The contact owns a 2021 GMC Yukon. The contact stated that while her husband was inspecting the vehicle, he discovered that there was no oil in the engine. The vehicle was taken to the dealer where it was confirmed that the engine was consuming an excessive amount of engine oil after performing an oil consumption test. The manufacturer was notified of the failure and agreed to cover 20% of the cost of the repair. The failure mileage was approximately 79,000.
2021 GMC Yukon engine problems
220 complaints (63% of all complaints for this car). Typical mileage when it fails: 81,000.
- owner complaints
- 220
- of this car's complaints
- 63%
- typical mileage
- 81,000
- crashes
- 0
- recalls
- 1
Which part fails
- Engine: crank/camshaft position sensor1
- Cooling system1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
GMC Yukon engine problems in other years
Specific symptoms reported on the 2021 GMC Yukon engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Engine failure 80Check engine light 60Knocking 43Loss of power 37Stalling 32Won't start 16Misfire 14Oil consumption 11
Related recalls
Engine and engine cooling: engine: hard parts internal/mechanical
- What is wrong
- General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
- Risk
- Engine failure increases the risk of a crash.
- Remedy
- Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1‑800‑333‑4223, Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is N252494000.
Recall number 25V274000 · Recall details
Related investigations
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V‑274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V‑274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GMâs recall remedy for Recall 25V‑274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V‑274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V‑274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
EA26005
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V‑274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V‑274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GMâs recall remedy for Recall 25V‑274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V‑274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V‑274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
RQ26001
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V‑274. These engines are installed in Model Years (MY) 2019â2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V‑274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V‑274, the federal safety agency has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V‑274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
EA25007
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GMâs full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engineâs bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V‑274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GMâs recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V‑274. Based on GMâs recall, ODI will close this PE. the federal safety agency will continue to investigate complaints of engine failure outside the scope of recall 25V‑274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE25001
What 2021 GMC Yukon owners say
Most recent owner complaints, unedited.
As I was driving down the road at 60mph, no dash lights or warnings were present. All of a sudden, my 2021 yukon lost all power and I nearly crashed as I was in heavy, fast paced traffic. I got to the side of the road, and it was at this time the engine light came on. Car died and wouldnt start back up.
crank/rod failure on 6.2 engine. yes it is available same as other people with blown 6.2s yes, GMC dealer diagnosed crank failure no no. engine still runs but is knocking and squealing but dies after a few mins and won't restart till it cools off
VEHICLE: 2021 GMC Yukon, 5.3L V8 (L84). VIN: [XXX]. Mileage at failure: approximately 88,000. Component: Engine. INCIDENT DATE: XXX While I was driving on a highway, the engine began to misfire and I heard a ticking noise. The check engine light then began flashing, indicating a severe misfire. I pulled off the highway immediately to a rest area. The vehicle was towed to a GMC dealer. The dealer's diagnosis suspected failed valve lifters, and the repair orders call for a misfire diagnosis with the Bank 1 cylinder head removed, and replacement of the camshaft, lifters, and related parts. This failure caused sudden loss of engine performance at highway speed. The engine began smoking. My family and I were in the vehicle, and we were fortunate there was a safe place to stop. I believe this is a known defect. GM Service Bulletin PIP5776, "Misfire Due to Collapsed Lifter," covers 2021 GMC Yukons with the 5.3L L84 engine. It describes a misfire with a bent pushrod leading to a collapsed lifter or a lifter that comes apart, and it attributes the cause to an internal lifter concern. Many other owners of GM V8 trucks and SUVs have reported the same failure, and a class action over the AFM/DFM lifters has been pending against GM in federal court in [XXX] since 2021. I bought this vehicle new and have maintained it. This is the second time this vehicle has left my family stranded on a highway. In 2024, a separate known issue left us, including three children under [XXX], on the side of a major highway about 7 hours from home. GM repaired that issue. For the current failure, GM has not agreed to cover the repair. It has offered $5,951.39 toward an engine replacement, which would leave me responsible for $13,886.59 plus teardown labor. I am filing this complaint so the federal safety agency is aware of this failure, which can cause sudden loss of power on the highway. GM case number: XXX. Dealer: Fred Beans Buick GMC, [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Bought 2021 GMC Yukon Denali new. Transmission failed at 70,000 miles. Engine has now failed at 111,000 miles. Both diagnosed at Capital GMC Atlanta, GA. Cost to replace transmission $8k (GMC paid half). Cost to replace engine $12k (GMC offered no assistance). Engine failure not related to current engine recall/investigation on GMC 6.2L V8 engines. This failure was on the top vs on the bottom (current recall).
