1. 2014 Hyundai Santa Fe Theta 2 Engine Failure It was available for inspection upon request at local dealer and service After engine failedXXX abruptly while driving, it was towed to the service for inspection. 2. The Theta 2 engine in countless 2014 Hyundai Santa Fe models has been a safety risk for all citizens on the roads. This has been an unannounced recall failure due to manufacture shards of metal found within the engine, causing vehicle damage and failure. My car stopped abruptly on the road. I have maintained it through due oil changes and service. 3. The independent dealership that serviced my vehicle has verbally recognized that Theta 2 engines are a safety risk, after my family and I did research to expose underlying cause of engine failure. 4. It has been inspected by Allen Turner Hyundai in [XXX]. No known national manufacturers have been present or documented in case. 5. No, abrupt stop while driving along with burning smells and smoke coming from hood of vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2014 Hyundai Santa Fe Sport engine problems
104 complaints (63% of all complaints for this car). Typical mileage when it fails: 76,000.
- owner complaints
- 104
- of this car's complaints
- 63%
- typical mileage
- 76,000
- crashes
- 0
- recalls
- 2
Which part fails
- Exhaust system: emission control: crankcase (PCV)1
- Engine: oil/lubrication1
At what mileage
Complaints by mileage at the time of the problem.
Hyundai Santa Fe Sport engine problems in other years
Specific symptoms reported on the 2014 Hyundai Santa Fe Sport engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Engine failure 43Check engine light 30Stalling 25Knocking 20Loss of power 15Oil consumption 8
Related recalls
Engine
- What is wrong
- Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V‑568 and 17V‑226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1‑855‑371‑9460. Hyundai's recall number for this recall is 180.
Recall number 18V934000 · Recall details
Engine and engine cooling: engine
- What is wrong
- Hyundai Motor America (Hyundai) is recalling certain 2013-2014 Sonata and Santa Fe Sport vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
- Risk
- Bearing wear may result in the engine seizing, increasing the risk of a crash.
- Remedy
- Hyundai will notify owners, and dealers will inspect the engine, replacing the engine short block, as necessary, free of charge. The recall began June 2017. Owners may contact Hyundai customer service at 1‑800‑633‑5151. Hyundai's number for this recall is 162.
Recall number 17V226000 · Recall details
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V‑568, 17V‑226, 20V‑746, and 21V‑727; and Kia recalls 17V‑224, 19V‑120, 20V‑750, and 21V‑844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V‑877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines.  The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS.  It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to
EA21003
What 2014 Hyundai Santa Fe Sport owners say
Most recent owner complaints, unedited.
The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while driving approximately 30 MPH, there was smoke coming from the engine compartment with an abnormal burning odor entering the vehicle through the A/C vents. The vehicle was pulled over to the side of the road and turned off. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to a dealer and was diagnosed and determined that the engine needed to be replaced. The contact stated that her father performed most of the maintenance on the vehicle and became aware that the Theta 2 engine had several failures. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 157,596.
The contact owns a 2014 Hyundai Santa FE. The contact stated that while driving the vehicle at 60 mph the vehicle began to shake violently, and the engine experienced a complete loss of automotive power, the service vehicle soon, ABS and check engine warning lights were illuminated. The contact veered off an exit into the parking lot of an AutoZone where a diagnostic scanner displayed the code "P0302". The vehicle was towed to an independent mechanic where it was diagnosed, and the contact was advised that the exhaust valve on cylinder two had dissolved and needed to be replaced. The vehicle was towed to a local Hyundai dealer where it was diagnosed, and the contact was advised that the exhaust valve in cylinder two was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 89,687.
On June 20, 2026, while the 2014 Hyundai Santa Fe Sport was being driven on Richardson Highway near Mile 155 in Alaska, smoke and flames developed from the engine compartment without any collision. The driver stopped and both occupants exited before the vehicle became fully engulfed. The fire created an immediate risk of serious injury or death and blocked the northbound lane. There were no known prior drivability problems, warning lamps, or other symptoms before the incident. The exact failed component is UNKNOWN. Potential areas requiring investigation include the engine, electrical system, ABS/HECU brake module, multi-fuse, fuel system, and other engine-compartment components. Alaska Department of Public Safety responded. Its report states that there was no obvious cause, but that the fire appeared to have originated in the engine compartment. The vehicle was towed and preserved for the manufacturer. Hyundai inspected the vehicle and confirmed that the inspection was completed on July 11, 2026. Hyundai later stated orally that it did not find an engine defect, but it has not provided the complete inspection report, testing methods, photographs, technical findings, or a written origin-and-cause determination. Hyundai has not explained whether the ABS/HECU, electrical system, multi-fuse, fuel system, or other potential fire sources were separately examined. The vehicle sustained catastrophic damage and was a total loss. Both occupants escaped, but experienced severe ongoing psychological distress after the fire. I request that the federal safety agency evaluate whether the fire involved an engine, electrical, ABS/HECU, fuel-system, recall-remedy, or other safety defect. The vehicle was available for Hyundai's inspection. Its current availability for further inspection is UNKNOWN. The vehicle remains preserved and is currently available for further inspection upon request.
