2022 Hyundai Santa Fe Hybrid engine problems

Filed Jan 5, 2026 · Electrical, Engine · MI

While accelerating at a light, the accelerator became unresponsive, only propelling the vehicle a couple miles per hour. I was not able to pull over, as I was in the left lane of a very busy road. After about 15 seconds of lack of acceleration, the accelerator responded enough for me to pull over. I’m glad this incident did not occur on a highway, during a turn, or other hazardous situations. Dash displayed, “Check hybrid system. Pull over safely”. There was no indication or issue with the vehicle prior to this. I haven’t had any issues since I bought it several months ago. I’ve read reports of this same issue happening with this same model. I have a scheduled date for inspection.

Filed Apr 30, 2025 · Engine · OH

Oil leaking from engine dripping down to floor.

Filed Apr 22, 2025 · Engine, Transmission · OR

Ever since new this suv will periodically hesitate when trying to accelerate. I have almost been rearended numerous times over the last few years do to this issue. I have had the SUV into the dealer and complained about this issue every time and they cannot seem to do anything about the issue. The have update software (or at least said they have) and done other things and it has made NO difference. This issue almost caused a serious accident just this week when I was trying to merge into traffic on I5.

Filed Feb 14, 2025 · Electrical, Engine · OK

Our vehicle continues to experience loss of power driving , on cold days below freezing. When driving normally this hybrid vehicle will be in hybrid mode at a stop, then when accelerating, the ICE engine will not start to assist the hybrid, causing a bare minimum of power to be available, just enough to pull over. On several occasions this has led to very near rear end collisions from the driver's behind. So far I've been able to avoid injury, as I recognize the condition and am hyper attentive to its possible happening. The vehicle handed shown any Check engine warnings until yesterday. As it was dying I pumped the accelerator to see if it would go, latching a TPS out of range code. The condition has been brought to Hyundai Corporate and dealerships with no repair, and no resolution, they say it's fine. This is well documented by others driving Santa Fe Hybrids, and Tucson Hybrids on forums. No one fix has been established, with some dealerships replacing parts, and others no work being done because their scan tool sees nothing. With dozens of recalls for minor inconvenience issues, I do not understand why a recall for this drivability safety issue has not been mandated! These vehicles are defective, and potentially very dangerous. Loss of power, acceleration when others are behind you anticipating you to go, is a real serious danger, not to mention you being stranded in frigid weather. This began happening at 23k miles and continues today with 48k miles on mine. If the vehicle is shut off, then restarted, it is again drivable, until the next happening. One reason Hyundai, says nothing's wrong, and often blames the owners. I can't be without a vehicle, and Hyundai has washed their hands on this, so I'm stuck Hyundai must be forced into an investigation, and a safety recall on this or nothing will be done. How many accidents or deaths are required to get a recall accomplished?

Filed Jan 9, 2025 · Electrical, Engine · OK

Headed to my work ,outside temp 26 deg F, when on hiway entrance ramp, vehicle lost all acceleration. Vehicle is a hybrid, condition no warning lights on dash, vehicle was stuck in EV mode, which the ICE engine would not start to help as normally would do. Hybrid battery began draining very quickly. There was a semi truck right behind me accelerating hard to get on highway .This time I managed to pull over on the debris filled shoulder before the system fully shut down as it has done before with the warning ⚠️ HYBRID SYSTEM FAILURE, PULL OVER NOW ! and loud alarm going off. This is a serious loss of total motive power, which I've reported to Hyundai Corporate, and dealerships for repair before, to which they say " we can't duplicate, all systems are fine", and blame me for the problem. Hyundai has washed their hands of this dangerous situation and won't help me. This is the 5th occasion of this problem, I now know from my experience and reading Hyundai forums this issue is wide spread among Hyundai Tucson and Santa Fe hybrids, with some places replacing parts, that doesn't fix the issue. I know how to react by pulling over immediately, shut off the vehicle completely, wait... Then restart the vehicle, and so far ,it will drive normal with no codes or warnings after that, until the next random occasion it happens. This is extremely dangerous in cold weather and around other traffic posing a major collision hazard and stranding someone who knows less about this condition. Hundreds have reported this as per the forums, yet no recall or TSB or real fix has been issued by Hyundai.

Filed Dec 26, 2024 · Engine · 40,000 miles · TX

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving on the highway at 80 MPH, the "power low" warning message was displayed, immediately after the contact vehicle proceeded to decrease in speed. The contact proceeded to pull over onto the side of the road to restart the vehicle. The vehicle was able to successfully restart, and the contact successfully drove to a local dealer where the vehicle was diagnosed however the failure could not be replicated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

Filed Oct 23, 2024 · Acceleration, Engine · NY

Was driving home from work on the highway at highway speeds and suddenly lost the ability to accelerate with a "Check Hybrid System" warning. At the time of loss of power, I was crossing a bridge and got stuck in the middle of the bridge. I also notice the oil indicator light come on. The engine remained on as far as I can tell but it wouldn't go with the accelerator pedal pressed. I placed the car in park and turned off the vehicle while blocking bridge traffic. 15 seconds later, I turned the vehicle back on, vehicle said ready to drive. I put the car in drive and everything worked normally as best I can tell. Still nervous driving the car for fear of it happening again. Called dealer service but they were closed. What I don't understand is there was 2 recalls for Hyundai Sante Fe hybrids 2022 but when I put in my VIN it said no recalls. Why is it only associated with a VIN?

Filed Sep 3, 2024 · Engine, Fuel system · NY

Power loss with no warning or errors - hybrid system frequently fails to start gasoline engine when needed, resulting in sudden power loss and limited to 35 mph without warning. Serious concern at intersections and on major roads.

Filed Jul 24, 2024 · Acceleration, Electrical · CA

I was driving on the freeway when suddenly I heard a clunking sound. Suddenly I was unable to accelerate at all. My speed was 60 mph and I had the gas pedal pressed all the way to the floor. Nothing happened and my speed would not go over 60. Then a message began flashing on my dashboard. I cannot remember the exact verbiage, but something along the lines of Hybrid System Failure. My car began losing speed and I was unable to accelerate to make it go faster at all. I lost complete control of the speed control. I was in the middle lane of a 5 lane freeway and struggling to get over since I was unable to accelerate at all. It was an extremely dangerous situation as I could no longer control the speed of my vehicle on a freeway. Finally, I was able to exit to an off ramp. My car continued to lose acceleration and finally came to a complete stop on a side street. My car was then towed to the dealer and they are unsure what the issue is. On doing some internet research, I have found a lot of postings of people having this same exact issue with the Hyndai Santa Fe Hybrid 2022 and I think it's a dangerous defect in the car.

Filed Feb 13, 2024 · Engine · TX

The car was idling for about 30 mins as I waited for delivery of groceries at curbside pickup. I put the car in drive but the motor did not kick on. I was able to drive on electrical power until the hybrid battery died. I lost complete power in the middle of the Interstate but I was able to coast to the shoulder. I had a check engine light and other warning lights on the dashboard but they went away when I restarted the car