2019 Hyundai Kona transmission problems

Filed Oct 20, 2026 · Engine, Transmission · FL

My 2019 Hyundai Kona (VIN: [XXX]) experiences violent shaking and complete engine stalling in active traffic when braking, creating an immediate safety hazard on public roads. This directly mirrors the failure mechanics of Safety Recall 203 ([XXX]). Upon inspection, physical evidence of massive silver aluminum metal flakes was discovered clogging the VVT solenoid mesh screens, originating from internal cylinder/piston ring degradation. However, the dealership Universal Hyundai in [XXX] (RO# XXX) issued a fraudulent diagnostic report stating 'no metal found' to evade recall liability. Hyundai Motor America subsequently closed corporate case XXXwithout an internal engine or borescope inspection. I have retrieved the vehicle under financial protest and possess full photographic evidence of the aluminum contamination. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 7, 2026 · Engine, Fuel system · TX

My 2019 Hyundai Kona SE (2.0L Nu MPI/Atkinson engine) was previously subject to the federal safety agency Recall 21V301000 (Hyundai Recall 203) for defective piston oil rings that can chip and cause accelerated oil consumption, engine knocking, and stalling. That recall's remedy was performed under a prior owner in December 2021. In November 2025, a Hyundai dealership installed a Cylinder Noise Diagnostic System (CNDS) software update (Service Campaign 974) specifically meant to detect this defect's vibration signature before it causes engine damage. Approximately 7,000-8,000 miles and about nine months after that software update, the vehicle stalled unexpectedly while being driven on two separate occasions, with no check-engine light or other warning beforehand. A third stall left the vehicle unable to restart. It was towed to a service station, which found no engine oil and no external leak. A Hyundai dealership subsequently diagnosed cracked valves that allowed approximately 5 quarts of oil to burn through the engine, and determined the engine requires complete replacement. This is the same failure mode (oil consumption/engine damage leading to stalling) that the original recall and the 2025 software update were both meant to prevent, and the software gave no advance warning before the stalling occurred. The vehicle and dealership diagnosis are available for inspection upon request.

Filed May 20, 2026 · Engine, Transmission · VT

96,247 mi Engine knock and complete oil loss within 3,000 miles of last oil change Symptoms consistent with the federal safety agency Recall 21V301 (Hyundai Recall 203) and Warranty Extension TXXM coverage

Filed Apr 24, 2026 · Engine, Transmission · CA

The vehicle burns oil faster and the vehicle began to stall at highway speeds. Upon further research, a campaign recall for the same vehicle is open but only for specific VIN. Although this vehicle was not part of the recall campaign 21V301000 the vehicle shows issues aligned with the recall.

Filed Sep 9, 2025 · Transmission · NY

Engine light blinking. Code P1327

Filed Nov 2, 2024 · Electrical, Transmission · PA

As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.

Filed Jun 24, 2024 · Driver assistance, Engine · HI

My check engine lights come on and then the front collision lights come on which reduces speed while on highway and then the engine turns off making it very unsafe driving on the highway. I have tried to schedule appts with dealerships to have it checked telling them how unsafe it is and I need my car to get to work. But they never have any openings except months down the road. I am afraid it will cause a terrible accident. I have taken my vehicle to repair shops ... some said it was the spark plugs so I got them changed and other maintenance costing me over $800 and the problem still exists ... still trying to get an appt with the dealership which will cost me another $220 just to get it diagnosed. There need to be a recall if it's happening to alot of people. I am very afraid if this issue isn't fixed and it's gonna cost me to repair it in the thousands that I don't have. Someone is going to get into a bad accident because the engine will turn off while driving.

Filed Apr 26, 2024 · Engine, Transmission · CT

While driving the vehicle the warning light went on and suddenly there was a loss of power on the highway. The vehicle was brought to our local mechanic who ran a diagnostic test and the NTSB recommendation for engine replacement DTC P1327 came up. He advised the vehicle go to the dealer, which we did. It has been at the dealer for 5 weeks. When the recall 22-EM-008H was done, they did not do the recommended engine test in 2023. The recall also had them do something in the computer to give owners a warning if there was any knocking sensed in the engine. That warning system failed to work because the light came on when the engine seized. The dealer said they see a couple of these cars a week with the same issue and Hyundai refuses to take ownership of the issue that prompted the recall. They denied us saying it was out of warranty when the recall was not issued until the car was about 4 years old. Most people would be out of warranty, especially because the 100K warranty doesn't apply to secondary owners which I was never aware of until now. I bought the car in 2020 about a year after production. Everyone you speak to at Hyundai doesn't understand English and at the bottom of the recall it states to submit a prior approval if the affected part is out of warranty for a goodwill consideration but they deny all of them due to out of warranty which doesn't make any sense as to why there would be a prior approval process for out of warranty claims for good will if they are not going to ever do a goodwill repair. They also do not give you to a person that can listen to what you are trying to tell them that can understand what goodwill means and explain why they did not do the engine repair or replacement when they discovered they had engines out there with the potential to fail. This is not right what they are doing. Many other models have the same issue and the warranty was extended to 15/150k but this one has not been added to that and it should be.

Filed Dec 22, 2023 · Acceleration, Transmission · OH

For about a month, the car is pausing for a second or two during acceleration. The car was brought for service to Great Lakes Hyundai of Columbus (Ohio) on 12/19/2023. This is diagnosis and remediation that was offered: Needs immediate attention 1 of 5 services Related requested service [Primary]: 10HYZ06 - C/S CHECK ENGINE LIGHT CHECK AND ADVISE: C/S CHECK ENGINE LIGHT CHECK AND ADVISE CHECK ENGINE LIGHT - DIAGNOSIS - CUSTOMER STATES THE CAR IS DRIVING ROUGH WHEN CHANGING GEARS, DOES NOT WANT TO ACCELERATE, HAS TO PUT THE PEDDLE ON THE FLOOR. [Other]: Transmission control unit update Speak with your service advisor for more information on this recommended service. There were no warnings. I just noticed to the problem, and it was getting worse.

Filed Apr 25, 2023 · Engine, Transmission · OH

Camshaft pin sheared with 66,000 miles leading to severe engine damage and expense. No known cause but consistent with many online reports of engine issues with this make and model year. Vehicle was well-maintained prior to the incident. No warning lights present until after engine damage occurred.