I was traveling on the freeway when I got a warning saying “check electrical.”i started to pull over on the freeway and my car went into “turtle mode “and I made it off the offramp but almost got rear ended. I was half a mile from home so I limp home in a tow truck towed off. It was determined it is the ICCU.
2022 Hyundai Ioniq 5 transmission complaints
Page 2 of 4: complaints 11 to 40 of 85, newest first, as owners wrote them.
Q: What component or system failed or malfunctioned, and is it available for inspection upon request? A: ICCU failed - Not available for inspection (at least at this time, but willing to try and make it work). Q: How was your safety or the safety of others put at risk? A: The ICCU (Integrated Charging Control Unit) is a safety-critical component subject to federal recalls 24V‑204 and 24V‑868. (My vehicle had all recalls performed prior to this failure.) The failure occurred while driving which was indicated by a “popping” sound. It is contextually important to note that the ICCU is responsible for charging the 12v battery, had the 12v battery failed during the duration of my drive I would have experienced a sudden loss of motive power. A sudden loss of motive power is an unacceptable risk to public safety. Q: Has the problem been reproduced or confirmed by a dealer or independent service center? A: Yes, the problem has been reproduced and confirmed to be an ICCU failure by an official Hyundai service center. Q: Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? A: No. Q: Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? A: Symptoms first appeared February 14, 2026. The first symptom of failure was the signature “pop” sound that the ICCU failure is known for. Only after my drive and upon attempting L1/L2 charging did my dash warning indicate “Check Electric Vehicle System.” I also checked for codes with my OBDII scanner, and it showed no codes.
While driving on the highway during a rainstorm, the high voltage fuse on my car's Internal Charge Control Unit blew and the ICCU itself failed. This rendered the vehicle inoperable as soon as I managed to get it to the shoulder. It took two weeks to repair, and I had to argue with Hyundai's corporate lines for almost six months before the offered a partial reimbursement for their device failure.
While making the short drive to work on surface streets I was given a warning in an amber circle to check the electrical system. Moments later I was presented with a warning in a red circle reading "Stop vehicle and check power supply"; accompanying this warning was a drastic loss in power. Had I been on the highway I would not have been able to maintain speed with the likelihood of being stranded in an unsafe location. The dealership reported that the ICCU (internal charge control unit) had failed. This is the second such failure on this car. It has been over 4 weeks since the dealership received the car, and Hyundai has not been able to supply repair parts.
P1A9096 ICCU failure ICCU Failed while travelling on interstate. Limp mode limited vehicle to 40MPH top speed. 12V battery was not able to recharge. Became a slow-moving hazard while driving back home a few miles limited to 40MPH during winter conditions. Problem was confirmed by dealership service center No other warnings prior to sudden "pop" and dashboard warning to check EV electrical system.
The Integrated Charging Control Unit (ICCU) has intermittent failures. During the last failure, my wife was on a busy freeway (Interstate 5 near Hwy 120 northbound) in heavy but fast moving traffic. She was driving in the #2 lane (of 4 lanes) when she experienced sudden loss of propulsion. The vehicle slowed to 5 MPH in traffic that was moving 70 to 80 MPH. She had to traverse through the #3 and #4 lanes to the narrow emergency shoulder. Cars were honking and flipping her off. In the emergency lane, the vehicle completely died after 30 to 60 seconds. She was at risk of being rear ended during the dangerous 5 MPH lane changes and in the time parked in the emergency lane. She could not start the car for 15 minutes, after which the system came back to life. She was then able to start it and continue home. The first time the ICCU failed was in a parking lot. This is a known defect with Hyundai which they have attempted to rectify with Recall Campaign 272. However, they refuse to replace the ICCU. After the first event, they replaced the battery after 22 months/32429 miles. Now they want to replace the battery again after another 20 months/34k miles. What they don't get, is that the batteries have not prematurely failed. Instead the ICCU has intermittently and temporarily drawn the batteries down causing the vehicle to lose propulsion and die. They refuse to replace the ICCU because an error code they were looking for was not in the memory. They have performed three software updates on three separate dealer visits, but the issue has not been resolved. During the last visit they kept my vehicle for six weeks while I appealed through Hyundai Consumer Affairs and the Service manager appealed through his Dealer rep. But the factory engineers held firm and would not approve the ICCU warranty replacement, and instead wanted me to pay for 12V battery replacement. We don't know if there were any warning lights since my wife was busy navigating the danger.
