2002 Hyundai Accent fuel system problems

Filed Aug 11, 2024 · Fuel system · CA

Purchased car 2002 in Arizona. About 2009 when the check engine light came on and when filling the car with gas the pump would stop after less than .25 gallons pumped. It takes greater than 20 minutes to fill the tank and many times the auto shut off fails and I end up being sprayed gasoline. This is a personal safety issue as well as an enviromental hazard. There are many similar complaints about this issue, but it is repeatedly ignored. What will get this addressed, some one being seriously injured after being doused with gasoline?

Filed Mar 4, 2019 · Fuel system · 67,000 miles · OH

I got this car in 2015 and it keep failing the state of ohio vechicle inspection e-check test and the same code keeps coming up..... P1401..... Why... It fail on jan 16,2019 and in 2017 jan.19.17 I spent $398.52 and had gas tank filler neck and canister ventvalve replace.....and again same code 2019 "p1401..help thks. (xxxx) parts of this document have been redacted to protect personally identifiable information pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)

Filed May 24, 2016 · Fuel system · NJ

When putting gas in the car, the fuel pump clicks off every 10 cents or so as if the tank is full but it is not. Sometimes the gas oven runs back out of the tank as if it is overfilled and running over, but it is not. I live in nj, which is one of the two states that have full service gas stations. And gas station attendants constantly tell me that they encounter this problem specifically with hyundai's all the time! They have told me that they have also seen this with brand new hyundai models as well, so it's not a problem that has improved over the years since my dated 2002 model. Even the service tech at my local hyundai dealership was all too familiar with this defect widely known with hyundai's when I spoke to him. He also quoted me a price around $600, which he said from his experience as a technician doesn't guarantee the problem to be fixed. There are cases of the problem coming back after the repair is done! I contacted hyundai with my concerns and to specifically ask why this widely known defect was not recalled and I did not get a real answer to my question. I have been dealing with this problem for some time. And looking at some of the other complaints filed, plus the people I've talked to (including hyundai employees), they have known about this common problem, but refuse to acknowledge it as a defect and fix the issue. Very frustrating.

Filed Aug 10, 2015 · Fuel system · 92,000 miles · FL

Tl* the contact owns a 2002 hyundai accent. While refueling the vehicle, fuel would leak from the filler neck onto the ground. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 92,000.

Filed May 11, 2015 · Fuel system · 16,000 miles · PA

Many people have been complaining about this vehicle. You can't put gas into it without the pump stopping approximately every .25 gallons. It's very annoying and it is difficult to pass inspection. I don't understand why hyundai should not be required to fix this problem. It comes up as a 1401 for emissions testing

Filed Oct 24, 2013 · Fuel system · 50,000 miles · WA

My 2002 hyundai accent "clicks off" repeatedly when attempting to refuel the vehicle. Gasoline pools in the chamber between the fuel door and the gas tank causing a serious hazard. Fuel smells are frequently observed within the car after fueling and for a period of days afterward. The "check engine" remains illuminated indicating a fuel line system. I have had the system checked by a full service automotive facility and they have replaced several parts with no success in remedying the problem. Have suggested possibly replacing the entire full line, gas tank, etc but have indicated this is likely a manufacturer defect that should be addressed as such. At the current time it is impossible to put more than a few ounces of gasoline into the car at any one time and failure to closely monitor the chamber while attempting to refuel can lead to gasoline overflow and spills. I have significant concerns as to the safety of fueling this car on a weekly basis as well as the risk of fire hazard should any type of rear-end collision occur with this vehicle. From my research this appears to be a fairly common occurrence with this model/year of hyundai, including at low mileage points. Concerned that hyundai has not addressed what appears to be a serious issue for safety.

Filed Jun 24, 2013 · Fuel system · 108,000 miles · CA

The gas tank will not accept fuel at a reasonable flow from a pump. It trips the shut off early. Sometimes fuel splashes out when this happens. Many hyundai cars have this problem. From research, I found the following problems: 1) charcoal bits in the vent lines from the carbon canister- one owner cut open the canister and found a foam filter like in a window A/C that was damaged by gas allowing carbon to go into the vent lines clogging them and not allowing the tank to vent. Incompatable material used. 2) faulty check valve at the inlet of the gas tank does not open fully when refueling causing gas to back up the filler neck. 3) defective "sampling pump". This is in the vent system between the fuel filler pipe and the rear bumper. Pump does not operate when it should. 4) small filler tube. Gas pump nozzles in the uk had to be changed to a smaller size so that there could be some venting. The vent lines in my car seem clear. I am changing the check valve, and I will see if this improves the situation. It also seems that the hyundai dealers do not understand the problem and what causes it.

Filed Apr 9, 2013 · Fuel system · 56,000 miles · AL

My hyundai accent 02 refuses to fuel up continually shutting off at the pump 1/4 gal at best, twenty minutes to fill, took it to the dealership they are well aware of the problem,,, the fumes can not vent properly and forces air back up the filler neck of the gas tank and sprays gas all over. This is not only dangerous to myself but also dangerous to every person in the area. I feel this is a danger to everyone and needs to b addressed.

Filed Aug 23, 2012 · Fuel system · 69,012 miles · IL

Tl* the contact owns 2002 hyundai accent. The contact stated that while refueling the fuel gauge indicated that the fuel tank was full. The vehicle was taken to the dealer who diagnose that the fuel pump and the fuel tank needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance although the vehicle was under warranty. The failure mileage was 69,012 and the current mileage was 69,100.updated 11/01/12 *bf the consumer stated that the pump would stop fueling after 0.5 gallons of gas. The canister was replaced. The failure continued. The check engine light illuminated. The dealer then suggested to change the dmtc pump. If the rubber pipe connected to the canister is removed the vehicle can then be fueled as normal. Updated 11/02/2012

Filed Sep 16, 2011 · Fuel system, Transmission · IL

For the past 2 years I have had to replace speed sensors and oxygen sensors, several times. I was taking to my mechanic because parts were out of warranty, but my mechanic stated that it is a transmission problem because every time I had chips replaced my trans fluid was dirty and had to flush again and again. Took car to dealer, same conclusion. Hyundai refused to replace. Filed a complaint with hyundai. Hyundai stated they were not contacted by dealer, this statement was later retracted by them. They are still refusing to replace my transmission. Did all scheduled maintenance. My car has about 77000 miles and is almost 10 years. My fuel system began acting up early 2011. Can only fill tank 1/4 gallon every 1min. This takes me a very long time to fil1 tank. Dealer gave me a $1600 repair estimate. I am reading literally 1000's of complaints on both issues and hyundai refuses to speak on them. These are dangerous issues: sensor chips causes cars to stall, particularly at high speeds, imagine being behind someone going 60mph and then suddenly their car stalls....crash waiting to happen and the fueling issue can increase the likelihood of car fires. If the gas is leaking or spilling out due to poor workmanship and/or design and an accident occurs ignition of gas spilling outside increases, not to mention environmental hazards. These cars could not pass emissions testing. The main issue is that hyundai is missing in action and refuses to honor their warranties. Shame shame hyundai. Saying you offer a 10 year warranty and actually honoring it are 2 different things.