While driving on the interstate highway the engine stopped. The circumstances surrounding the failure matched those for Kona VINs that were recalled.
2021 Hyundai Kona engine complaints
Page 3 of 4: complaints 41 to 70 of 81, newest first, as owners wrote them.
I had a 2021 Hyundai Kona limited. On Friday 09/13/2024 my engine caught fire and my car was a total loss. Minutes before the fire I noticed some smoke, all of my dash lights came on and the car shut down. Seconds after stopping the vehicle and getting out the whole engine went up in flames. There are recalls active for my make model and year, nothing for my specific vin number but will be reaching out to Hyundai corporate to see if they want to come look at the car, in case it needs to be added to the recall list.
Unknown the vehicle stopped running and won’t start back up
I bought this car for my daughter we bought used low miles in May 2023. She got her first oil change in August 2023, in November on her way back to college her car seized up and stop working on the highway. Dealership said missing oil plug. Had to replace with new engine. Insurance company drops us, and new insurance is double. Second oil change July 2024. I noticed oil spots on my new driveway, she takes to dealer, again oil plug gone and hole in oil pan. This is crazy!! If I wouldn't have seen the oil spots on driveway she would have blown up anothe engine. She parks on gravel lot, can't see oil drips. Internet full of these stories. I can't afford this car. Thousands of dollars in increased insurance, driveway repair, car repair, not to mentoin the anxiety. This car has doubled insurance rates, ruined two paver driveways, and over $1000 each time in repairs. This needs to be fixed. This is dangerous. I spoke to dealership and there only advice was to bring to dealership for oil changes. This company needs to recall this defect with the oil plug/pan
Told previous recall on engine was not needed on this vehicle while vehicle has same stalling issue that caused previous recall on engine. On july 5 2024 engine locked up nearly creating a wreck. Previous recall clearly is wider spread than hyundai is admitting. Now my car that is 8000 miles out of warranty needs an engine they claimed was not affected by previous recall but has same issue and originally fell under previous recall.
The contact owns a 2021 Hyundai Kona. The contact stated that on several occasions while driving at various speeds, he observed white smoke emanating from the rear of the vehicle. Additionally, on several occasions, while driving at various speeds, the vehicle lost power and did not accelerate as intended. The vehicle was taken to a dealer where it was diagnosed that an unknown software needed to be updated. The vehicle was repaired but the failure persisted. Lastly, the contact stated that while turned off the vehicle would not turn on. The vehicle was towed to a dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 36,000.
My 2021 Hyundai Kona AWD will not operate. It only has 18,000 miles on it and I bought it new. I had the oil changed at 7,000 miles. The dealership made me wait a month to take a look at it, and I believe that they know there is an issue with this model so they are trying to stall. I plan to request a buyback. The last time I tried to drive it, it died every time the car came to a brake. I had to sit with my emergency lights flashing for a few minutes to get it to start again, only to have it die at the next light. This is very dangerous.
My vehicle was purchased in late June 2023 with Remainder of Hyundai Factory Warranty promised. A few months ago I started hearing a ticking noise from the motor and on 3 different occasions almost stalled while stopped at a traffic light. I took it to CMA's Hyundai of Lynchburg and upon inspection was told I need a new motor due to finding possible aluminum on the piston head of cylinder 4. There was a previous recall on 2021 Hyundai KONA Motors due to faulty piston rings. I am wondering if the defect in my motor may be related. I was told I could not leave/drive my vehicle for my own safety. So my vehicle has been at the dealership since mid-December, 2023. They state the warranty is void.
The contact stated that she was an insurance company claim adjuster who was calling on behalf of an insured consumer, who owned a 2021 Hyundai Kona. The contact stated that while the vehicle was parked and unoccupied, the vehicle caught on fire. The contact stated that there was no warning light illuminated before the incident. The fire department extinguished the fire and filed a report. The contact stated that the insurance company sent an inspector, who determined that the fire originated in the engine compartment. The contact stated that the entire vehicle burned and only the frame remained. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to the federal safety agency Campaign Number: 21V301000 (Engine); however, the VIN was not included. The contact did not know whether the dealer and the manufacturer were contacted. The failure mileage was approximately 23,000.
9/13/2022 I took my vehicle in to the dealer stating the vehicle felt like it was going to stall. I was told there was no code found so they couldn't do anything, passed off as nothing wrong. On 4/1/2023 the vehicle stalled while pulling into a parking lot and a car behind me had to honk because it was going to hit me. I took the vehicle to dealer, they kept it two days, I was told it could not be created, no code found. 7/30/2023 the vehicle stalled on me four times, again I left it at the dealer for two days, vehicle was down 3 qts of oil. Oil consumption test started. During all this I had two open cases with Hyundai corporate. One was closed without my knowledge and the second my case was denied for any kind of help, no engine replacement or vehicle repurchase options provided to me. I was told I could open a case with the BBB which I currently have. I am waiting to hear what is happening with that currently. The vehicle continues to run extremely rough and sluggish, everytime I brake or slow down, I'm afraid it's going to stall. One time previously it did stall on me while driving on an overpass of a business street and I was afraid someone was going to hit me from behind. It's hard to drive a vehicle that everytime to put your foot on the brake or slow down you are afraid it's going to stall and someone is going to hit you from behind. That is a safety risk. When the vehicle has stalled it has been at different speeds, in different instances, like I said, slowing down, braking, pulling in to a parking lot and just driving straight.
