2005 GMC Sierra 2500 brakes problems

Filed Mar 4, 2021 · Body, Brakes · 61,000 miles · KY

Tl* the contact owns a 2005 gmc sierra 2500. The contact stated he replaced all the brake lines on the vehicle and also stated that the body frame of the vehicle was corroded. The vehicle was taken to an independence mechanic where all the corroded brake lines were replace. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 61,000.

Filed Feb 19, 2018 · Brakes · 95,000 miles · IN · crash

Brakes failed while driving due to metal brake line corrosion causing an accident. Police report: mooresville, indiana pd #a17315

Filed Mar 2, 2017 · Brakes · 130,000 miles · NH

Break line rusted and broke almost resulting in an accident when trying to stop brake petal went to floor

Filed Sep 22, 2016 · Brakes · 54,000 miles · NC

Blew out one brake line lost all brakes no backup,pedal went all the way to the floor. 54,000 miles all lines rusted all needed to be replaced thank god I just pulled into a parking lot.

Filed Jul 9, 2016 · Brakes · 100,000 miles · NY

Taking vehicle out of park brake pedal went all way to floor because steel line ruptured causing massive leakage of brake fluid, rolled out of drive way into street cutting wheel to avoid wreck before could get in neutral and roll to stop !

Filed Jul 15, 2015 · Brakes · 216,000 miles · VA · crash

2005 gmc 2500hd that the brake lines failed. After checking they are rusted everywhere. I looked on the internet and I see that this is a ongoing issue with this model year.

Filed Dec 15, 2014 · Brakes · 101,000 miles · OH

The brakes went to the floor and vehicle did not stop, barely avoided a crash. Found pool of brake fluid under truck. Firestone auto charged $675 to replace a rusted out brake line. All other lines are heavily corroded and ready to fail as well.

Filed Oct 26, 2014 · Brakes · 58,771 miles · NJ

While driving to work approaching an intersection the car in front of me signaled to turn right last minute and applied the brakes, I also applied the brakes and the pedal went all the way to the floor. If I didn't have enough following distance I would have crashed right in to the car. I only had about 1/2 inch of brake pedal and drove in low gear very carefully the rest of the short distance to work. When I got out of the truck I saw brake fluid pouring out of the brake lines below the drivers side door and they were completely rusted out. Upon further inspection I realized all my brake lines were rusty on a nine year old vehicle, I never saw anything like this before. I had to get the vehicle towed and repaired at a local garage that charged me $1,547.61 to replace all the lines and did a horrible job. I had called the gmc dealer I dealt with in the past and they were inundated with recall work and had at least a 2 week wait and another gm dealer that gmc customer service provided me and they were also all booked up with recall work and so I was forced to trust a local shop. This a safety issue that could get people killed, I always have my wife and kids in the truck and it was a death trap. In talking to gmc reps is seems they have no intention to reimburse me for this premature and accelerated rusting condition that could have caused me or someone else their life.

Filed Jun 19, 2014 · Body, Brakes · 50,000 miles · MD

I bought my gmc sierra 2500 in june of 2005. Shortly after I bought the truck I started to notice rust on the trailer hitch and frame rails. As the years have gone by, the entire undercarriage is rusted over. Over the last several years a brake line rusted through and the brake pads & rotors have been replaced several times. I was lucky to be picking my truck up from the shop after an oil change & not driving it, when I noticed brake fluid on the ground under my truck.my speedometer does not work properly & the dashboard lighting works occasionally. My trailer hitch rusted so bad that the last time I put the receiver into the hitch it was stuck & I had to get a friend to connect a chain to his truck & while I drove forward & he reversed, the receiver finally broke free after approx. 10 minutes.

Filed Mar 25, 2014 · Brakes · 70,000 miles · NJ

Brake line under drivers side broke leaving vehicle without any regular stopping capability and requiring tow. Estimated replacement of all lines recommended by gmc dealer due to failures being common, $1,480 plus tax.