2020 Honda CRF1100A: engine stalls while driving

Filed May 10, 2022 · Engine · NV

Bike will Stall occasional from a stop while trying to accelerate under light throttle. Just had a stall in heavy traffic waiting on a light to turn left off The Las Vegas Strip.. not cool, don't think its a DTC issue I think its the engine mapping, funny thing is when I had started the bike while I suited up it stalled while idling just 5 min before. I always ride S3/Urban in the city. Had a stall a few weeks back after a long highway ride in S3/Tour, same deal, waiting for a light to turn left. Just over 3200 Miles on it. Have had 4 stalls total.

Filed Jan 6, 2021 · Fuel system · 1,200 miles · NJ

Lost of power on highway and when struck in city traffic, usually occurs with less than half a tank of gas and when the temperatures are above 90f. Engine stalls as if starved of fuel.

Filed Nov 5, 2020 · Fuel system · 7,200 miles · GA

Motorcycle is only 6 months old with about 7,200 miles. Cruising on I-75 near ocala fl at highway speed, the engine began sputtering and stalling. Frightening safety threat in heavy traffic. Had to pull off road and have motorcycle towed to nearest dealer. I was 300 miles from home and incurred hundreds of dollars of expense. I understand this happens to many other like models. Apparently the coating inside the gas tank deteriorates and clogs the fuel filter and pump. Honda is well aware of the issue but will only have the dealer clean the tank and replace the fuel pump assembly. This will likely happen again since the symptom, not the problem, was repaired. Honda should be redesigning a replacement tank and recall the motorcycles for a long term solution.

Filed Jun 23, 2020 · Engine, Fuel system · 150 miles · MA

Brand new bike within the first couple hundred miles I have been experiencing "flame out" issues on the bike. Intermittently if the throttle is blipped on a down shift to rev match the engine it will stall out or "flame out" this is typically while riding down the street. Pull the clutch in, down shift and blip the throttle to rev match and sometimes it stalls out. I can also get this to happen sitting in neutral by revving the bike. As of 2,000 miles the bike now has no power no matter how much throttle I give it. My dealer had honda rep come look at it and he was able to recreate the issues twice in the shop. He also stated he believed the inside of the tank was flaking. Hondas solution is to clean the tank and replace the fuel pump I am waiting for the dealer to get the parts in for repair. I have read of many many others having the same issue and wanted to report mine. Very very very frustrating this is happening after spending almost 20k on a brand new bike.

Filed May 29, 2020 · Fuel system · 625 miles · TX

Debris in gas tank. Idle rough and stalls at various times while driving fuel starvation issue..