The ICCU component failed. I lost propulsion while driving and almost got rear ended. The dealership service department confirmed the ICCU issue. The dealership service department has inspected the vehicle. I had a dead 12v a month prior that I had asked the service department to look at and test the ICCU. They did not test the ICCU. The car warned me 30 seconds maybe less before i lost propulsion.
While driving, a warning message displayed on the dashboard stating that there was a fault in the electrical system and that I should pull over and stop the car. As I tried to find a safe place to pull over the car lost power and I pulled onto the shoulder. The shoulder was only as wide as the car. I was stopped on the side of a two lane road with a 55 mph speed limit. In order to exit the car I had to step into the travel lane. The electrical fault resulted in no power available to the warning flasher lights or headlights. This occurred at night with no street lighting to show oncoming drivers that there was a stopped vehicle immediately next to the traffic lane. This put me and other drivers at risk. The vehicle was towed to a dealer capable of working on this type of failure. The dealer determined that the failed component is known as the ICCU. This is a critical part and had been known to fail in this model. My vehicle had already received every software update in an attempt by the manufacturer to avoid the ICCU failure. The dealer replaced the failed ICCU with a new working ICCU. It is my understanding that the replacement ICCU is identical to the failed ICCU and a risk remains that the new one could fail as well with a loss of power while driving at speed.
The ICCU has failed. This component was replaced approximately one year ago as part of a recall, but it has failed again. The vehicle is currently parked and cannot be driven until Hyundai provides a replacement part, which may take up to three months. The failure presents a safety concern, as the vehicle can shut off while driving and leave the driver stranded. The Hyundai dealership has confirmed that the replacement part provided by Hyundai—the ICCU—is the component that failed. There were no prior warning signs of failure, other than the vehicle refusing to charge on a Level 2 charger.
The component that malfunctioned is the Integrated Charge Control Unit (ICCU) and related high-voltage charging system in my 2022 Hyundai Ioniq 5. The ICCU controls AC (Level 2) charging, DC fast charging functions, and power delivery. The ICCU assembly and charging components were serviced and replaced by an authorized Hyundai dealer and are available for inspection through service records. This defect created a safety risk because the vehicle experienced complete charging failure and reduced-power operation. Loss of charging capability can leave drivers stranded, and reduced-power “turtle mode” conditions can limit acceleration and vehicle performance, creating hazards in traffic. The charge port has also not locked during charging, creating a potential risk of electrical arcing during DC fast charging. The failure was reproduced and confirmed by an authorized Hyundai dealer. In approximately January 2025 the vehicle would not charge and remained at the dealership for an extended period (about January through June 2025). After diagnosis and consultation with Hyundai technical support, the dealer replaced the ICCU assembly and high-voltage fuse. The vehicle and charging system have been inspected multiple times by Hyundai service centers. Hyundai issued recall campaigns in 2023 and 2024 involving ICCU software updates and fuse-related work, but these did not prevent the later failure requiring full ICCU replacement. Prior symptoms included abnormal charging behavior and eventual total loss of AC charging capability during the 2025 failure, making home charging impossible. After the ICCU replacement, the vehicle exhibited unusually loud cooling fan operation during Level 2 charging, documented by the dealer. There were also charging-port safety concerns. After one service visit, an important DC pin cover/cap was not properly installed until corrected on a return visit, leaving charging components exposed.
After a loud bang (fuse blown) the car was unable to move just before I was about to turn into an intersection. The ICCU failed for the second time, all warranty repair completed prior to the incident, first failure occurred in 2024. Both failures occurred close to a when the lead acid battery failed and needed replacement. When the car was stopped and started again, I was able to drive the car slowly to the dealership located less then 1/4 mile away. The car behaved as if there was no power steering but the car still jerked the wheel around to try to put me back into the driving lane presumably because I was driving in the emergency lane. Failed component was ICCU Module 36400-1XAA0. Vehicle was unsafe because I was unable to move while about to turn into an intersection. After stopping and starting the car, the was drive-able bit mildly erratic when attempting to move the car to a safe location (out of the left turning lane). Problem was identified, confirmed, and repaired by dealer under warranty for second time. Component and vehicle inspected by dealer. Failed part sent back to manufacturer. This incident occurred without any prior warning or indication by the vehicle. There were no active recalls on the vehicle at the time of the incident.
