At 9,100 miles my 2023 pickup truck experienced engine failure. It was inspected by dealership in the town where truck was purchased and it is determined that it will need a new engine due to "bearing failure". This occurred 2/24/25. No indicators or warning messages appeared.
2023 GMC Sierra 1500 engine complaints
Page 8 of 9: complaints 191 to 220 of 238, newest first, as owners wrote them.
The contact owns a 2023 GMC Sierra 1500. The contact stated that while his wife was driving 60 MPH, the vehicle came to an abrupt stop, and the engine was seized. There were no warning lights illuminated. The driver was stranded on the highway for approximately two hours. The vehicle was towed to the local dealer, where it was diagnosed that the camshaft bearing had disintegrated. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 22,872.
I started truck and engine light came on.Coolant fan went super loud and would not stop at high speed. Code P1098 was seen.The dash read reduce acceleration drive with care.I had to have vehicle towed to GMC dealership.
The engine has blown for the 6.2L V8 Denali with 31,300 miles. I was told that this is happening on several of these engines. They told me it would be 3-4 months for repair as the engines are on backorder. I am not able to use a truck that I have purchased and am paying on.
Complete engine failure confirmed by GMC dealership service technicians. Incident Details: On [XXX] while driving at approximately 45-50 mph on [XXX] , my vehicle suffered a complete engine failure without warning. This resulted in sudden loss of power, inability to accelerate, no warning lights, near-accident, and the need to pull over in unsafe conditions. This failure placed me and my son, as well as others on the road at risk of serious harm and has left me with no confidence in this vehicle’s long-term safety and reliability—even with an engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Driving on a road. Suddenly the engine shut off and would not turn back on. I was stuck in the middle of the road with out the ability to put the truck in neutral to push it out of the way.
I was driving on the interstate and the vehicle just shut off with a warning stating conditions not right to shift. I had to drift off the interstate and the vehicle would not restart. This happened on 12/4/24 and has been at the dealership since.
Driving truck at highway speed and went to pass a group of slower vehicles on my right. I increased speed to 75 mph and the engine stopped and I had no acceleration. Engine would not shift into Neutral and would not restart. I coasted off to an exit ramp and the truck stopped in the middle of it blocking traffic for about an hour. Highway Patrol was on site to help direct traffic through the intersection of the off ramp and side road. We sat for approximately an hour before a tow truck could get us out of the intersection. The truck transmission was locked tight and the tow truck had to put the back wheel on skates to move it. I had to pay $175.00 to this tow truck company to move me approximately 200 yards to a local restaurant where we waited for the GMC provided tow service to arrive. GMC provided tow truck would only tow to nearest dealership which was in Weimer, TX. At the time of failure there was no warning. The truck just shut down making loud wining noises since the transmission was still in gear. This was an extremely stressful event and I was worried that someone was going to strike us at highway speed from the rear. Traffic was heavy that day on [XXX] heading [XXX] towards San Antonio and most left lane speeds were 75-80 mph and bumper to bumper traffic. The GMC Dealer in Weimer was very professional and inspected the engine on Dec 2nd notifying me that is was a total failure and would need to be replaced under warranty. The dealer had a new engine in hand within a few days and the truck was repaired with two weeks. I had a couple other issues with the OnStar system and the wireless after I picked up the truck and drive it home. I returned it to the dealer and proper parts were ordered to replace a bad control module that had failed during the engine failure. It took some additional time on my own after this was replaced to get my OnStar account back up and running correctly. This truck also had "tailgate drop" issues that the dealer fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT
I have a 2023 6.2L V8 GMC AT4. I have ~ 27,000 miles on the truck. On 2/1/2025, I was driving down the interstate going 78 mph and I lost all power to the truck. This was a MAJOR safety issue because I could only "coast" to a stop. I fortunately was able to get to the emergency lane and call a tow truck. I put others at risk because I had no choice but to move over. I had my truck towed to Brookfield Buick GMC dealership. Because I had no power, I had no HEAT. I sat for 1.5 hours before a tow truck could come to me. I was freezing because it was 20 degrees outside. The dealership told me that I had massive engine failure "seizure", which will require a NEW engine. I had no warning lamps or messages prior to the failure. This was a BIG safety issue and I'm fortunate I didn't get injured.