At a stop sign, or red light, car bucks, then accelerates. Steering column is making noise. Took car to dealership..stated they can't look at my car until October 31st, 2023! My car only has 16k miles. If this is a dangerous issue, especially the steering colum noise (possibly a bearing issue or rack and pinion problem)..why am I having to wait until October??
I purchased the vehicle on 6/29/23, mileage at purchase was 38,126. Per CarFax ,this vehicle had an oil change at 38,026 miles (at Turnersville Hyundai). I drove this vehicle to Maryland and while there it had stalled 3 times, each time when I was going very slow. I came home to find out that in under 1,000 miles of driving since the last listed oil change, I had burned 2 quarts of oil. Took car back to Turnersville Hyundai where they kept if for 4 days and said they were doing an Oil Consumption Test and Hyundai was notified. There is no way two quarts of oil should burn up while driving under 1,000 miles.
The contact owns a 2021 Hyundai Kona. The contact stated that while driving approximately 35-45 MPH, there was a ticking and knocking sound coming from the vehicle. There were no warning lights illuminated. The vehicle lost motive power, stalled, and failed to restart. The vehicle was towed to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to the federal safety agency Campaign Number: 21V301000 (Engine). The manufacturer was contacted but provided no additional assistance. The approximate failure mileage was 23,700.
The contact owns a 2021 Hyundai Kona. The contact stated that while driving at various speeds, the vehicle would suddenly lost motive power and stalled. After restarting the vehicle, the vehicle operated as designed. The contact indicated that the failure had occurred on four occasions while driving. The vehicle was serviced at the local dealer, but the failure was not corrected. The manufacturer was not yet notified of the failure. The failure mileage was 21,400.
My car has approximately 14,000 miles on it and was purchased brand new. It still has 1,000 miles to go before the next servicing. Saturday I when driving approximately 40 miles an hour, the engine suddenly cut off and the car stopped in the middle of the road. I was able to start the car and drive for approximately 15 minutes before it slowed to 3mph and shut off again. I called the dealership where I purchased it and explained what happened. Initially they said they had not serviced the car in a year. I let the car sit for a day then checked all the fluids. The coolant level was fine and so was the oil. Monday, it cut off twice on my way to work. I drove to the nearest dealership and left it there. I had to rent a car as no loaners are available. It has been at the dealership for 5 days. They thought they fixed but when they test drove it, the car cut out again. Later that day, I received an email from Hyundai Blue link with an Automatic DTC Notification that a possible condition has been detected with my Engine Control System.
Vehicle will not go out of 3rd gear when on the interstate. The vehicle will go pass the redline and hit the fuel cut off and will not accelerate. Have to slow the car down and attempt to speed up again. Vehicle has almost been in accident multiple times due to almost being rear ended because can not get the vehicle up to speed.
Driving 60mph on I-5 in May 2021. Dry roads, no wind. Vehicle suddenly surged (as if we ran over a speed bump at 60mph) despite there being no debris nor damage on the road surface. The surge felt like the ABS system triggered a single pulse, and then car completely turned off: no engine power, no radio power, no cabin lightning power, no dash lighting nor warning lights. Toggling the ignition to accessory didn't help. I had steering authority and brake authority. With no engine power, I pulled over to the side of the road. I inspected the exterior of the vehicle and there was no damage. I entered the vehicle and I was able to restart the vehicle normally. I drove it to a dealership and described the problem, they didn't know what it could be and were 30 days out on booking appointments, so I gave up.
Please refer to Complaint 11488659 filed 10/10/22. I erroneously listed date of incident as 10/4. Incident occurred on 10/5/22, while driving on highway check oil light suddenly came own with knocking and other noises. I was able to pull onto exit ramp before deceleration and total stall with oil running out of bottom of car. I called 911 due to large trucks and traffic stopped behind me. State police came and stayed until AAA towed car to Freysinger Hyundai in Mechanicsburg , Pa (717) 766-8422, where regular maintenance has been done on the car as recently as Sept. 20, 2022. I was advised by [XXX] in Service Dept. That engine had failed with at least 3 months or more wait for replacement parts. I was forced to purchase another vehicle at great expense. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Oct 4,2022, 2021 Kona, 17,600 miles, was operating on highway when suddenly "check oil" light came on and knockin noises began. Able to pull onto off ramp before deceleration and total stall with oil running out of bottom of car. State Police stayed with vehicle due due heavy truck traffic until AAA towed to Freysinger Hyundai in Mechanicsburg, Pa. Diagnosed engine failure with 3 to 6 month wait for necessary parts for repair. Had to purchase another car at great financial loss.
