Recall 03v159000 concerning windshield wiper motor: windshield wipers worked intermittently during inclement condition. Dealer was contacted. Dealer informed the consumer that this vehicle was not covered under this recall due to VIN.
The worst 1991 GMC Sierra problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes6
- Lights1
- Seat belts1
- Steering1
- Tires1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes6
- Lights1
- Seat belts1
- Steering1
- Tires1
- Visibility1
Recalls 1
Service brakes, hydraulic: foundation components: disc: rotor
- What is wrong
- Severe corrosion due to road salt at the joint of the stamped steel center section and the cast outer section can cause the sections to separate.
- Risk
- Separation of the rotor sections can cause loss ofbraking ability in the affected wheel. This could result in increased stoppingdistance and/or loss of vehicle control and an accident.
- Remedy
- Replace the front brake rotors with new rotors with a corrosion protection coating. However, if replacement of brake linings are necessary, it will be done at owner's expense since brake linings are normal maintenance items.
Recall number 93V119000 · Recall details
Technical service bulletins for the 1991 GMC Sierra 4
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline...
- Diagnosis of cracked or broken transmission case
- Spring slap noise from the rear of the gmt 400 series truck
- Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan
1991 GMC Sierra fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 6.2L 8‑cyl Diesel | RWD | 16-18 | 19-23 | 18-20 |
| 6.2L 8‑cyl Diesel | 4WD | 15-17 | 17-21 | 16-18 |
| 4.3L 6‑cyl | RWD | 15-16 | 19-21 | 17 |
| 5.0L 8‑cyl | RWD | 14 | 17-19 | 15-16 |
| 4.3L 6‑cyl | 4WD | 14-15 | 16-19 | 15-16 |
| 5.7L 8‑cyl | RWD | 12-14 | 15-18 | 13-15 |
| 5.0L 8‑cyl | 4WD | 12 | 16-17 | 14 |
| 5.7L 8‑cyl | 4WD | 11 | 13-16 | 12-13 |
What 1991 GMC Sierra owners say
Most recent owner complaints, unedited.
When the brake pedal is depressed, they failed to stop the truck immediately. This resulted an extended stopping distance. This failure has processed over time. The brake rotors are of poor quality and deteriorates. The rotors were replaced at 16,000 miles and needed to be replaced again at 24,000 miles. The second time the rotors were replaced, two were turned and two were replaced.
Looking for information on paint recall. My father contacted gmc about his paint but his warranty was up. He has not been notified of any recalls, he is the original owner. The paint is literly peeling off.
Bubbles would develop on the front passenger side tire causing the tire to go flat. Size lt 26575r16.
The bolts which held the steering column in place had come loose. The dealer advised there was no replacement part, however the entire column had to be taken apart to apply an "adhesive" to prevent the column from dropping. The dealer also advised it was common for the bolts to come loose. *ts *dt
Both headlight lenses have dryed out and clouded over greatly reducing visability.
Metallic brake line has rusted through, causing a fluid leak and loss of brakes. Dealer has not been contacted.
Seat belts do not latch. When tring to latch a piece falls out of the housing. Dealer has been contacted.
Vehicle has the anti-lock brake system on the rear brakes only. When the brake pedal is applied hard consumer will hear a clunking sound and will slide for about 7ft. Dealer has been contacted.
When driving the truck and applying foot to the brake pedal, it goes down to the floorboard and takes a while before the truck will stop. *ak
Compare the 1991 GMC Sierra
Other model years
1990199119921993199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017
Questions about the 1991 GMC Sierra
Is the 1991 GMC Sierra reliable?
Owners have filed 12 complaints about the 1991 GMC Sierra, fewer than a typical Sierra model year.
What is the most common problem with the 1991 GMC Sierra?
Brakes, with 6 complaints. Next is lights (1).
How many recalls does the 1991 GMC Sierra have?
1 recall, covering service brakes, hydraulic.
Was there a recall on the 1991 GMC Sierra brakes?
Yes, 1 recall: 93V119000. Check your VIN to see if your car still needs the free repair.
What year does the GMC Sierra have bad brakes?
The GMC Sierra model years with the most brakes complaints are 1999 (338 complaints), 2000 (228 complaints) and 2001 (150 complaints).
What gas mileage does the 1991 GMC Sierra get?
Official estimates for the 1991 GMC Sierra range from 12 to 20 mpg combined. The most efficient version (6.2L 8-cyl diesel, RWD) gets 16-18 city and 19-23 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 GMC Sierra?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history