2016 Hyundai Santa Fe brakes problems

Filed Mar 24, 2025 · Brakes · 119,000 miles · GA

The contact owns a 2016 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the contact stated that the brake pedal was inoperable. The contact stated that the vehicle vibrated while depressing the brake pedal. There was no warning light illuminated. The vehicle was restarted. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the ABS module had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 119,000.

Filed Oct 1, 2024 · Brakes, Engine · CA · fire

Driving on a slight upgrade, lost power and smoke started to come out of the vents and from under the hood. Had no brakes and by the time we were able to drift to a stop, the engine compartment was on fire. There was no warning lights. Witnesses saw fire under the car while we were coming to a stop. The car and all contents were totally consumed. Following some research on the federal safety agency vin decoder we found that this car has the same engine (GDI THETA II) that has been involved in many fires and is involved in class action suits. Even though this car has the same engine, it was never recalled. That may indicate that there are other cars out there that may have the same problem but have not been informed.

Filed Sep 14, 2024 · Brakes · MA

None

Filed Aug 2, 2024 · Brakes, Electrical · MO

Abs system is randomly locking up calipers causing a dangerous speed wobble. Dealership can't re create so won't diagnose. Have had to replace all brake calipers and components were near new but ruined because of abs applying brakes when unnecessary. Vehicle is very unsafe to drive, pulled hard to left at one point veering me into oncoming traffic. Independent mechanic has made caliper release by manually releasing abs system. Same results were not found by releasing pressure at master cylinder making abs the obvious culprit. No warning lights but I just replaced two cracked rotors on rear at 130k miles. That should not happen. Has caused hub readings of 270 on three different tires at 3 different times. Santa fe has recall on this system for every year but mine, very curious as to why not. If this was not a dealership only part , it might not be such a big issue, but being it is main source of stopping a 4000 lb vehicle, I have concerns. Hyundai dealership was very condescending and of little to no help. I have an Independent are certified mechanic who is happy to talk with you if needed. Please help, as of right now am.making payments on an unsafe vehicle with not much hope of it being fixed.

Filed Mar 19, 2024 · Acceleration, Brakes · IN

My car started accelerating on its own, out of nowhere. There were no prior indications. No prior damage. It began accelerating on its own. After shutting the vehicle off and turning it back on, the issue has persisted. Anytime it is in drive or reverse, it accelerates at an extreme rate. It also disabled the brake, when the acceleration began.

Filed May 16, 2023 · Acceleration, Brakes · MI

I was driving my 2016 Hyundai Santa Fe to my morning job, & noticed a slight trembling of the vehicle initially. Upon approaching a stop sign at a 2 way stop, I noticed that my brakes were not fully engaging so I pumped them a couple times. Immediately my car started accelerating on its own faster and faster until my brakes were not stopping the car at all even with my foot pushing the brake pedal down as far as possible. My foot wasn’t on the accelerator at all. I noticed a pickup truck about to cross the intersection for which I needed to stop. Because I had no control over the car to get it to stop, I slammed the car into park, & it finally stopped just before my car crossed through the intersection. If I had not done that I would’ve been hit directly on my drivers side door by a truck going at least 55 mph. The car revved really high for several seconds after putting the car in park. I drove 10 mph to my work destination, & experienced exactly the same symptoms when I was pulling into my parking spot. As soon as I started braking to come to a stop to park, the car immediately started to accelerate again beyond my control & the ability to engage my brakes, even with my brakes pushed down as far as they would go. Again I slammed the car into park, otherwise my car would’ve run through the side of a barn & a horse stall with a horse and the barn owner inside. I checked to make sure nothing was impeding the movement of my accelerator and braking pedals, and nothing was. No warning lights came on at any time. I am very concerned as I am reading multiple reports of almost identical incidents for other Hyundai Santa Fe owners of a variety of years, & because this issue can’t be reproduced, there is no recall, and no code comes up, owners are not being given a solution or any type of support by Hyundai dealers or the manufacturer itself. I absolutely do not feel safe driving my car for my own safety & the safety of those on the road with me. I was almost killed today.

Filed Mar 16, 2023 · Brakes, Steering · IL

While driving the car experienced a catastrophic engine failure as well as loss of steering and brakes. Was able to get to the side of the road without injury. This could have resulted in injury or loss of life if the drivetrain would have locked up. The vehicle is at the dealer now, after a 250-mile tow. The dealer said that they have eight cars at their dealership with the same blown engine issue. No warning lights came on prior to the incident.

Filed Jan 23, 2023 · Brakes · CA

The contact owns a 2016 Hyundai Santa Fe. The contact received notification of the federal safety agency Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Nov 29, 2022 · Brakes · OH

The contact owns a 2016 Hyundai Santa Fe. The contact received notification of the federal safety agency Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Nov 25, 2022 · Brakes · TN

The contact owns a 2016 Hyundai Santa Fe. The contact stated that the brakes made an abnormal squealing sound upon depression of the brake pedal without warning. The contact also stated that the vehicle would jerk forward while accelerating. The contact then received a notification for the federal safety agency Campaign Number: 22V056000 (Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. The local dealer and manufacturer were notified about the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The failure mileage was unknown.