To my understand, the ICCU keeps shutting down and is causing issues with my car? This is apparently a huge issue with a bunch of Hyundai's from 2022.
My 2022 Hyundai Ioniq 5 has experienced two ICCU (Integrated Charging Control Unit) failures, both completely immobilizing the vehicle. •First failure: November 2024 •Second failure: December 31, 2025 (confirmed by dealer 1/13/26) •Downtime: Over 45 days total •All recall work and maintenance were performed at the same Hyundai dealer, under active warranty, but the recall did not prevent the second failure. Safety Risk: These ICCU failures cause sudden loss of propulsion, leaving the vehicle stranded and creating a serious safety hazard. The second failure after recall indicates the repair is inadequate. Luckily mine failed at home before departing for an errand, but I am gravely concerned about others not as fortunate or for myself should the issue recur while I am traveling on a public road. Examples of this are reported online in a variety of forums. Widespread Issue: Thousands of owners report similar ICCU failures, often after recall repairs, on forums and social media. There is also ongoing Canadian litigation addressing the same defect. Requested Action: •Investigate repeated ICCU failures in Hyundai/Kia EVs •Evaluate the adequacy of recall repairs •Require Hyundai to implement a permanent fix •Take appropriate safety action to protect vehicle owners
While charging at a level 2 charger (6 kW) the car stop charging at 61% for no apparent reason. I was unable to restart charging. Within 2-3 minutes of starting the car and driving, received a warning to “check the vehicle electrical system” and then within another minute or two, another warning to “stop vehicle and check power supply.” I was traveling under 20 mph the entire time.
3rd ICCU failure. Was Driving and went into limp turtle mode. Was in a dangerous area for it to happen and took a while to get to a safe place.
On November 29 2025 my 2022 Hyundai Ioniq 5 with 49000 miles was warming up in the driveway. I heard a pop sound from the back seat like a soda can being opened (or a fuse blowing). Immediately afterwards warning lights appeared on the dash saying "Check Electrical System." The vehicle lost power to accelerate and could not be driven effectively. After a few moments, another error saying "Power is Limited" appeared. This could have happened on the roadway which would have been hazardous to myself and other drivers. The car is scheduled to be diagnosed next week by Simmons Rockwell Hyundai in Elmira, NY. These symptoms are similar to the hundreds of other reports of ICCU failures in this car and similar models. On Sept 10, 2025 the car was previously issued software updates to the ICCU software , which were required under the federal safety agency Recall Number 24V868000. If this problem is proven to be an ICCU failure, the experience with this car is an example of the 2025 software update failing to prevent the ICCU Failure. I request swift action from the federal safety agency to compel Hyundai to implement a permanent fix for my vehicle and all other afflicted models in order to make Americas roadways safe again. Until then, everyone should be extra careful when driving behind a Hyundai Ioniq, 5 because it is at risk of dying and coming to a complete stop at any moment. Hyundai is a large corporation and has the resources and technology to fix this, but they have not done so, despite there being more than 300 complaints to the federal safety agency about these cars at the time of this writing.
Check Vehicle Electric System warming shows up on dashboard, then vehicles enters turtle mode and then cuts power shortly with violent jerking of the vehicle. Shortly after, all system shuts down, 12V is said to be weak and car cannot move.
Electric Drive System Inoperable, sustained an immediate failure upon engaging in Drive mode. Dashboard lit up with warning lights and messages. Luckily was just pulling out onto road when vehicle completely died. Tow service unable to start vehicle with jumper module. After being towed to dealer, was diagnosed with failed ICCU. The original ICCU was replaced previously in January 2025. Luckily was not underway on the road when it happened. There was no warning, no indication that there was any problem.
