2020 GMC Yukon XL: engine failure

Filed Jul 23, 2026 · TX

The vehicle has an unpredictable and random tendency to hesitate when the gas is pressed. This has been happening at some level since the vehicle was new. The dealership service department was never able to get the vehicle to do what I was concerned about, so they never helped resolve the issue. Now that it is out of warranty, the issue is getting worse. It is to the point that I believe it is unsafe for anyone but me to drive it. I have to make sure that when I turn onto a new road, that there is absolutely noone coming because I cannot depend on my vehicle to accelerate quickly enough, even at a normal rate. It may lag and take its time speeding up, or it may accelerate normally with no issues. I stopped going to the dealership for oil changes and checking the issue because they no longer give loaner vehicles and they take a minimum of three hours for an oil change. So I recently took it to my trusted mechanic. He replaced the knock sensors, which helped slightly. He could still detect issues, but was concerned it would require a whole new engine built to bypass the DFM system and repair the cams and lifters. So I nw have to drive a vehicle that needs $20,000 worth of repair, has the potential to be dangerous or leave me broken down on the side of the road. It has 106,000 miles and I still owe $12,000 on it. From my research, I understand that this is a known issue and that there are several lawsuits regarding the issue. That does not help the average person who doesn’t care about a lawsuit, but is justifying st trying to live their average life with a dependable vehicle. Please help!

Filed Jul 12, 2026 · Engine · TN

My family drove from [XXX] to [XXX]. Upon arrival check engine light came on, we proceeded to a local shop, by the time we arrive check engine light was flashing and engine was knocking and was clearly malfunctioning. Shop owner recommended we transport the vehicle back home as service shops in the area were experiencing high volume and parts shortages. We had vehicle towed to a local shop in [XXX]. The engine is giving diagnostic codes P0300, P050D, [XXX] with internal knocking and tapping. Vehicle has been kept current on all oil changes and has no external leaks. GMC wants at least $12,000 to replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 20, 2026 · Engine · NM

Complete engine failure while driving on I25 in New Mexico, lost all power was able to roll into a airport parking lot. If I had not been close to the off ramp it could have been catastrophic with the truck traffic on the Interstate. The vehicle has completed all of its normal maintenance on time, and as of January 30, 2026 had a complete review from GMC that everything was in great shape including the engine. There was never a warning light, a maintenance message or any other indication.

Filed Jan 4, 2026 · Engine · KY

Knocking noise from engine-no check engine light initially. Next time it was started knocking was still present and the check engine light was on. Contacted Champion Chevrolet in LaGrange KY. Dealership diagnosed problem (Code P0308 - Cylinder 8 misfire). Compression test on Cylinder 8 failed. Removed valve cover and confirmed loud tick in the rocker shaft and worn camshaft lobes. Was told I would need a new engine and that repairing the existing engine was not cost effective. So, $22,722.14 later, i have a new engine in my 2020 GMC Yukon and have the original engine (core charge) in my shop in case it is needed for evaluation to help determine if the GM recall should be expanded to 2020 model year (and others not covered by the current recall).

Filed Nov 23, 2025 · Engine · PA

Complete Engine Failure at 83,986 miles and no prior signs that it was defective. Had GM initially look at it and they refused to cover the repair and indicated that it was due to faulty lifters. Took it to an independent shop, they tore it all down and indicated the lifters had trays that were not tight, which allowed the lifters to eat away at the camshaft. Due to that, metal shavings got into the main engine bearings and that is what ultimately caused the engine failure. While questioning how a new engine would be any more reliable than the one that failed, I was told that all engine suppliers were aware of the sloppy lifter play and the needed cam changes and new parts were all maid to a tighter spec so that this would not happen in the future. GM is fully aware of this issue and fortunately for me it did not result in my engine failing on the highway like others have. I was left with a $14,969.74 repair bill on something that should have never happened. I talked with current GM master technicians, and they indicated to me to stay away from anything pre 2025 because all engines were made to the same spec and they don't know why a change was not made sooner.

Filed Nov 5, 2025 · Engine · GA

The vehicle suddenly stopped working while driving with my family of 5 in the vehicle. There was no warning, messages or other symptoms of the problem prior to this. We had no idea there was anything wrong until it just stopped working. Then the engine light came on. Thankfully we were close to an exit and were able to pull off the road. We had it towed to a GMC dealer they found cylinder 7 intake lifter collapsed causing P0300 to set in ECM. Upon disassembly of bank one found lifter guide failed due to lifter collapse leading to camshaft lobe damage. The engine required replacement of camshaft and all lifters. The total cost of repairs was $10,115.72. When I reported this to GMC they said that our vehicle was not part of the current recall for engine failure because it was a 2020.

