2001 GMC Yukon XL recalls

What is wrong

Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (ABS) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.

Risk

This can cause increased stopping distances during low-speed brake applications, which could result in a crash.

Remedy

Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1‑800‑630‑2438 or gmc at 1‑866‑996‑9463.

Recall number 05V379000 · Recall details

What is wrong

Certain trucks and sport utility vehicles were built with fuel module reservoir assemblies that contain fuel pump wires connectors may overheat under certain operating conditions.

Risk

If the ignition circuit wire is exposed, the fuel pump fuse will blow, disabling the fuel pump and causing an engine stall or no-start condition. If sufficient heat is conducted to the pass-through connector, a hole in the connector may result, which may cause a 'service engine soon' light to be illuminated during the emission system diagnostic routine. Fuel vapor and in some cases liquid fuel may leak out of the fuel tank through the hole in the connector body. Fuel leakage, in the presence of an ignition source, could result in a fire. Also if the ignition circuit or ground wire is exposed and shorts to the fuel level sender card wires, inaccurate fuel level readings may result.

Remedy

Dealers will remove the fuel tank, and remove the module reservoir assemblies from the tank, and install a new service kit free of charge. An interim letter to owners was mailed on may 25, 2005. The owners were re-notified on october 19, 2005, since parts are now availabe. Owners may contact chevrolet at 1‑800‑630‑2438 and gmc at 1‑866‑996‑9463.

Recall number 05V155000 · Recall details

What is wrong

Vehicle description: pickup and utility trucks. Some of these vehicles have an internal component in the outboard seat belt retractors for the 2nd and 3rd row of seats that could be cracked. With repeated actuation of the locking mechanism, the crack could spread to the point such that the seat belt would no longer lock.

Risk

In a crash, increased occupant injury could result from the no-lock condition.

Remedy

Dealers will inspect the outboard seat belts for specific lot numbers and replace the belts if necessary. Gm is enclosing an inspection procedure for the owners to use or they can have their dealers do the inspections. Owner notification began july 2, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1‑800‑222‑1020 or gmc at 1‑800‑462‑8782.

Recall number 01V159000 · Recall details

What is wrong

Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have loose or missing rear wheelhouse plugs. Under certain vehicle operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse.

Risk

These gases could flow into the passenger compartment if the plug is missing or loose and could cause possible illness, unconsciousness, or death.

Remedy

Dealers will inspect the vehicle for loose or missing wheelhouse plugs and install new plugs if necessary.

Recall number 00V343000 · Recall details