2023 GMC Yukon XL fuel system problems

Filed Oct 20, 2026 · Engine, Fuel system · VA

The engine of this car failed at high speeds on [XXX], in [XXX], at 40,000 miles. GMC claimed the lifters in the 3rd cylinder failed and they were replaced under warranty. The lifters in the 3rd cylinder failed again, at high speeds on [XXX], at 77,000 miles. GMC claimed the lifters and crank shaft needed to be replaced. After paying for the repair and getting the car back, the engine locked up and failed within 30 miles of being fixed at 77,000 miles. Prior to these issues, there were no warnings and no symptoms. The car supposedly was not included in the engine recall by GMC. Two of the three incidents happened at speeds of 75 mph, the third occurred on a highway and speed of 55 mph. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 4, 2026 · Fuel system, Transmission · WV

Vehicle passed previous recall for engine defect related to complete engine failure, GM switched oil viscosity. Recall performed 10-16-25. Complete engine failure diagnosed at dealer 9-4-26, related to exact malfunction that sparked recall.

Filed Aug 15, 2026 · Engine, Fuel system · VA

Our lifters in cylinder 3 were replaced after failing at 40,000 miles. The exact same lifters broke again at 77,000 miles.both events caused engine failure.

Filed Jul 24, 2026 · Fuel system · AL

On July 14, 2026, I experienced a serious fuel system failure with my 2023 GMC Denali. That morning, I filled the vehicle with a little over 20 gallons of fuel at a gas station approximately two miles from my home. Later in the day, I made a short trip to my neighborhood swimming pool, roughly 1.5 miles round trip, with no unusual noises or warnings from the vehicle. Approximately two hours after returning home, I entered the vehicle to run an errand. When I shifted into reverse and began backing out of my carport, I immediately heard a scraping noise on the concrete. I stopped the vehicle and inspected underneath. At that point, I discovered that the entire fuel tank had fallen out of the vehicle and was resting on the ground. I contacted roadside assistance, and the vehicle was towed to the dealership. The dealership informed me that the fuel tank support straps were missing, which allowed the tank to detach and fall. I personally searched along all the routes I had driven earlier that day and did not locate any straps or debris. The tank itself showed no impact damage, suggesting it dropped cleanly rather than being torn loose by road contact. Although the vehicle is relatively new, my bumper to bumper warranty expired in September 2025, and I was charged for the repair. I have included photos taken before and during the tow, as well as the dealership’s invoice. I am extremely concerned about the safety implications of this failure. If the tank had fallen while I was driving at interstate speeds (approximately 70 mph), it could have caused a catastrophic fire hazard, loss of vehicle control, or danger to other motorists. I do not know how long the vehicle had been operating without fuel tank straps, nor why there were no warnings or indications of a structural issue. I also question why the dealership did not treat this as a manufacturing or assembly defect, given that fuel tank straps should not detach under normal use. ...RAN OUT OF CHARACTERS...

Filed Jul 24, 2026 · Electrical, Engine · CT

The car just died while going 55mph on the highway. Complete shutdown but luckily both the steering and brakes worked. After stopping it wouldn’t start again. I had my three children in the car aged [XXX], [XXX], and [XXX]. It was a horrific experience. GMC did some repairs to the engine that took over two months and then the car had a few more warnings pop up just a few weeks later. GMC now says there is a misfiring in one of the positions. I’m terrified of driving this car with my children as I don’t know when it will shut off again and how bad it will be! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 30, 2026 · Engine, Fuel system · NC

The vehicle has the L87 GM engine. It lost complete power and the engine seized up and would not start again. Fortunately I was able to roll into a neighborhood and get off the main road with no issues. The dealer has confirmed the seized engine and a replacement engine has been ordered with no ETA. There was no prior warning of the failure, besides a shuddering, like I was running out of gas, and then a lose of complete power.

Filed Mar 23, 2026 · Engine, Fuel system · TX

2023 GMC Yukon XL 6.2L V8 experienced progressive engine defects starting in first year. At 7,445 mi (Jan 2023), first dealer visit for engine issues. At 10,315 mi (Apr 2023), Cyl 2 fuel injector failed (internally open), vehicle TOWED to dealer, replaced under warranty. At 14,982 mi (Aug 2023), identical Cyl 7 injector failure (internally open), replaced under warranty. Two identical failures on different cylinders within 15,000 mi indicates systemic defect. By 30,409 mi (Aug 2024), dealer performed engine decarbonization due to carbon buildup from fuel injection issues. Dealer recommended additional decarbs at 38,077 mi and 42,577 mi. At 56,028 mi (Mar 2026), engine suffered catastrophic failure: piston ring failure causing excessive oil consumption and engine destruction, requiring full engine replacement. This matches GM's known 5.3L/6.2L V8 piston ring defect (subject of $150M class action settlement). Defective injectors caused incomplete combustion, carbon buildup on piston rings, ring tension loss, and catastrophic engine failure. Vehicle also has unfixed suspension defect (camber bolt/alignment). Vehicle visited dealer 8+ times. Engine failure poses serious safety risk from sudden power loss at highway speeds. Vehicle available for inspection.

Filed Mar 19, 2026 · Fuel system, Transmission · TX

High pressure fuel pump housing failed and filled the cabin with fumes. Rendered the the Yukon unsafe to drive with fuel flooding the engine compartment. Took the dealer 57 days to repair the car. No warning lights, only indication was the fumes in the cabin.

Filed Mar 7, 2026 · Engine, Fuel system · TX

My vehicle was one of the vehicles that was subject to the engine failure recall by GM. I took it to the dealership for the “repair“ where I was told the oil was changed to a different weight. Last night, I was driving down the road and all of a sudden my car just stopped. It still had power, but the engine had stopped. I tried to restart was unable to.

Filed Jan 18, 2026 · Electrical, Engine · OH

Good afternoon, My 2023 GMC Yukon XL AT4 with the 6.2L L87 engine (approx. 61,000 miles) suffered a sudden and complete engine failure at highway speed while I was driving between Canton, OH, and Columbus, OH, on the expressway, returning to my home in Cincinnati. There was no warning before the engine lost all power and propulsion. I was traveling in the left lane of the interstate in moderately heavy traffic. When the engine shut down, I only had steering and braking available to me. In addition to losing all propulsion, I also lost all electronics, and there was no shoulder. The complete dashboard shut down. The only reason there was not a collision was that the traffic around me could see what was happening and slowed down themselves. I coasted on through the onramp and found a shoulder where I had three lanes of traffic on my left and two lanes on my right. Less than two months before this incident, the vehicle had been inspected and serviced by an authorized GM dealer, and no engine issues were identified. I was given no indication that the engine was at elevated risk of failure. After the breakdown, GM and the dealer determined that the failure falls under GM Safety Recall N252494002 / the federal safety agency Campaign 25V274000, which involves internal engine defects in the 6.2L L87 that can cause a loss of propulsion in certain GM trucks and full‑size SUVs widely used as family vehicles. GM is replacing the engine, extending the warranty, and providing a loaner, but this does not change the fact that my family was exposed to a serious safety risk, nor does it address the possibility that other owners may experience sudden loss of propulsion even after their engines “pass” dealer inspection. I am submitting this complaint so the federal safety agency is aware that a recalled 6.2L L87 engine, inspected shortly beforehand, still failed without warning at highway speed in a primary family‑hauler vehicle, creating a dangerous situation. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(