1) [XXX] - Was driving on the interstate at 65 - 70 mph when the truck suddenly shut off and shifted to neutral. I was in the far left lane and had to coast thru 2 lanes of high speed traffic to the right shoulder before the truck stopped coasting. Once I coasted to a stop on the right shoulder of the interstate, I tried to crank the truck up a couple of times and it finally cranked and I proceeded on to my destination. When I reached my destination and was attempting to park, the truck shut off again and would not crank after that. I then called roadside assistance to send a wrecker and take it to my local GMC dealer in Montgomery, Alabama. 2) My safety and others was put at risk when the truck, without warning, shut off and lost power while driving at 65-70 mph in heavy interstate traffic causing the truck to suddenly decrease speed and having to maneuver through traffic , without power, while coasting to the side of the road. 3) [XXX] - The service department at Mullinax GMC in Montgomery, Alabama called me about a week later to say the engine had "LOCKED UP" and that they had contacted GMC to begin the process of getting it fixed. They indicated that this was not uncommon with this model truck, and that it happens sometimes. 4) There were absolutely no warning lamps, messages, sounds or any other symptoms of the problem prior to the engine failure. I was caught completely off guard when the engine shut off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Complete engine failure while driving on interstate. Vehicle went into neutral. After rolling to a stop on highway. Vehicle would not go into gear. Tow was unable to put vehicle into saftey mode and had to drag vehicle onto tow bed. At dealership techs were also unable to get vehicle to turn on or go into gear. Dealer advised the engine was complete seized. This happened while traveling on the highway there was no warning or signs of something being wrong. Vehicle simply lost all power and went into neutral while traveling 70mph with 37k on the odometer.
I started my truck on [XXX] and after driving less than 3 miles the check engine light came on and then light for traction control needs service came on. I stopped and notice engine was idling weird. So I called dealer and they recommended I bring in. I proceeded to drive but could not drive over 40 mph as the engine would not idle past that and started hearing clicking noises. I slowly get the vehicle into service at McKinney GMC Buick in McKinney, TX. Two days later I get a call stating that engine needs to be replaced due to bearing failure and excessive metal in oil and oil filter. Which damaged the engine and is not repairable. The service center informed that this is common with my 6.2 L V8 and there are four other trucks same issues. The engine is on back order and don't know when I will be able to get my vehicle back. This appears to be a known issue for GMC and they are not telling people who could be in danger on road at any moment without warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Traveling on the interstate at highway speeds of 75mph and the engine spun a bearing resulting in complete engine failure.
At 28,000 miles and driving at highway speed, the 6.2L engine suddenly seized.
My engine started knocking while on vacation in Indiana (I live in TX) I took it to dealer [XXX] and it was diagnosed with bearing failure. Engine "ordered" on [XXX]. It is currently [XXX] still with no ETA for new engine. Stuck with a small/standard SUV (chevy equinox) for rental in place of my $74,845 Truck which is not a large enough vehicle for my daily usage, but no solutions or help added from GM customer service or dealership. There were no warning signs other that me hearing the noise. My GM app still states no current issues with your vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving on the interstate, my vehicle started losing speed. I pulled over to the shoulder of the interstate and put in neutral so I could coast further to the exit ramp where I would be in a safer location. My vehicle has 14037 miles on the odometer and has now gone through 2 engines. It has always been serviced by GM.
While idling, I noticed a knocking sound. Dealership found that rockers on both banks not rotating from lifter failure. Dealership replaced both lifter banks. Luckily this was caught early and was corrected for engine failure.
L87 engine locked up while driving dwon the highway. I have been waiting 7 weeks for a replacement engine.
I was driving my 2023 GMC Sierra pickup (26,634 miles) while towing a trailer. I also had three of my children with me. I was in the fast lane doing approximately 65 miles per hour when the vehicle suddenly started to lose power. The Low Oil Pressure light came on the engine started to make a banging sound. Then the vehicle said to turn it off. We immediately started working our way across three lanes of very busy traffic to get to the side of the road. We were almost hit by several semi-trucks and barely made it to the side of the road as the engine turned off. We could not get the truck to start again. It also would not go into neutral. We were in a very dangerous position due to semi-trucks going by us at a very high rate of speed. I had to call a friend to come get my children because I was fearful, we were going to be hit. An officer luckily came by and assisted us. The engine was replaced with a remanufactured engine by the dealer. The technician who worked on the truck said that the bearings failed causing the engine to fail.
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving on two occasions at 60 MPH, the vehicle stalled. The vehicle was restarted after the first failure but was unable to restart after the second failure. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 27,750.