The ICCU (Integrated Charge Control Unit) failed. The car was in a Hyundai dealer repair shop on November 18, 2025, for an unrelated regular maintenance procedure when (i) the technician noticed a logged ICCU error code generated sometime prior to the shop visit and (ii) after the technician cleared that prior error a second new ICCU error code was generated. The shop replaced the defective ICCU. This car had been serviced on prior occasions to install updated ICCU software, most recently as part of the federal safety agency's recall 24V868000 of November 18, 2024 (also known as Hyundai Safety Recall 272), intended to eliminate such ICCU failures. Installation of that software as the remedy for recall 24V868000 clearly did not prevent the very ICCU failure it was intended to guard against. Please note also that it is common knowledge (as disseminated on various Ioniq 5 forums and Reddit groups) that large numbers of later Ioniq 5 vehicles with newer VINs not included in recall 24V868000, i.e., from model year 2025 onward, have also suffered from these failures despite being initially placed into service with the updated ICCU software, as well as many other pre-2025 remedied vehicles. The Hyundai ICCU software currently in operation on both remedied cars from recall 24V868000 as well as newer cars not subject to that recall is clearly entirely ineffective as a solution to this very serious safety issue. I strongly urge the federal safety agency to (i) declare the existing ICCU software to be an ineffective remedy for recall 24V868000, (ii) include all Hyundai Ioniq 5 cars for all model years, whether running current ICCU software or not, to be part of the group of unremedied and unsafe vehicles, and (iii) extend recall 24V868000 until such time as Hyundai can actually demonstrate that an effective remedy exists and is being made available to all Ioniq 5 vehicles.
Carr went into limp mode and wouldn’t drive more than approximately 10 mph in traffic. Once I was able to pull over and reset the ignition button, the car seems to be operating normally.
Even after the recall service performed, the ICCU still failed 10 months later. DTC P1E011C is listed and will not charge. This is the same issue for the KIA EV9 and a TSB needs to be issued the same as the TSB 339 KIA did for the EV9.
I am submitting an update to my existing complaint regarding the ICCU safety recall on my 2022 Hyundai Ioniq 5. Since my original submission, my vehicle has been at authorized Hyundai dealerships since July 2025 and remained undiagnosed and unrepaired for over three months. During this time, I received inconsistent and misleading information from both Hyundai corporate and the dealerships regarding the status of the recall repair, as documented via emails, texts, and recorded calls. On 10/31/2025, the dealership informed me that the issue may involve a floor harness/wiring problem and it is out of warranty; however, this appears related to the ICCU safety recall, and Hyundai has not provided a firm timeline for repair. Hyundai’s delay has caused significant inconvenience, as I have been without my vehicle while continuing to make car payments and insurance payments, and arranging temporary transportation. Additionally, Hyundai and the dealerships provided multiple assurances that the vehicle was being diagnosed and repaired, which were later contradicted, reflecting misleading and deceptive practices. I request that the federal safety agency consider this update as part of my ongoing complaint and investigate Hyundai’s failure to provide timely and adequate recall service, as well as the misinformation surrounding this safety recall.
Despite being up-to-date on recalls for this vehicle intended to address failures with the integrated charging control unit (ICCU), I still experienced an ICCU failure. I was driving along a surface road at approximately 40 mph for about 9 minutes when I heard a pop that sounded like cargo shifting in the rear cargo area. The vehicle then flashed a "Check EV System" warning but otherwise continued to operate normally. About 2 minutes later, there was a warning to stop vehicle and check power supply. After I pulled into a parking lot, I restarted the vehicle, but the errors persisted. I had the vehicle towed to the dealer, where it was diagnosed as an ICCU failure. The vehicle was last charged ~15 hours before the failure on a level 2 charger at a peak rate of 6 kw. The vehicle was driven for about an hour after charging, sat overnight, before being driven when the failure occurred. The vehicle is primarily charged using level 1 and 2 charging, typically not exceeding 6.3 kw. Only a handful of times has level 2 charging rates exceeded 6.3 kw. The vehicle previously had the ICCU fail and replaced in 2023. The car is still at the dealership with no repair timeline.