Filed Oct 14, 2025 · Engine · WI

We have owned the car for five years. We bought it new in 2020. Now, the engine has completely failed. It has the same problems all the recalled GMC Yukon Denali XL 6.2L V8 engines have; lifters are not functioning, cam shaft is destroyed, rods are bent, oil is pooling and the aluminum engine has melted. The engine light suddenly went off and we didn’t have acceleration. The vehicle started “puttering” and didn’t drive well. No warning at all. This is a known issue with GMC (which I just found out about) and I find it absurd I have to pay $26,000 for a new engine which will most likely have the same problem. Luckily nothing happened, but if that happened on the highway with my wife and three young kids in the car it could have been a nightmare situation.

Filed Sep 23, 2025 · Engine, Fuel system · OH

[XXX] [XXX] Phone: [XXX] Email: [XXX] [Date] the federal safety agency Office of Defects Investigation (ODI) 1200 New Jersey Avenue, SE Washington, D.C. 20590 Subject: Safety Complaint Regarding 2020 GMC Yukon XL Denali – Repeated Engine Failures (VIN: [XXX] ) To Whom It May Concern: I am writing to formally file a safety complaint regarding my 2020 GMC Yukon XL Denali (VIN: [XXX] ) which I purchased in 2021. This vehicle has experienced repeated and dangerous mechanical failures that raise significant safety concerns. •March 2024: The oil pump failed, resulting in immediate engine issues. Repairs were completed under warranty, but the check engine light remained on afterward. •April 2024: The vehicle broke down again. At that time, the cams and lifters were replaced in addition to other service, but the underlying issues were not resolved. •August 2025: The vehicle failed once again. After taking it in, the service department could not determine the cause. When they believed they had identified the issue and took it for a test drive, the vehicle broke down again and had to be towed back to the shop. At that point, I was informed that the vehicle now requires a complete motor replacement and a new fuel pump. Each of these failures has left me stranded and placed me and my family in unsafe situations on the road. Despite contacting the dealership (Joseph Cadillac of Dublin), General Motors, and the warranty company, none have taken responsibility to properly resolve the issues. I believe this represents a potential defect in the engine or related systems that could impact many other consumers. I respectfully request that the federal safety agency investigate this matter to determine whether a broader safety recall or manufacturer action is warranted. Thank you for your attention to this matter and for helping ensure consumer safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 27, 2025 · Brakes, Engine · OH · fire

I was driving down the highway, and my wife and I decided to stop at Costco to get protein bars and gas for the drive home. We also had a [XXX] , [XXX] old, and [XXX] in the car. As we were approaching the end of the exit ramp at approximately 30 miles per hour, the engine jerked the car two or three times then died. When it died, I lost power steering and the car slammed to a stop. The car also displayed an alert about my tow breaking system. I tried to restart it, and smoke began rising from my engine bay. I stopped trying to restart, and got my family onto the hill beside the exit while waiting for a tow. The tech at the GMC dealer stated that the engine had seized on me while driving. The cam shaft can rotate a small amount one way before getting blocked, and likewise the other way. Tech believes that the bearing is responsible, but will not be doing a tear down until September 2. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 25, 2025 · Engine · 52,000 miles · WI

The contact owns a 2020 GMC Yukon XL. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power, and an abnormal rattling sound was coming from under the hood. The contact stated that the message "Action Needed - Oil Pressure" was displayed on the screen. The vehicle was towed to a local dealer, where it was diagnosed with catastrophic engine failure due to metal shavings inside the engine. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

Filed May 22, 2025 · Driver assistance, Transmission · 46,000 miles · WI

The contact owns a 2020 GMC Yukon XL. The contact stated while driving at an undisclosed speed, the rear passenger side tire seized. The contact stated the vehicle was skidding, and the contact noticed an unusual sound. The vehicle was taken to an unknown dealer, but was not diagnosed or repaired. The contact related the failure to an unknown recall; however, the VIN was not included. The manufacturer was made aware of the failure, but no assistance was provided. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 46,000.

Filed Apr 30, 2025 · Engine · NJ · crash

Engine failure had to replace the motor.