The contact owns a 2021 Hyundai Kona. The contact stated that while driving at various speeds, the vehicle would shut off without warning. The vehicle would restart soon after failure. The contact had taken the vehicle to the dealer where he was informed that his oil level was severely low; however, they were unable to determine the cause of the failure. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 5,000.
The contact owns a 2021 Hyundai Kona. The contact received notification of the federal safety agency Campaign Number: 21V301000 (Engine). The contact stated that while driving at an undisclosed speed, the vehicle consumed an excessive amount of oil. Additionally, the vehicle made loud noises while driving. The vehicle was taken to the dealer on eight separate occasions, and the dealer refilled the oil reservoir every one-thousand miles. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the engine needed to be replaced. The failure mileage was approximately 15,000.
Ongoing issues with the motor consuming oil despite passing a safety recall inspection. Issues with knocking, oil consumption, engine light on. Issues with the dealership fixing the problem. Issues since January of this year. Issues with stalling and motor locking up. Now no oil and not due for oil change, knocking, hesitates, motor light on.
While driving to work car started knocking. As soon as i arrived not even 5 miles from my home, died in my parking lot. Car had no indications of issues. Only information was due for oil change. Checked oil there was none. I was taking it in for service the next day for my regular service check. I was 62 miles over the standard time. Had to pay a tow and found out there is a hole in my engine block. Well with no indication of "Low oil" this brings a question of a information failure>?
The contact owns a 2021 Hyundai Kona. The contact stated that she received notification of the federal safety agency Campaign Number: 21V301000 (Engine) and the vehicle was taken to the dealer who inspected the vehicle and informed her that no issues were found. The contact stated while starting the vehicle, she heard abnormal knocking sounds coming from the engine. There was no warning light illuminated. The vehicle was taken back to the dealer where it was diagnosed that no issues were found; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed that the vehicle had lost 3.5 quarts out of 4 quarts of oil within 4,000 miles. The dealer informed the contact to bring the vehicle back for an oil consumption evaluation after 1,000 miles. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 7,500.
The engine failed at 12,034 miles. I was at the stop light right before the bay bridge and my life and others were severely put at risk. Had I been on the bridge when the engine seized it would have meant imminent death. The Hyundai dealership said they expected it because engines on the 2021 Hyundai Kona have been recalled. This vehicle was supposed to be fitted with a safety light warning the driver of an imminent fire or engine failure after 2019 but that didn’t happen.
The contact owns a 2021 Hyundai Kona. The contact stated while driving approximately 35 MPH for an extended period of more than 30 minutes, the engine would remain running 8-10 minutes after the vehicle had been turned off. On another occasion while driving approximately 35 MPH and entering a highway ramp, the vehicle lost motive power and power steering functionality before independently restarting and operating as designed. The contact stated that the vehicle also stalled while reversing and would restart after shifting into Park. The contact stated that three or four attempts were necessary to restart the vehicle. There was no warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50.
While driving on cruise control set for 45mph the vehicle accelerated to 53 mph. Noticed this multiple times. Also steering wheel making noise and at times hard to turn. All fluids at good level. Then burning smell coming and vehicle revs up when at stop light. And then hard to start. Have had multiple issues with this vehicle. Dealer states all is good. Hyundai is no help. This is a 2021, a new vehicle that should not be acting like this.
The contact owns a 2021 Hyundai Kona. The contact stated that while driving at 20 MPH, the vehicle inadvertently stalled and lost electrical power. The battery warning light, engine warning light, and an unknown warning light were illuminated. The contact veered to the side of the road. The contact was unable to restart the vehicle after several attempts. The contact waited an hour and was able to restart the vehicle and drive; however, the vehicle was shaking while driving. The contact stated that the failure reoccurred while driving. The vehicle was towed to the dealer who diagnosed that the engine had failed and needed to be replaced. The dealer advised the contact that the vehicle would be repaired at her own expense. The contact referenced the federal safety agency Campaign Number: 21V301000 (Engine). The manufacturer was notified of the failure but did not provide any assistance. The vehicle was not repaired. The failure mileage was approximately 21,605.
We have a 2021 Hyundai which is the subject of an engine recall. There have been no repairs to the car and we just turned 5000 miles. When the car is cold and first started the engine knocks and it has gone through 2 quarts of oil so far. The dealership says nothing is wrong with it. I have video of it being started and knocking. We are afraid to park it in our garage due to fire risk and due to the greatly reduced price of repairs the dealer can charge Hyundai, are getting nothing done. The number 1 driver of this car is 88 years old and does not need this stress. Help, please?
The contact owns a 2021 Hyundai Kona. The contact received notification of the federal safety agency Campaign Number: 21V301000 (Engine). The contact had taken the vehicle to a dealer and was informed that the part to do the recall repair was unavailable. The dealer also performed an engine check on the vehicle and found no fault with the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Hyundai Kona?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history