2023 Hyundai Ioniq 5 transmission complaints

Filed Jun 19, 2023 · Engine, Transmission · GA

EV goes into power limited mode when on interstate when going ~50 miles while driving 70mph or more. Happened each of my 3 times on interstate of about that distance. First time was Sat 4/29 while in eco mode with 70% battery and 82°F outside, 1 hr drive 50+ miles. Second time was in normal mode Friday 5/12, 55% battery 72°F outside 1 hr drive 50+ miles. Third time was in normal mode and it happened after 42 miles. I scheduled a service after the first incident but they were only able to take it on 5/31. When this happens you lose ability to accelerate and have to coast to the side of road and let it sit for 10+ minutes to clear and then can resume, I would take surface roads after it occurred. Impacts safety for self and others, as it drastically slows without brake lights causing a high chance of being rear ended. The last incident was close to it. As it was getting worse I stopped driving on interstate with it. Car has been at the dealership's service department since 5/31. They were able to easily reproduce once they finally got to it. They diagnosed a bit and then consulted design engineers. Diagnosed on and off for a couple weeks and have finally decided to replace the drive motor. Part received Friday 6/16, to be installed tomorrow 6/20. We'll see if that addresses.

Filed May 25, 2023 · Brakes, Transmission · TX

When using the most aggressive braking energy recovery mode in the Hyundai Ioniq 5 (i-Pedal), the brake lights do not illuminate despite the aggressive nature of the braking provided by this mode. This mode brings the car to a full and complete stop and is very similar to commanded braking via the brake pedal. When using the L1-L3 braking energy recovery modes, the deceleration experienced by the car is more or less mild enough that it would be similar to a downshift in a manual transmission car. But the brake lights only illuminate if your foot is fully off the accelerator pedal. I am not aware of the regulations or SAE guidance to know if this is consistent with best practice, but it could be better with the brake light coming on once a certain deceleration (x m/s2) is reached. It is my opinion that a software change in the car's ECU could effect a fix for this. A mandatory recall would force the issue with Hyundai to actually do something about it. Note that Kia and Genesis share the same basic EV platform and may share the same logic fault in brake light activation. Here is a Youtube video that discusses the issue in a fair level of detail - https://www.youtube.com/watch?v=U0YW7x9U5TQ