The Integrated Charging Control Unit (ICCU) in my 2022 Hyundai Ioniq has not been diagnosed or repaired despite being at the dealership for 3 months for a safety recall. The ICCU controls the vehicle’s electrical and charging systems, and a malfunction could prevent the vehicle from charging or operating properly, creating a risk of loss of propulsion while driving. Two different Hyundai dealers have had the vehicle since July 11, 2025, but no diagnosis or repair has been completed. I have escalated the issue to Hyundai Corporate, but there has been no resolution or communication of a timeline. The vehicle is available for inspection upon request. No warning lamps or messages were reported prior to the dealer receiving the vehicle, as the car was delivered specifically for the recall repair. Due to this unresolved recall, I have been without my vehicle for 3 months, which has caused significant hardship and forced me to rent a vehicle temporarily. I was given a loaner vehicle eventually but this vehicle is not comparable to my ioniq5. Both dealer's gave excuses for the lack of diagnosing and repairs, ranging from "technician is on jurty duty" or "the climate is too hot outside to look at it."
I was driving along and got a warning to pull over due to low power. This is the third time this has occurred and is a well--documented failure point for this vehicle. I go in for "repair", things are checked and sometimes software is updated and then within months the problem returns. Very unsafe being stranded on a high speed, two land rural road at night. It has been flat bedded to the dealer and tomorrow I will here theri song and dance.
Vehicle Information: Year/Make/Model: 2022 Hyundai Ioniq 5 SE AWD VIN: [XXX] Mileage at issue onset: ~18,000–22,000 miles Purchase date: April 2022 Ownership type: Purchased new, paid in full Component Affected: Electrical System → Integrated Charging Control Unit (ICCU) / Charging System Problem Description: I am reporting a persistent and unresolved charging system failure involving the ICCU (Integrated Charging Control Unit) in my 2022 Hyundai Ioniq 5. This defect has rendered the vehicle unreliable and currently inoperable, leaving me without safe transportation for myself and my infant child. Over the past year, I’ve brought the vehicle to the dealership more than 10 times, including 6 visits in just the last 3 months, due to charging issues that were supposed to be addressed via multiple recall campaigns (e.g., Campaigns 228, 997, 9A1, 9B5, 272, TCP). Despite these attempted software and firmware updates, the issue persists and culminated in a total failure to charge in March 2025. The dealership confirmed ICCU failure again, but advised that the part is on indefinite backorder, with no timeline for repair or safe operation. This defect is dangerous, particularly as it can result in loss of power and stranding, with potential risks to driver and passenger safety. Hyundai is aware of this widespread issue among Ioniq 5 owners but has not issued a permanent fix or offered viable alternatives to affected consumers. Hyundai denied my Lemon Law claim despite substantial repair documentation and admitted ICCU defects. I have filed with the BBB Auto Line and IL Attorney General. I’m now preparing for legal action. This is not just a consumer issue — it’s a national electric vehicle safety issue involving Hyundai’s inability to resolve a known, system-wide defect in a core safety component. Attachments: Available upon request: repair invoices, dealer assessments, Hyundai’s denial letter, lemon law filings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The vehicle has had 2 12V battery replacements and 2 ICCU failures in about 20 months and just 12,000 miles of ownership with over 100 combined days out of service for repairs.
ICCU failure preventing car from AC charging. In shop 25 days now but part not available and not given estimated repair time. Car was bought new and has 24,600 miles on it.
ICCU failure. Vehicle abruptly reduced speed while on the road. Hyundai has inspected the vehicle and confirmed the failure. "Stop vehicle and check power supply" warning. "Check electric vehicle system" warning. "12v batter voltage low. Stop safely" warning. All first appeared within a few minutes of the vehicle losing power. Vehicle has been at dealership for repair/replacement of ICCU since February 7th.
My car suffered a failure of the Integrated Charge Control Unit ("ICCU") which makes the car underivable. This is the third time that I have had an issue with the ICCU. The first two times, it failed to charge the 12V battery, leading to a loss of all 12V systems and being unable to drive the car. This third time, the car now refuses to charge on AC power. Hyundai has tried to "repair" this issue with software updates, but it doesn't fix it. Now I am waiting for a remanufactured ICCU to replace my broken one.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Hyundai Ioniq 5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history