The vehicle stalled 5 times in one morning while driving to work. The weather warmed up outside and the vehicle ran and started fine. The next evening the vehicle started fine, I got 1/2 block down the road it stalled again. I waited for a few minutes and it ran fine. The next morning it started fine and I drove it for miles, had no problems with it stalling. We called gmc to see if there was a recall on windshield wiper motor, because the wipers would work when they wanted to work. Not when you needed them to work. They had told us that there was also an ignition coil problem with this truck-they called the gmc dealer that was to do the recall work. A faulty ignition coil can give the same side effects as a defective fuel pump. We drove the vehicle to the dealer, when we turned the vehicle off it would not restart. The recall work was performed on the vehicle, but still would not start. The gmc dealer told us it was most likely the fuel pump, the dealer told us the fuel pumps in this vehicle go out "frequently." but, he offered us to replace the fuel pump for $450.+ including labor. Or sell us one over the counter for approximately $425.00 + tax. And we could install it ourselves. Needless to say, we had the vehicle towed to our house and now are deciding what type of fuel pump should be bought for a vehicle that the fuel pump goes out frequently in. Our biggest concern is that this truck has 85,066 miles on it, and has been maintained to the highest standards. Why are the vehicles fitted with faulty/defective products. The pump can catch on fire, or go out if you hit too many bumps in the road. That is a manufacturer problem of a faulty product. Please let us know, how many fuel pumps we should plan on replacing in the normal life of this vehicle.
1997 GMC Sierra: fire, smoke or burning smell
6 of the 238 complaints about the 1997 GMC Sierra describe fire, smoke or burning smell.
- owner complaints
- 6
- of this car's complaints
- 3%
- recalls
- 0
Fire, smoke or burning smell by model year
- 20171
- 20151
- 20142
- 20121
- 20103
- 20071
- 20063
- 20043
- 20032
- 20021
- 20012
- 20004
- 19991
- 19985
- 19976
- 19963
- 19951
- 19921
- 19901
What owners say
The vehicle was involved in a rear end collision, and the vehicle caught on fire.
Consumer state while traveling 60 MPH consumer notice gray smoke coming from vehicle consumer pulled vehicle over and noticed flames under vehicle consumer put fire out. Dealer has been contacted and stated fire came from transmission. Please provide further information. Nlm
Vehicle experienced fuel system problems twice, the sending unit inside the fuel tank with the fuel pump, wire assemblies and float, the wires and fitting plugs burned, the consumer is afraid that the vehicle may catch on fire.
Insulation around wiring and connector of unit inside fuel tank caught on fire due to a short. *ak consumer states plug and wiring were inside fuel tank, wires going to odometer and fuel pump, the fire was inside the fuel tank.
Fuel pump caught on fire. Manufacturer has been notified.
Service bulletins that may apply
Related recalls
No recalls on record for this model year.
Questions about the 1997 GMC Sierra fire or smoke
Is fire, smoke or burning smell a common problem on the 1997 GMC Sierra?
6 of 238 owner complaints about the 1997 GMC Sierra (3%) mention fire, smoke or burning smell. The model year with the most reports is 1997.
Is there a recall or service bulletin for this on the 1997 GMC Sierra?
There are 0 recalls and 2 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 1997 GMC Sierra
Wipers 21Jerking 16ABS 13Fuel pump 10Brake failure 8Pulling 8Stalling 7Tire blowout 5Transmission failure 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 GMC Sierra?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history