Honda Passport grinding brakes problems

Filed Aug 31, 2026 · Engine · IN

Car began making loud rattling noise which proceeded to a larger grinding noise in the engine. Car sudden wouldn’t accelerate and had to be shut off. It wouldn’t restart and once it did get jumped produced an intensely loud grinding rattling noise. Car had to be towed to Honda which upon diagnosis was found to have metal shards in the oil pan and diagnosis to replace entire engine. Honda is denying recall on this engine though it is very similar engine to what they currently have recalled for their V6 engines in Pilots, Odysseys ect

Filed Jul 22, 2026 · Driver assistance, Electrical · SC

The seat memory of the vehicle will reset itself every few days. This is while using the same key fob and driver profile. Android auto does not stay connected wired or wireless. This is after the vehicle has been factory reset, new cables used and phone reset. Buzzing/ grinding noise while breaking Blind spot sensors do not beep while the setting is activated to beep

Filed Jan 7, 2026 · Brakes · CA

While driving at highway speeds, I experienced multiple loud, intermittent double-knocking noises within a short period of time, followed by an additional grinding/rotational noise at low speeds. These noises were abnormal and raised immediate safety concerns, prompting me to bring the vehicle to a dealer that day. During inspection and test driving, the noise condition was confirmed. Further inspection revealed that a front brake caliper (flange) bolt was missing, and the brake caliper had shifted out of position. This bolt is a critical fastener that secures the brake caliper to the brake assembly and is available for inspection through service records. This condition posed a serious safety risk, as a shifted or unsecured brake caliper could result in reduced braking performance, brake failure, or wheel lock-up, potentially endangering vehicle occupants and other road users. The issue was confirmed by an authorized Honda service center, and the vehicle was inspected by manufacturer-authorized personnel. The vehicle was repaired at no charge by reinstalling the correct hardware and restoring the brake caliper to its proper position. One week later, I have come to find out this is a known issue, and Honda has issued a Technical Service Bulletin (TSB) for 2023–2024 Honda Passport vehicles addressing loose or missing front brake caliper/flange bolts. I never received a recall notice or voluntary letter from Honda notifying me this might be an issue or to have it inspected. No warning lights or messages appeared prior to the incident; the only symptoms were the knocking noises at highway speeds and grinding noise at low speed.

Filed Jul 7, 2025 · NC

The 2025 Honda Passport has developed an issue where the sunroof produces a popping or squeaking noise when it is being opened.

Filed May 19, 2023 · Brakes · 7,000 miles · CA

The contact owns a 2022 Honda Passport. The contact stated that an abnormal, squeaking sound would emit from the brake pedal upon depression without warning. The vehicle was taken to the dealer where they discovered that both the clevis pin and the cotter pin clip were missing from the master brake cylinder. The manufacturer was notified of the failure and a case was filed. The vehicle was repaired. The failure mileage was approximately 7,000.

Filed Oct 17, 2022 · Acceleration · DC

Incident occurred immediately after a full stop at an intersection. When I hit the gas pedal, the transmission sounded like shifting to Neutral gear, resulting in loud grinding, and with complete loss of power. Had do pull over the shoulder, place it on parking mode and then back to drive gear and continue. Now almost every time it's going to shift gears, you can hear and feel the a hard shifting gears.

Filed Mar 14, 2022 · Transmission · MI

Had the optional transmission cooler installed at the Honda dealership to help increase vehicle towing capacity. After install, when the vehicle shifts from 7-8 gear at light throttle application (approx. 45mph) the transmission makes a grinding noise. Took vehicle back to dealership and they inspected. They contacted Honda tech support and they stated it is a known design defect. They will not address it in anyway even though there are many possibilities to address this. Noise is energy and energy has to dissipate. I am concerned the grinding noise will start to wear something out and cause a failure later in the life of the transmission or the cooler.

Filed May 25, 2021 · Engine, Transmission · WA

My Honda passport had approx 10k miles and I was driving down a blind s curve less than 1 mile from my home on a clear dry day. The passport lost power, and when the gas pedal was depressed there was a loud grinding sound but no engagement - it seemed like the transmission was grinding and disengaged, or that power was not being transmitted by the engine. I coasted down to safe spot at bottom of hill, and stopped vehicle, put it in Park and turned it off. Then I started it again, transmission/power seemed to re-engage and I drove straight to dealership. They kept the car and told me they checked and found no codes. I asked about checking transmission fluid and they said they did but I don’t believe them. I called Honda corporate customer service and they told me they “couldn’t do anything until it happened to me again” and that I “needed to address problems and issues with my dealer.” (It was dealer who told me to call corporate.) Since this time, I have received notice of fuel pump recall and that has been repaired. I wonder if the loss of power I experienced was fuel pump, or if it was related to transmission issue (same as Odyssey) for the 9-speed transmission.

Filed Apr 14, 2021 · Transmission · 10,000 miles · WA

2019 honda passport touring w/ 10k miles o blind downhill s-curve approx one mile from my home.. My zf-9 speed transmission slipped out of gear while driving, resulting in loud grinding, lurching, and complete loss of power while driving. Incident occurred immediately after a full stop at the end of my lane before entering main roadway and downhill curves. I had to coast to the bottom with the grinding and gnashing gears and bucking, lurching vehicle dealership claims they could not replicate the problem, nor had they ever heard of this problem. They also stated that diagnostics did not identify any issues which is odd because I could give them a timeframe of exactly when incident and subsequent loss of power occurred. I also called honda corporate who tried to tell me that this was "a normal breaking in" scenario and that I should contact them when it happens again because they would do nothing for first reported incident. Clearly, american honda co does not care about consumer safety. I am now afraid to drive my vehicle

Filed Aug 29, 2014 · Suspension · 186,000 miles · WI

Driving started to sway slightly for no apparent reason, on the way home there was a sudden grinding and loss of control over the vehicle staying in one lane, I pulled it over to the side of the road and looked at it. The rear trailing arm rusted and separated from the frame. Hundreds of complaints over this issue as well as complaints that canada is reimbursed and in the us it is hard to get the proper compensation. Had the vehicle for two years, were assured there were no recalls when we bought it from a dealer, we were never informed of any recalls while owning it. Vehicle has recalls on rust and the frame that honda said expired, but they had us tow our vehicle to honda center then offered 100 dollars to us after the tow fee was deducted or we could pay 1800 to fix it. We had it in a safe place that would have given us much more money for totaling it out because he wouldn't fix it due to the repair still being unsafe. This is this particular service centers way of getting unsafe honda's off the road.