The vehicle experienced a catastrophic fuel system failure involving the high-pressure fuel pump and related fuel system components. While driving, the engine began stalling and lost power, making the vehicle unsafe to operate. The failed components were replaced during repairs; however, the repair records, photographs, and additional documentation are available for inspection upon request. The failure created a significant safety risk because the vehicle stalled unexpectedly while being driven, resulting in a sudden loss of power. This placed the occupants and surrounding motorists at risk by reducing the driver's ability to safely control the vehicle or move it out of traffic. The problem was confirmed by an independent repair facility, which documented extensive metallic contamination (metal shavings) throughout the fuel system. Photographs and videos taken during the inspections document metallic contamination within the fuel system. From our understanding, cp4 pump failure has been a common issue.
GMC Sierra 3500 fuel pump problems
15 of the 586 owner complaints about the GMC Sierra 3500 describe fuel pump failure, most of them for the 2016 model year.
- owner complaints
- 15
- worst model year
- 2016
- typical mileage
- 80,000
By model year
- 20231
- 20202
- 20191
- 20164
- 20152
- 20141
- 20132
- 20011
- 19991
Often reported together
Loss of power 4Stalling 3Power steering loss 1Check engine light 1
Trouble codes mentioned
P129F 1
What owners say
The contact owns a 2016 GMC Sierra 3500. The contacted stated that while her husband was attempting to start the vehicle, the contact stated that after five minutes the engine independently failed while the vehicle was running. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the fuel system and fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The contact was transferred to the federal safety agency Hotline to report the failure. The approximate failure mileage was 100,000.
The contact owns a 2020 GMC Sierra 3500. The contact stated while driving approximately 60 MPH, the vehicle jerked, lost motive power, and almost stopped unintendedly. There was no warning light illuminated. The contact was able to pull into a parking lot, where the vehicle shut off. The contact stated that while attempting to restart the vehicle, the diagnostic trouble code: P129F was displayed, and the vehicle failed to restart. The vehicle was towed to the residence. The local dealer was contacted and advised the contact that the failure might be related to the fuel pump control module and that the part was on backorder. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 19,000.
Bought the vehicle new in 2019 currently at a dealership to have the third in tank electric fuel pump installed. When it was in the shop for the second fuel pump installation the technician informed me that the pump can go out at any time causing a potential accident. Fortunately truck wouldn’t start and was diagnosed at dealership.
Fuel Pump Driver Module
Bosch CP4 fuel pump failure that shut down vehicle while driving, luckily did not cause an accident. Would not restart. Damaged entire fuel system including injectors and now have $17,000 in damage that needs repaired.
This is a 2016 GMC 3500 Denali truck with 70,000 miles on it. The Bosch fuel pump threw metal shavings into the fuel system. This is a known issue with GMC trucks with a Bosch CP4 fuel pump for 2011-2016. The engine suddenly quits running leaving the driver without power steering or power brakes. It happened to me when pulling a 14,000-pound 5th-wheel RV. Fortunately, I was on an interstate outside of Grand Junction CO and the road was flat. If I had been in the mountains going downhill and the engine quit I'd likely caused an accident perhaps fatal. GMC quoted me $16,000 to repair. Again, this is a known issue at GMC but they refuse to do anything about it. GMC Dealership in Grand Junction performed the analysis and advised me to drive it home to Phoenix. I got 60 miles when the engine quit. Cost me $1,600 to get the truck returned to my GMC Dealer in Phoenix and another $1,600 to get my trailer back home.
I own a 2016 GMC 3500 Diesel that had a serious mechanical breakdown while traveling on the freeway. The truck lost all motive power and needed to coast across 4 freeway lanes. Once towed to a local GMC Dealer, they diagnosed the problem as the Bosch CP4 fuel pump internally came apart while driving. I have to have this vehicle working so I got it repaired at a cost of $16,145. This is a known issue and losing all power while at highway speeds could have caused a serious incident. Please address this issue before someone dies.
Vehicle has a cp4 fuel pump. This pump has a high failure rate. Upon failure the vehicle shuts down and cannot be restarted. This can happen at any time and anywhere. Can happen while on a highway or freeway. This vehicle is used to haul heave loads. This failure can ending up to $10,000 or more to repair. This failure has not happened on this vehicle yet. Am very concerned about me safety and the safety of others because of the high failure rate.
CP4 High Pressure Fuel Pump failed/disintegrated causing metal shavings to be pumped through out the fuel lines, injectors and connected systems requiring a replacement of the pump, injector and fuel lines totaling over $11,000 in repairs. Trucks mileage was 94112 at the time.
Related recalls
Fuel system, gasoline: delivery: fuel pump: control/drive module
- What is wrong
- General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.
- Risk
- An engine stall increases the risk of a crash.
- Remedy
- The vehicle's engine control module (ECM) will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact GMC customer service at 1‑800‑462‑8782 or Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is N262544420. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on March 5, 2026.
Recall number 26V129000 · Recall details
Fuel system, diesel: storage: tank assembly
- What is wrong
- General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
- Risk
- An engine stall increases the risk of a crash.
- Remedy
- Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is N222368030.
Recall number 23V047000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.
- Risk
- If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
- Remedy
- GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.
Recall number 19V088000 · Recall details
Fuel system, gasoline: storage: auxillary tank
- What is wrong
- General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.
- Risk
- If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
- Remedy
- GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1‑800‑222‑1020 or for GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 17399.
Recall number 17V664000 · Recall details
Questions about the GMC Sierra 3500 fuel pump
Which GMC Sierra 3500 years have fuel pump failure problems?
The model years with the most reports are 2016 (4 complaints), 2013 (2 complaints) and 2015 (2 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used GMC Sierra 3500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history