Honda CR-V fuel leak problems

Filed Nov 9, 2026 · Driver assistance, Fuel system · NC

Vehicle: 2019 Honda CR-V (1.5L Turbo) Failure Mileage: 72,742 miles While driving, the vehicle experienced a sudden and catastrophic failure of the fuel delivery system. The primary engine malfunction illuminated the Check Engine Light, which immediately triggered a secondary safety system shutdown. The vehicle automatically disabled critical factory safety features, including the Collision Mitigation Braking System (CMBS), Road Departure Mitigation, Adaptive Cruise Control, and Lane Keeping Assist. The entire dashboard lit up with warning indicators, creating a significant distraction while operating the vehicle at highway speeds. A certified technician retrieved diagnostic trouble code P0172 (Fuel System Bank 1 Too Rich), confirming a fuel injector defect where raw fuel was leaking into the cylinders. The sudden, unprompted disabling of critical advanced crash-avoidance and emergency braking systems while in motion creates an immediate hazard to the driver, passengers, and surrounding traffic. Honda has refused to cover or remedy this known component failure outside of the baseline warranty period.

Filed Oct 22, 2026 · Fuel system · GA

In February, 2026, while driving the car after cold start within 1 mile of house, engine light started flashing, car was misfiring and was losing power. I had to pull over, turn the engine off, restart it and continue without incident. Car taken to Honda service department; no codes found; problem could not be duplicated; and unable to diagnose issue. Problem continued intermittently and became more frequent until 5/21/26. Honda service duplicated issue and diagnosed problem as leaking fuel injectors. On 5/22/26 car was repaired with 4 new fuel injectors and 4 new spark plugs. Repair cost was $3,549.01. Mileage was 60,775. Safety issue was loss of power on the road.

Filed Sep 15, 2026 · Engine, Fuel system · LA

While driving my 2023 Honda CR-V Hybrid at approximately 40-45 mph, the vehicle began hesitating and not accelerating smoothly. A Check Engine/Emissions System warning also appeared. The vehicle had approximately 31,873 miles. I took the vehicle to an authorized Honda dealership for diagnosis. The dealer recommended replacement of all fuel injectors and the spark plugs. The vehicle has not yet been repaired and the components remain available for inspection. I am concerned about the safety risk because the hesitation/loss of smooth power occurs while the vehicle is being driven and could affect the ability to accelerate normally in traffic. Honda has issued Service Bulletin 25-044 applicable to 2023-2024 CR-V Hybrid vehicles concerning leaking fuel injectors that can cause an excessively rich air/fuel mixture, foul spark plugs, illuminate the malfunction indicator lamp, and cause drivability problems. The repair procedure can include replacement of the fuel injectors and affected spark plugs. My vehicle has very low mileage for this type of fuel-system failure. I am reporting this incident so the federal safety agency can evaluate whether similar fuel injector failures and resulting drivability problems in 2023-2024 Honda CR-V Hybrid vehicles represent a broader safety defect.

Filed May 30, 2026 · Fuel system · MA

A franchised dealership has actively undermined a federal safety mandate, creating an immediate vehicle fire hazard. On [XXX], I took my 2018 Honda CR-V to Bedard Bros Honda in Cheshire, MA, for the federal safety agency Safety Recall Campaign 23V‑858 (Fuel Pump Module). During the service, the dealer identified a cracked fuel pump housing and attempted to charge me a $390 fee to replace it. When I declined this commercial upcharge on a safety recall, the technician reassembled the pressurized fuel system using the broken housing and released the vehicle to me. Prior to this appointment, the vehicle had no fuel leaks or odors. Immediately upon driving the vehicle home and parking it, the vehicle began actively leaking raw gasoline, filling the cabin with toxic, flammable vapors. The dealership’s decision to perform a federal safety recall inside a known broken component, and subsequently release a vehicle with a compromised fuel system to avoid completing a free repair, has created an active fire emergency. The dealer invoice explicitly documents the crack and their attempted charge. I am requesting a formal investigation into this dealership's handling of Campaign 23V‑858. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 21, 2026 · Engine, Fuel system · TX