The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while driving at undisclosed speeds, the vehicle started to lose power while depressing the accelerator pedal, with black smoke coming from the engine compartment. The oil, check engine, and battery warning lights were displayed on the instrument panel. The contact pulled over and discovered black smoke coming from under the hood. Due to the failure, the vehicle was towed to an independent mechanic, and the engine was replaced. Two weeks after the replacement, the starter failed to operate as needed, and the vehicle was towed back to the independent mechanic, where the starter was replaced. Upon investigation, the mechanic discovered the federal safety agency Campaign Number: 17V226000 (ENGINE AND ENGINE COOLING); and associated the vehicle with the recall. The contact was referred to the federal safety agency Hotline to report the failure. The vehicle remained with the independent mechanic and was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,577.
On March 20, 2026, while driving, my 2014 Hyundai Santa Fe Sport (VIN: [XXX]) equipped with a Theta II 2.4L GDI engine, the car experienced a catastrophic, sudden loss of motive power. The engine suffered a total mechanical failure/seizure, creating an immediate highway safety hazard. This vehicle is part of the "In re: Hyundai and Kia Engine Litigation II" settlement population due to known factory manufacturing defects where residual metal debris blocks oil flow to the connecting rod bearings. Hyundai Corporate has issued a blanket refusal to honor the lifetime safety warranty extension, using an unverified allegation of "outside influence" to avoid executing the mandatory engine replacement protocols required under the federal safety agency Campaign T3G. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ID # 11746004. I accidentally entered the wrong incident date on my original submission. The correct date of the incident is June 17, 2026. Please update my file to reflect this correct timeline.
The engine failed completely and is currently available for inspection at my residence. While traveling on a family vacation at highway speeds, the engine suffered a catastrophic connecting-rod bearing failure and seized. This caused an immediate loss of motive power, braking assistance, and steering control, nearly resulting in a fatal multi-car collision with my child in the vehicle. Warning lights illuminated on the dashboard during the failure as a sudden metallic knocking sound occurred and the engine died. The vehicle became completely disabled and had to be limped off the highway and towed. The VIN has a completed Campaign 953 from September 2019 qualifying it for the Lifetime Warranty Extension under the Theta II settlement.
Engine code p1326. The engine went into limp mode it was only able to drive about 15 miles then check engine light came popped on and the vehicle stopped and I had the get the vehicle towed. Yes Route 60 of Hyundai in Vero Beach was aware of the issue and also I took the vehicle to Hyundai in Fort pierce where they also was well aware of the engine issue. When I received a recall letter in the mail and brought my vehicle into Route 60 Hyundai of Vero Beach. My vehicle was also apart of the Theta 2 issue class act litigation.
Failure consistent with known recall defect (the federal safety agency Recall 17V226) involving premature bearing wear resulting in engine seizure and sudden loss of power while driving.
Questions about the 2014 Hyundai Santa Fe Sport engine
Does the 2014 Hyundai Santa Fe Sport have engine problems?
Owners have filed 104 complaints about the engine of the 2014 Hyundai Santa Fe Sport, 63% of all its complaints, more than any other problem.
At what mileage do 2014 Hyundai Santa Fe Sport engine problems start?
The typical (median) mileage in owner complaints is 76,000 miles.
Was there a recall on the 2014 Hyundai Santa Fe Sport engine?
Yes, 2 recalls: 18V934000, 17V226000. Check your VIN to see if your car still needs the free repair.
What year does the Hyundai Santa Fe Sport have bad engine?
The Hyundai Santa Fe Sport model years with the most engine complaints are 2017 (221 complaints), 2018 (208 complaints) and 2013 (121 complaints).
Other 2014 Hyundai Santa Fe Sport problems
Brakes 30Electrical 22Transmission 13Fuel system 10Body 8Driver assistance 8Acceleration 7Steering 5Airbags 2Seat belts 2Suspension 2Lights 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2014 Hyundai Santa Fe Sport?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history