park and turned the motor off and then restarted it. The truck was running extremely poor and sounded like it had rocks loose in the motor. I had it towed into an automotive repair facility I have always used and they told me my engine was gone and had to be replaced. I had been told by an oil change company a few weeks before that this engine was under a recall. I checked into it but this model year was not included. I did further research and founded out that this model year was under review. Something needs to be done as I was lucky this was not a busy highway or this could have ended worse.
I was driving up the road truck cranked up fine started a morning commute, on cruise control the truck instantly out of nowhere lost power completely with no signs of anything and engine won’t attempt to turn over now. I fear the worst has happened which would be catastrophic internal failure for to a faulty engine & its internals.
While traveling in high-speed traffic, the vehicle experienced a sudden and catastrophic mechanical engine failure without any prior warning lamps, messages, or symptoms. The failure manifest as a loud, rhythmic ticking and knocking noise immediately followed by a sudden loss of propulsion and severe engine shuddering. Safety Risk: The loss of power occurred in active traffic, creating an immediate crash hazard. Because the engine could no longer maintain speed, I experienced multiple near-miss collisions while attempting to navigate the vehicle to safety. This "limp mode" state placed myself and other motorists at extreme risk of a rear-end or side-impact collision. Component & Inspection: The failed component is the engine (6.2L L87 V8), specifically believed to be a failed lifter or bearing within the Dynamic Fuel Management system. The vehicle and its engine are currently available for inspection. Confirmation: The problem has been confirmed by a certified dealership service center. Diagnostic codes include P0300 (Random Misfire) and P0016. The dealership identified the symptoms as consistent with internal mechanical failure.
We were driving down a farm to market road at about 50 mph pulling an empty cattle trailer when we had a severe power loss, lots of dash lights and warnings. I noticed white smoke coming from the tail pipe. We limped it back to the house and unhooked the trailer and idled it into the Chevrolet dealership in Portland TX. The dealership just called and they said the #5 cylinder failed, there is metal in the oil and it will need an engine replacement at a cost of over $11,000.00. The truck is a 2019 and has just over 54,000 miles on it. No engine should fail at 54,000 miles and no company should sell one that does. Pulling a loaded trailer at highway speeds with a total engine failure could easily cause death to passengers and livestock. 12122025
Main bearing failure
For the last year I burn between 2 - 3 quarts of oill between oil changes. Dealer keeps telling me this os normal. I know it is not normal and I'm afraid of enging failure while engineering recall is in process
GM installed a 2023 6.2L engine in my 2019 GMC. The engine locked up while I was driving it. It had about 54,000 miles on it. There is a recall on the vehicles with the 6.2 GM engines that were made between 2021 and 2024. However since they installed it in my 2019 they are telling me they won't warrant it because the recall just list the vehicle year and not the motor year. This is not right.
Just had my 2019 GMC sierra 1500 Denali engine fail. My truck has 75k miles oil changed regularly no codes, issues or dash lights. Recently had it at GMC I Folsom California for a rear window replacement. Full inspection with no issues and nothing found wrong. Sunday 12/7 with my girlfriend and son in the truck about to get on the freeway felt a weird shift as I got on the freeway on-ramp. As I went to accelerate I had my traction control lights come on, lost power, and flashing check engine lights limped the truck off the side of the freeway and exited to a gas station. My truck wasn’t leaking anything and oil pressure was good but it sounds like popcorn was being made in my engine when it was on. Had my truck towed to Folsom GMC and yesterday 12/8 got a call I need a new engine. Called GM corporate to talk to them and opened a claim. GMC dealership got an initial help with 15% of the bill telling me I would need to pay $13,315. Talked to the service advisor and they put in a request for help from GM. Today at 9:00 a.m. they offered 50% coverage and I was able to get a little more but it still has me paying $7,500 and it will be 2-3 weeks to get the repair done. The dealership also will be getting me a loaner vehicle. This dealership has not been great but with this they are trying and doing a lot. However 75k on a truck that does not haul or have heavy use and is 7 years old with no prior issues is crazy. I was told cylinder 8 showed a misfire. Once they opened it up there was damage to the pushrods, valves and lifters with significant metal throughout the motor. I’m still waiting for corporate GMC to get back to me and hoping they will help or offer more money off as this is still a very large bill for a single father of 2 around the holidays. I bought the truck used with about 32k on it in 2022 and have had no mechanical issues or codes related to the motor or transmission.
Engine malfunction, had dealer look at truck and they said I needed a new engine, check engine light came on and a knocking noise appeared suddenly. Reading about 2021+ sierra with 6.2 engine that has a recall with the same problem as mine. Wondering why that recall wasn’t extended to my truck as well.
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving approximately 60 MPH, the vehicle started shuddering. The check engine and stabilizer warning lights were occasionally illuminated. The contact pulled over into a nearby gas station, and the vehicle was later towed to a local dealer. The vehicle remained at the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The local dealer informed the contact that the failure was related to the federal safety agency Campaign: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 49,000.
Engine failure on 12/1/2025 16,253 miles and 591.9 hours on vehicle. Vehicle has the 6.2l engine. Towed to dealership
Engine oil cooler lines leaking from crimp joints. "Oil Pressure Low Turn Vehicle Off" display showed on dashboard. Oil is present all over the bottom of my truck as well as a trail along the road and the parking lot where I parked it. I have not brought it to the dealership yet. There has been a Customer Service Program notice about this issue, I got my truck after the issue was sent out so I did not get the letter or supposedly this truck is not part of it even thought it is the exact issue. Customer Service Program number N212326940.