During a drive home from dinner, my truck engine completely turned off. I was driving around 25 mph at the time. Car when into neutral and I pulled to the side of the road. Tried to restart the truck, but couldn't not. I had to have the car towed to a dealer. Just got confirmation that my I need a new engine. Then I found that the federal safety agency is investigating GMC for this very reason, so I thought I'd file a complaint. * My truck is currently at the dealership, so it is not available for inspection. * While I didn't feel my safety was at risk, If I was driving on a major highway, I may have felt differently. * Yes, problem has been confirmed by a dealership. * Vehicle has not been inspected by anyone other than the dealer. * The check engine light came on at the beginning of the drive, engine failed ~10 min later.
The truck has 12k miles on it and a week ago a bearing rod in the engine failed without warning. An engine should not have significant issues like this after only 12k miles of use. The truck is now with Williams Buick GMC in Charlotte, NC and waiting for a replacement engine.
My truck without warning the motor seized and stranded me in the side of a major route. This happened while driving 55mph and lost power and coasted to side of road.
On [XXX], in the middle of a 600 mile road trip from Idaho to Southern Nevada, the engine failed in our 2023 GMC Sierra with just 23,060 miles on the odometer. We stopped for fuel and upon restarting the engine to continue on our trip, the engine was making a harsh metal on metal knocking. We called for a tow instead of driving further. The truck was towed 242 miles to the nearest dealership (GM Roadside refused to do the tow since it was 42 miles outside of their limit) by our AAA membership. The dealership in Las Vegas took 5-1/2 weeks to look at the truck to determine what had failed. They pulled the oil pan and found that the rod bearings for the #1 and #2 rods had failed. If we had continued on, the rods would have seized and would have lost power to the brakes and steering. It's been nearly three months now, and we have no resolution from GM. They have agreed to a "repurchase" on the truck, but we have not been able to get any details on the buy-back for over three weeks. We are still waiting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I was driving my pickup to my farm. I was on a 4 lane divided highway, when i pulled into the left turning lane my pickup just randomly said "press Start/Stop button" so I stupidly did. The vehicle then shutoff or was already shutoff, I am not sure. There was no warning sign, dash lights, or weird engine noises. I would later learn the engine just blew up. The vehicle would not refire and I was forced to sit in the turning lane for 5 hours waiting for a tow truck. The highway was very busy and vehicles were buzzing past me constantly. Not a safe place to be at all! I could not get the vehicle into neutral or remove the parking brake. Multiple highway patrol officers stopped to help me and try to get the vehicle into neutral so we could pull it off the side of the highway to no avail. I crawled underneath the vehicle and disconnected the drive shaft, but then had no way of removing the parking brake. After many hours of waiting a tow truck showed up and my 1 year old pickup was drug onto it skidding the rear tires. The engine had around 12,000 miles. The vehicle went to a GM dealership for 4 weeks and got a new engine installed.
Going down beltway at 80mph on November 18 2024 the vehicle lost engine power. I had to drift vehicle across 3 lanes to shoulder and called tow truck to take to dealership. The dealership informed me that the engine had went bad and needed to be replaced. The vehicle had 63k miles on it and was out of warranty and they want me to pay 4k to replace.
Truck acted like it would not start several times in a day. Had battery replaced and it still did not fix the issue. Was told by dealership I would need to bring in and let them look at it. Was going to delearship and noticed a llight knocking in my engine then all of a sudden lost power. Was able to coast out of traffic and onto a curb. Truck would not start or even try, yet every light and such still worked. Had taken to dealership and this morning was told it was the engine.
I was driving along the freeway with my family of five. There were no warning lamps. There was an odd noise for about 10 seconds, and then the engine completely seized/locked up. I lost all ability to use the engine. I was able to come across three lanes of traffic, thankfully, without hitting anything without the ability to accelerate. GMC dealership inspected the car the next day. The engine is completely seized up. They are replacing the entire engine, but it has been a month without my car. They still do not have the parts available. We are fortunate. There were no other cars around us and I was able to steer to the Berm Across three lanes. This could’ve caused a catastrophic accident for my family.
There was noise in the engine area and after truck stalled
While driving along [XXX] in northern Arkansas the on [XXX] my 2023 GMC Sierra Denali's 6.2 engine suddenly locked up causing us to pull on to the shoulder of the road - nearly causing an accident. The vehicle had 23000 miles on it at the time. We were towing a two horse trailer with one horse aboard. At our expense, we had the vehicle and trailer towed back to St. Louis, MO then to O'Fallon Buick GMC. The dealer replaced the entire engine under warranty with a used rebuilt engine. They have omitted the engine replacement from the vehicle history report in CARFAX. The dealer had handled a number of 6.2 engine failures prior to this one. The vehicle was serviced well within factory guidelines at the dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 GMC Sierra 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history