2001 GMC Sierra 2500 brakes problems

Filed Feb 4, 2016 · Brakes · 180,000 miles · MI

Tl* the contact owns a 2001 gmc 2500 hd. While driving approximately 35 MPH and depressing the brake pedal, the brake pedal extended to the floorboard and failed to stop the vehicle. The contact engaged the emergency brake and placed the vehicle in park. The vehicle was towed to an independent mechanic who was diagnosed that the distributor brake block had excessive rust and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000. The VIN was unavailable.

Filed Jan 27, 2016 · Brakes, Fuel system · GA

I understand gm had a recall on the brake booster sytem and also a few years back a recall on replacing all the fuel injectors on the diesel engine ! I am oringinal owner at the same address when I purchased the vehicle new ! I missed the recalls because I never was notified ! Its sad to buy a gm product and they don't alert me to a recall ! What's up with this?

Filed Jul 21, 2014 · Brakes · 200,000 miles · MI

I connected my camper to the truck. Proceeded toward the street driving on the driveway. I applied the brake and felt a thump at my foot that's was applying the brake. The brake pedal went slowly to the floor. I was able to stop, looked under the truck and noticed brake fluid flowing from underneath the truck. Apon inspection my brake lines were totally rusted. The truck is in the repair facility as I write the complaint. The truck body is in great shape except for the brake lines. Better regulations need to be met regarding brake line. Please help.

Filed Oct 28, 2013 · Brakes · 68,000 miles · MI

Tl* the contact owns a 2001 gmc sierra 2500 hd. The contact stated that when traveling under 5 MPH, the contact stated that the pedal began to pulsate. The anti-lock brake system activated and the vehicle failed to stop immediately. The vehicle was taken to the dealer for inspection. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 68,000.

Filed Oct 17, 2013 · Brakes · 145,000 miles · KY

We had driven about 90 miles from our main house to our lake house on friday night-brakes were fine. Saturday morning we backed the sierra up and hooked up the boat to the hitch. After hooking up the boat while we were pulling out of the driveway the brake pedal went to the floor. We dropped the boat and drove the sierra a few miles to the store. While at the store we noticed a leak above the gas tank. The leak was brake fluid and the sierra took an entire bottle of brake fluid. We drove it the few miles back to the house and got the truck towed home the next day. When the gas tank was dropped we noticed rust so bad on the frame that a screwdriver went thru the frame. The frame could have busted apart right behind the cab of the truck. We were extremely lucky that there were no injuries.

Filed Sep 4, 2013 · Brakes · 35,870 miles · MD

I parked my vehicle and upon exiting observed fluid drips on the pavement. I touched and smelled the fluid and determined it to be brake fluid. I then observed fluid dripping from beneath the drivers side passenger compartment. I immediately checked the brake fluid res. And observed it to be below the 1/2 point. I was approximately 4 miles from my home and decided to take the back road which required less braking. The fluid was still leaking upon my arrival home. I should note there was no fluid leaking prior to departing my residence. I did notice the pedal travel to have increased and the feel to be slightly spongy as I drove down a steep grade requiring significant braking to maintain the 35 MPH limit into havre de grace. The vehicle (2001 gmc 2500hd) is not driven much and mostly for local (<15 miles) travel. The front rotors and calipers have been replaced and the lines bled approximately 2 months ago. There is rust evident on the brake lines. I might argue that due to the vehicle age this is to be expected; however, the extremely low mileage is equivalent to approximately three (3) years worth of driving. Having owned many vehicles, this is the first to have had such a problem. I now have the unscheduled expense of replacing the brake lines. I am lucky not to have been further from home where I might have experienced total brake failure possibly causing a crash.

Filed Dec 3, 2012 · Brakes · 35,000 miles · OH

Tl* the contact owns a 2001 gmc 2500 hd. The contact stated that he noticed a huge puddle of brake fluid under the vehicle. Upon further inspection, he was able to determine that there was a hole in the brake line and it appeared that the brake line was ruptured. In addition, the contact stated that the frame was completely rusted. The vehicle was not taken to the dealer for diagnosis. The contact wanted to purchase a stainless steel brake line and install it on the vehicle but he stated that it should have been the responsibility of the manufacturer. The failure and current mileage was 35,000.

Filed Sep 7, 2012 · Brakes · 130,000 miles · SC

Tl* the contact owns a 2001 gmc sierra 2500. The contact stated that while driving, the ABS warning light illuminated on the instrument panel. The contact turned the vehicle off however, ABS continued operating and drained the battery. The contact took the vehicle to the dealer where they advised that there was a shortage in the ABS and that there were no failures within the braking system. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 130,000. The VIN was unavailable.

Filed Sep 5, 2012 · Brakes · 176,000 miles · NY

All the brake lines are rusting through.

Filed Aug 31, 2012 · Brakes · 243,000 miles · PA

The steel brake lines from the master cylinder back along the frame rail on my gmc 2500hd rusted through and failed the other day, causing pressure and fluid loss, fortunately while traveling at a slow speed close to home. Of the various vehicles owned over the years, this is the first time I have had a steel brake line rust through like this.