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at various speeds, the vehicle hesitated and failed to properly accelerate while the accelerator pedal was depressed. No warning light was illuminated. In addition, the contact was aware of excessive oil consumption and the vehicle was previously taken to a local dealer. An appointment with the same local dealer was scheduled to inspect the vehicle. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.
Complete engine failure. I was driving approximately 55 miles an hour, then all of a sudden the cruise control automatically shut off and a series of alarms are triggered. When pressing the accelerator pedal, the engine vibrated excessively in Cleary indicated catastrophic engine failure. I was lucky enough to make it to the nearby dealer who confirmed a complete engine failure. I ended up buying a new vehicle that day to avoid being stranded.
Around June 2025 under normal driving my truck displayed engine oil low which I promptly checked the oil to find that it was in range. The light later went off but I still brought it to the dealership to which they could find no issues. From there over the next month or so the truck developed a low end popping sound on start up and at my next oil change at the dealership in August of 25 I asked them to listen to see if they heard it and could recommend a course of action. They reported not hearing anything. On October 19th I had my family in the truck with me and during normal acceleration the engine had a loud pop sound and lost power. Every warning light came on and I pulled over promptly when safe. I had it towed to the dealership and their initial diagnosis was a failure on cylinder 4 with a suspected failure of either the cam shaft or lifter. Given the poor design of the lifter I didn’t want to go back with the OEM lifter so I had it towed to an aftermarket shop. It is there now and they are in the process of tearing down the engine. After watching a video on YouTube I fear my truck is part of the connecting rod bearing failure under PE25-001. My understanding is there is an official investigation into the trucks outside the initial recall. I wanted to submit this for your review as the truck only had 74,000 miles. Freeman GMC in Grapevine, Tx has performed all the maintenance and should have documentation.
my engine went out with no lights or warnigns prior to engine going out. Now we still making payments for the truck,expensive truck and we haven't use it because we dont have the money to fix it.
Less then 47 000 miles on truck, Used for only city driving, no off road driving or rigorous travel. - engine malfunction and could have had catastrophic failure while traveling causing injury to myself or others. -Car is inoperable, dealer recommend not to drive it due to safety concerns. -I have metal shavings in the oil, misfires, and a P0011 code. These match the known GM lifter/camshaft failure pattern. Vehicle started skipping check engine light turned on for cam shaft interrupter magnet. GM has open recall for 2021-2025 engine However 2019 vehicle is still under investigation.
While driving my Sierra AT4, my engine shut off with no previous indication of a problem. The dash simply said to restart the vehicle. Unable to do so, I coasted the vehicle into a parking lot. Once it was diagnosed to be a defective engine, I replaced it with a new GM long block assembly paid out of pocket as the vehicle had 210,000 miles on it and was well out of warranty coverage. The first replacement engine lasted 15,000 miles before developing a spun bearing in the engine. GM did cover replacement of the engine assembly. The 2nd replacement engine was installed 12/2022 and lasted until 2/2025. Same engine seizure problem as the original due to the bearing failures that plague this engine series. Engines have always run 0-w20 Mobil1 synthetic as recommended by GM. Vehicle is currently waiting for GM to make a decision to cover it or not.
Informant system tells me that the engine oil is low every time right at about 1,000 miles after I change the oil. There have been times where the engine has hesitated to accelerate shortly after receiving the message. I've taken truck to be serviced with no oil leaks found. I purchased this truck with 21,000 miles on it, and it's been doing this ever since I've had it.
2019 GMC Sierra that was not on recall list for engine, had same exact issue as the recalled engines. We were driving, light came on and it wouldnt work properly. We immediately took it for diagnoses and it was same reason as the recalls, however our engine wasnt on the list. We just had to pay 14K cash for our truck engine and repair. We purchased 5/24 with 78K miles and it stopped at 94K miles. We didnt have the truck for 5 months because of the motor recalls were backed up. GMC refusing to reimburse us even tho there is still issues with that motor
The starter started dragging about a year ago and on November 12 the 2019 GMC truck would not start. We had it towed to Harper GMC in Minden, La. They told us the motor was locked up. This vehicle has a little over 40,000 miles on it. Has always been parked in a carport out of the weather and still looks brand new. I see where 2021 GMC trucks have a recall on the motor and this is the same problem with our 2019.
The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at 25 MPH and making a turn, the vehicle lost motive power. There were several unknown warning lights illuminated after the failure. Upon investigation, the failure was related to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle was towed to an independent mechanic, where it was diagnosed with lifter failure and camshaft damage. The vehicle was repaired. The local dealer was not contacted. The manufacturer was contacted and opened a case, and referred the contact to the local dealer for assistance. The failure mileage was approximately 86,960.
Truck cut out going across the road almost got hit due to the vehicle stalling then about a mile down the road the check engine light came on parked it took it to my mechanic and after the incident it was throwing a cylinder misfire code. Cylinder one when the mechanic got in there was completely shot and I had to have a new motor. No warning no lights could have potentially caused a major accident.
Engine problems (Oil, crankshaft, loss of propulsion) similar to that of recalls in 2021-2024 models.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 GMC Sierra 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history