In late February / early March 2026, at approximately 139,000 miles, my 2021 GMC Yukon Denali with the 6.2L V8 (L87) engine developed a loud knocking/rattling noise that sounded like a loose part inside the engine. The vehicle kept running, but the noise persisted. I took the vehicle to a GMC dealer. The dealer checked the VIN and told me there was no recall covering my vehicle. The engine was found to have internal damage consistent with connecting rod / bearing failure. A replacement engine was quoted at approximately $8,000. Because I could not afford that, an independent mechanic in Connecticut rebuilt the engine for approximately $5,500 in total (about $4,500 in parts plus $1,000 in labor), paid out of my own pocket. I have all the invoices for the repair. This failure appears to be the same connecting rod and crankshaft bearing defect covered by Recall 25V‑274 for other 2021–2024 vehicles with the 6.2L L87 engine, but my VIN is excluded from that recall according to the dealer and the federal safety agency/GM VIN lookups. No crash and no injuries occurred. I am reporting this failure so it is documented in the federal safety agency's investigation of L87 engines outside the recall population, and I respectfully request a review of why this VIN was excluded and whether reimbursement for the repair is possible if coverage is expanded.
The contact owns a 2021 GMC Yukon. The contact stated that while driving, the engine started making abnormal sounds. The vehicle was towed to a dealer. The manufacturer was notified of the issue. The dealer confirmed that the vehicle had experienced lifter failure and stated that further diagnostic tests were needed to determine if the engine needed to be replaced or if the lifters only needed to be replaced. The failure mileage was approximately 69,000.
While driving on the highway with my child in the car, the car suddenly began shaking and warning lights to check the power train came on the dash. There was also a loss of power in acceleration. Other error codes (303) also appeared with the check engine light also coming in. Upon checking the code later once home, it indicated there was an issue with the lifters. The car was then towed to the dealership where it was confirmed there are issues with both the lifters and the cam shaft and both need to be replaced.
I purchased this vehicle new in 2021. In XXX, the vehicle started shaking while driving then suddenly cut off. Mileage was a little over 12K. Diagnosis was an engine lifter issue. The dealership replaced all 16 engine lifters. The vehicle now has a little over 52K miles on it. The engine lifters have failed again. This is a known safety issue for this (and other GM vehicles) manufactured in the same timeframe. However, GM has not issued a recall. I am now looking at having to replace the lifters at my cost and/or driving an unsafe vehicle. I have a wife and [XXX] son. This is an untenable situation. GM must issue a recall and correct this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2021 GMC Yukon. The contact's wife stated that while driving at an undisclosed speed, the vehicle lost motive power and was unable to restart. The vehicle was towed to a dealer, where it was determined that a fuse had failed and needed to be replaced. The vehicle was repaired. The contact's wife stated that while driving 55 MPH after the repair, the vehicle unexpectedly shifted into neutral, stalled, and lost motive power. The vehicle was unable to restart. The vehicle was towed to another dealer, where it was diagnosed that metal shavings were found in the oil, causing the engine to seize. The contact was informed that the engine needed to be replaced. The contact associated the failure with the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was made aware of the failure on the manufacturer's website and by phone, and a case was opened. The approximate failure mileage was 72,850.
Questions about the 2021 GMC Yukon engine
Does the 2021 GMC Yukon have engine problems?
Owners have filed 220 complaints about the engine of the 2021 GMC Yukon, 63% of all its complaints, more than any other problem.
At what mileage do 2021 GMC Yukon engine problems start?
The typical (median) mileage in owner complaints is 81,000 miles.
Is there a recall for the 2021 GMC Yukon engine?
Yes, 1 recall: 25V274000. Check your VIN to see if your car still needs the free repair.
Other 2021 GMC Yukon problems
Fuel system 57Transmission 55Electrical 31Driver assistance 26Airbags 18Brakes 12Steering 11Seats 7Acceleration 6Suspension 6Seat belts 4Body 2Lights 2Visibility 2Tires 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 GMC Yukon?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history