2018 Honda HR-V fuel system problems

Filed Oct 16, 2026 · Fuel system · 100,000 miles · MA

The contact owns a 2018 Honda HR-V. The contact stated that while driving at 40 MPH, a fuel odor was noticed inside the cabin. The dealer was notified of the failure, and the vehicle was towed to the dealer. The contact was informed that the fuel odor was normal following an unknown recall repair; however, a pool of fuel was discovered on top of the engine and cleaned up. The vehicle was repaired. The failure recurred. While the vehicle was parked, the contact noticed fuel leaking onto the ground underneath the vehicle. The vehicle was taken back to the dealer, where the undercarriage was cleaned, gaskets were replaced, and parts were tightened; however, the failure recurred. The contact again smelled fuel inside the cabin, which was confirmed by a service advisor, but a sniff test later yielded no signs of fuel odor. The contact stated that the failure began immediately after the unknown recall repair was completed. The manufacturer was notified, a case was filed and escalated, and the dealer was instructed to continue diagnostic testing. The failure mileage was approximately 100,000.

Filed Jun 11, 2026 · Engine, Fuel system · MA

My 2018 Honda HR-V had the federally-mandated Safety Recall 24-015 (Fuel Pump Motor replacement) performed on August 16, 2025 at Honda Westborough, Westborough, MA. The vehicle had zero EVAP-related issues or warning lights before that recall work. Approximately 9 months later, in May 2026, a parking alert and check engine light appeared on the dash. I brought the vehicle back to the same dealership. The technician retrieved diagnostic codes P0455 (large EVAP leak) and P0456 (small EVAP leak), performed a smoke test, and confirmed the leak was coming specifically from the FUEL PUMP MOTOR AREA - the exact same location where the recall work had been performed. The technician's own notes state: "confirmed leak coming from the fuel pump motor area." After replacing the O-ring and lock ring, the leak persisted at the same spot. A new fuel pump assembly (part# 17045-T7X-A02) was ultimately installed to resolve it. Honda Westborough charged me $1,676.61 for this repair, including $870.50 in labor and $724.83 in parts. When I contacted American Honda Customer Relations, they declined to reimburse me, stating the repair was unrelated to the recall. I strongly dispute this. The recall involved opening the fuel pump housing to replace the motor. The subsequent EVAP leak was confirmed by smoke test to originate at that exact location. No such issues existed before the recall. This is a direct causal connection. Other Honda owners on public forums (HR-V Forum, CivicX Forum) have reported identical P0455/P0456 EVAP leaks appearing within days or months of the same recall being performed, suggesting a systemic issue with the recall repair procedure, specifically, improper resealing of the fuel pump housing after motor replacement. I am requesting: 1. An investigation into whether the Recall 24-015 repair procedure is causing downstream EVAP system failures. 2. Honda be required to reimburse owners who incurred repair costs caused by improper recall workmanship.

Filed Aug 26, 2025 · Fuel system · NJ

Fuel pump is failing and not properly propelling the fuel which is causing the car not to start correctly and failing during driving

Filed Aug 11, 2025 · Acceleration, Electrical · OR

While driving the car to work the instrument cluster LCD display began to glitch showing garbled information on the fuel as well as effecting the speedometer reading. Having inaccurate speedometer reading due to a faulty instrument cluster can put others at risk due to not knowing your exact speed. There were no indications of a problem prior to this incident. Upon discussion with several HRV owners and forums this issue is likely caused by cracked solder joints on the board for the instrument cluster. The leadfree solder used appears to fail causing connection issues for the pins on the board and erratic read outs and displays. I plan to have the dealer look at the vehicle shortly. This problem is known and reported prolifically on discussion boards. Honda has released several service notices internally related to this issue for CRVs and Civics, but no recalls and not for HRVs.

Filed Jul 2, 2025 · Fuel system · 22,000 miles · CO

The contact owns a 2018 Honda HR-V. The contact received notification of the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the vehicle failed to immediately start. The cause of the failure was not yet been determined. The failure mileage was 22,000. Parts distribution disconnect.

Filed May 3, 2025 · Fuel system · NJ

I just want to get my recall done. It’s almost 2 years since the recall was announced and no one is able to do my car. I called Open Road Honda a bunch of times, last year they told me parts are not available. I have been following up since then every few months since honda sent a letter that parts are available. I just get sent to voicemail and no one calls back. I tried to call Honda to report but they just tell me to call local Honda dealerships. Something needs to be done with this before my car breaks.

Filed Apr 17, 2025 · Fuel system · AZ

The contact owns a 2018 Honda HR-V. The contact received notification of the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Mar 6, 2025 · Fuel system · 102,000 miles · CA

The contact owns a 2018 Honda HR-V. The contact stated that while driving at an undisclosed speed, a message was displayed to "Check fuel cap". After refueling the vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to the repair under the federal safety agency Campaign Number: 23V858000 (Fuel System, Gasoline). The VIN was included, and the vehicle had been repaired by the dealer. The manufacturer was not notified of the failure. The failure mileage was 102,000.

Filed Jan 13, 2025 · Fuel system · NY

The contact owns a 2018 Honda HR-V. The contact received notification of the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Dec 31, 2024 · Fuel system · FL

The contact owns a 2018 Honda HR-V. The contact received notification of the federal safety agency Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.