System/Component Involved: Fuel System / Fuel Injectors / High-Pressure Fuel Joint Pipe Description of Incident and Safety Risk: My 2017 Honda CR-V (1.5T engine) experienced a fuel system failure evidenced by DTC P0172 and a failed AF cylinder test, confirmed by an authorized Honda dealer. This failure leads to engine hesitation and power loss, creating a safety hazard during operation. More critically, during the repair (Case #16244235), the dealer and manufacturer refused to replace the High-Pressure Fuel Joint Pipe. According to Honda’s official Service Manual and TSBs for the Earth Dreams 1.5T engine, this pipe is a mandatory, one-time-use component that must be replaced whenever fuel injectors are serviced. Reusing this component violates Honda’s own safety protocols and poses a severe fire risk due to potential fuel leakage under high pressure ($20\text{ MPa}$+). Safety Risk to Others: Reinstalling a non-reusable high-pressure fuel line creates a high probability of fuel spraying onto hot engine components, leading to an under-hood fire while driving. This endangers the occupants and others on the road. Reproduction and Inspection: The injector failure was confirmed by [Insert Dealer Name] in Houston, TX. The subsequent safety violation (failure to replace the mandatory fuel joint pipe) is documented on my repair invoice dated April 2026. The vehicle and the old part (if still on the car) are available for inspection. Symptoms and Warning Lamps: The Check Engine Light (DTC P0172) appeared shortly before the failure, accompanied by a strong gasoline odor and engine stalling symptoms.

Filed Apr 5, 2026 · Electrical, Engine · OH

My 2018 Honda CR-V (1.5L Turbo) has a confirmed fuel leak dripping directly onto the starter motor, creating an immediate fire hazard. A Honda dealer (Inv #XXX) diagnosed codes P219C and P219D, which are explicitly covered under Honda Service Bulletin 20-038 for a 150,000-mile warranty extension. Despite the vehicle having 131,528 miles, Honda Corporate is refusing to honor the warranty extension, claiming my VIN is not affected, while ignoring the documented failure and the dangerous safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 7, 2026 · OH

Twice this has happened after the car is running for a bit all the lights cycle through as errors parking assist, hill assist, power steering, etc... Took to a dealership was told it is the fuel injectors and gas leaking into engine oil. Had to have my fuel injectors replace and get a new oil change due to gas in the oil. I see there is recalls for 2021-2025 but 2020 are also having the same issues. I have only had this car for 2 years and had to buy all new fuel injectors.

Filed Feb 18, 2026 · Electrical, Engine · NY

Vehicle: 2025 Honda CRV HYBRID SPORTS TOURING VIN: [XXX] The vehicle is subject to an active recall involving the high-pressure fuel pump, which may leak fuel and create a fire hazard. Dispute prior dealer inspections, the during cold starts, abnormal ticking/ knocking noise from the high-pressure fuel pump area. The recall repair was not completed, and the defect remain unresolved. I'm concerned about potential fire risk and safety hazard. The repair didn't fix it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 30, 2026 · Driver assistance, Fuel system · MN

The vehicle began experiencing repeated engine misfires, hesitation, and loss of power during normal driving. The issue was diagnosed as failing fuel injectors, which is a known issue on this generation of Honda CR-V. The failure causes sudden hesitation and reduced engine power, particularly during acceleration and at intersections, creating a safety hazard in traffic. In some instances there was a strong fuel odor, raising concern for a potential fuel leak and fire risk. The injectors failed well before normal service life and required replacement. Honda has not issued a recall for many affected vehicles despite widespread reports of similar failures across multiple model years. This defect presents a safety risk due to possible engine stalling, loss of power, and potential fuel leakage.

Filed Jan 23, 2026 · Engine, Fuel system · IL

The fuel injector valves started leaking resulting in a P0172 Rich Fuel mixture diagnostic code. When fuel injector valves leak gasoline into the engine oil it can cause an engine fire, severe damage to the engine and catalytic converter. My daughter was driving the car when this happened which makes me very upset that a known safety issue has not been addresses by the federal safety agency or Honda. This effects millions of CRVs which is why Honda is fighting a recall and why the federal safety agency must step in and fine Honda and force a recall. The potential for engines catching on fire should result in an immediate recall. When I talked to the Honda shop manager he told me that he is seeing several CRVs every week with faulty fuel injectors and quite frequently bad catalytic converters. This is a well-documented problem which makes me wonder why nothing has been done.